2018 Ford Focus recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Range & efficiency

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Fuel/propulsion system

  when the vehicle accelerates too quickly or up a very gradual hill, barely any slope, it will slow to a stop. this is in line with the current recalls with other Ford focus 2018s likely caused by the Canister Purge Valve. it has the exact same symptoms, poor fuel economy, rough idling so much so the entire vehicle shakes, and the dangerous part- stalling. I have now stalled 4 times and have been in and out of multiple mechanics for this issue and no one can seem to identify the root and it's getting costly. now they are saying it might be the canister purge valve but if it is I think it should be covered despite my vin not being perfectly aligned because it's ultimately the same issue with…

  Oct 4, 2026
• Engine

  The contact owns a 2018 Ford Focus. The contact stated that after the vehicle was repaired under a recall, while driving 45 MPH, the vehicle unexpectedly idled, causing the engine to misfire with the check engine warning light illuminated. The contact stated that the vehicle sputtered during the misfire. The vehicle was taken to the dealer, where the contact was informed that the engine needed to be repaired. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer to be diagnosed, and it was determined that the cylinder wall had failed and the engine needed to be replaced. The contact was concerned that the failure was caused by an improper recall…

  Aug 28, 2026 · 63,126 miles
• Power train

  My car had been driving fine. Until one day I leave my house and crank my car up and it does not go into reverse. It loses engine power and stalled into traffic. This is an on going issue as you can see stories from other people with the same make and model as my car with the same issue. No warning signs, hasn’t been checked out but I have contacted Ford and they only cover models with this issue 2012-2016. I think it should cover 2018 as well.

  Sep 22, 2026
• Vehicle speed control

  "My 2018 Ford Focus was traveling uphill at highway speed. I fully depressed the accelerator because the vehicle was losing speed. The vehicle did not respond with additional acceleration and subsequently continued to lose speed despite the accelerator remaining fully depressed. The dealership inspected the vehicle and told me that the engine is not powerful enough for sustained uphill driving and that the vehicle performed as designed. I am reporting this because I am concerned about the loss of ability to maintain speed despite full accelerator input and whether this constitutes a safety defect."

  Jul 25, 2026
• Engine and engine cooling

  The contact owns a 2018 Ford Focus. The contact stated that on several occasions while driving uphill, the vehicle lost power, the check engine warning light illuminated, and the message "Engine Fault" was displayed. The contact inspected the vehicle and noticed that the check valve on the vacuum pump had separated. The check valve was replaced every 1,000 miles. The contact stated that while driving approximately 35 MPH, the vehicle lost power and the oil warning light flashed. The vehicle was taken to the residence and parked. The contact inspected the vehicle and checked the dipstick, noticing bits of rubber inside the oil. The failure mileage was approximately 32,000.

  Sep 15, 2024 · 32,000 miles
• Engine

  My Ford vehicle has experienced repeated and significant engine problems that have never been successfully resolved despite numerous repair attempts at multiple Ford dealerships. The engine has been repaired/rebuilt multiple times, yet the underlying issue has continued and the engine has now seized. Most concerning, the vehicle unexpectedly shut off. Fortunately, it started again yesterday, but I do not consider it safe to drive because I am concerned it could shut off again while being driven, causing a sudden loss of power and creating a serious safety risk. Ford is declining further assistance because the vehicle odometer is approximately 105,000 miles. However, the engine has been…

  Sep 12, 2026
• Engine

  First my wind shield wipers were coming on by themselves and not cutting off when I flicked the switch. Now my car is jerking when I press the gas to drive and sometimes moving in reverse after I press the gas to drive. Jerking and barely accelerating, then it decides to driver in between gaps. My safety is put at risk because sometimes it slows down or barely accelerates in oncoming traffic and moves backwards when cars are behind me at a light or stop sign. Manufacture by others which is a neighborhood auto shop. Just the check engine light came on.

