*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Equipment
The contact owns a 2020 Georgetown Forest River RV built on a 2019 Ford F53 chassis. The contact received notification of NHTSA Campaign Number: 24V103000 (Equipment) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool showed no open recall.
Feb 12, 2024Unknown or other
While driving down [XXX] in Denver the front welds holding the propane tank broke. This left the propane tank at an angle only supported by the rear welds. Was fortunate that another RVer flagged us over and we were able to get off the highway and used a ratchet strap to support it so we were able to drive to get the bracket welded back into place. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Feb 6, 2024Unknown or other
While a mobile welder was repairing the cracked rear bracket holding the ASME propane tank (NHTSA complaint #11555667) he repaired another full-depth crack, this one on the actual ASME propane tank mounting flange itself. This flange is welded to the tank by the tank manufacturer. This cracked tank flange is bolted directly to the cracked rear angled mounting bracket reported on Nov. 17, 2023. The tank mounting flange crack was close to an inch long and cracked at a gusset on the rear, outer mount of the tank ("outer" means nearest the propane compartment door). Please see the top and bottom pics. This second crack had rust in it on the top but was only partially rusted on the bottom, as if…
Nov 16, 2023Unknown or other
Another owner of a 2020 Forest River Georgetown GT5 model 34H5 just posted a pic of a crack at the 90-degree bend in the rear propane tank mounting bracket. This is an ASME tank that can contain 19.5 actual gallons of propane. Previous ASME propane tank mounting bracket cracks reported by owners of Georgetowns were all on the front propane tank mounting bracket and were broken welds that allowed one end of the propane tank to drop almost to the road while driving. They were NOT a crack at the 90-degree bend in the bracket and also NOT on the rear bracket. I just cut three tie wraps to expose that bend on our 2020 Georgetown GT5 34H5 and my rear propane tank mounting bracket is cracked in…
Nov 17, 2023Structure
Our propane tank got detached. Very dangerous. Posted on our Georgetown Facebook page and someone told me this is a known issue and I should report it.
May 29, 2023Structure
Two owners of Forest River Georgetown Class A motorhomes, one a 2020 model year and one a 2022 model year, reported on a forum that one of the two brackets holding their 24.5 gallon water capacity ASME propane tank in place had its tack welds break, allowing one end of the tank to drop so far it was visible by passing cars. Both reported they were flagged down by people passing them. (The end of the propane tank likely was bouncing up and down on the remaining bracket.) Both used a strap to hold the tank in place until the bracket could be re-welded. Both reported that the repair shop then installed two bolts through the front and rear bracket to help hold the tank in place if the welds…
May 27, 2023Structure › Body
Weld seams broken on battery shelf which holds 4 27D Batteries. If I had not noticed this problem the batteries would have fallen to the road below, and possibly cause injury.
Aug 30, 2022Unknown or other
Windshield developed a stress crack starting at the bottom-center, and is growing vertically. Several other owners have reported the same issue, originating in the same exact spot. Some have reported that the original windshield was too large and, consequently, did not leave sufficient room for caulking at the bottom. Others have reported that a defect in the vehicle's dash causes it to press against the windshield. This has been reported to the factory by numerous other owners, and the factory refuses to correct the issue.
Jun 29, 2022
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.