  Aug 1, 2026
• Fuel/propulsion system

  There was supposedly a recall of 2012-2018 Ford focuses such as mine, which is a 2018, but somehow my car is not included in this recall even though it seems to be affected by the same problem. I believe it to have a faulty purge valve (forgive me if I am not precise in my terminology) as it stalls after I get gas and try to start it up. I have to rev the engine to get it to stay on. I cannot stop after I get it started because it roughly idles and seems like it will shut back off if I do, which makes this a little dangerous as well as damaging for my car. I am distressed that my car is not included in this recall because I desperately need to repair it before I ruin my engine but I cannot…

  Sep 2, 2026

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• Timing Belt FailureOpen

  On December 18, 2025, the Office of Defects Investigation (ODI) opened PE25020 to investigate instances of timing belt failure in model year (MY) 2015-2017 Ford Fiesta and MY 2015-2018 Ford Focus vehicles manufactured by Ford Motor Company (Ford), equipped with a 1.0L engine and manual transmission (subject vehicles). Additionally, MY 2018-2021 Ford EcoSport and MY 2016-2018 Focus vehicles with a 1.0L engine and automatic transmission were analyzed as peer vehicles because they utilize a wet timing belt comprised of similar material as the timing belt in the subject vehicles. Through the PE, ODI investigated a potential failure/degradation of the timing belt that may affect oil pump function resulting in a lack of engine lubrication and potential loss of motive power. The complaints commonly allege a low engine oil pressure warning lamp immediately preceding a complete loss or…

  EA26004 · opened Jul 31, 2026
• Timing Belt FailureClosed

  On December 18, 2025, the Office of Defects Investigation (ODI) opened PE25020 to investigate instances of timing belt failure in model year (MY) 2015-2017 Ford Fiesta and MY 2015-2018 Ford Focus vehicles manufactured by Ford Motor Company (Ford), equipped with a 1.0L engine and manual transmission (subject vehicles). Additionally, MY 2018-2021 Ford EcoSport and MY 2016-2018 Focus vehicles with a 1.0L engine and automatic transmission were analyzed as peer vehicles because they utilize a wet timing belt comprised of similar material as the timing belt in the subject vehicles. Through the PE, ODI investigated a potential failure/degradation of the timing belt that may affect oil pump function resulting in a lack of engine lubrication and potential loss of motive power. The complaints commonly allege a low engine oil pressure warning lamp immediately preceding a complete loss or…

  PE25020 · opened Dec 18, 2025 · closed Jul 31, 2026
• Oil Pump FailureClosedLed to recall 23V905

  On September 20, 2023, the Office of Defects Investigation (ODI) opened PE23-015 to investigate instances of engine failure due to loss of oil pressure in model year (MY) 2018-2021 Ford EcoSport vehicles. Some consumers reported a low engine oil pressure warning lamp immediately preceding a complete loss or reduction of motive power while the vehicle was in motion. The investigation revealed that the engine oil pump drive belt tensioner arm may fracture, separate from the tensioner backing plate, and/or the oil pump drive belt may degrade and lose teeth, resulting in a loss of engine oil pressure. A loss of engine oil pressure can result in engine seizure, which can result in a loss of motive power and a loss of mechanical vacuum pump required to provide power braking assist, increase the risk of a crash. On December 22, 2023, Ford filed recall 23V-905 for certain MY 2016-2018 Ford…

  PE23015 · opened Sep 20, 2023 · closed Feb 14, 2024
• Loss of Motive PowerClosed

  On September 15, 2023, the Office of Defect Investigation (ODI) opened this Recall Query (RQ) after receiving 98 consumer complaints alleging loss of motive power in model year (MY) 2012-2018 Ford Focus vehicles. The RQ focused on the effectiveness of the remedies of Recall 18V-735 and 19V-515. In October 2018, Ford issued Recall 18V-735, which updated Powertrain Control Module (PCM) software in MY 2012-2018 Ford Focus vehicles equipped with 2.0L GDI engines built prior to April 13, 2017, and those with 2.0L GTDI engines built prior to February 2, 2018. The recall addressed vehicles experiencing a malfunctioning Canister Purge Valve (CPV) that can stick open and PCM software that does not adequately detect a stuck-open CPV condition. A CPV that is stuck open can cause excessive vacuum in the fuel vapor management system, potentially deforming the fuel tank, collapsing on itself. This…

  RQ23006 · opened Sep 15, 2023 · closed Dec 20, 2024
• Pedestrian alert soundsClosedLed to recall 22V063000

  NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review…

  DP22005 · opened Jan 27, 2023 · closed Aug 7, 2023