Model year record

2002 GMC Safari recalls & problems

The 2002 GMC Safari has 3 safety recalls and 25 owner complaints on file with NHTSA. The most-reported problem area is service brakes, hydraulic (11 complaints).

Recalls3safety recalls

Complaints25filed by owners

Crashes · fires4 · 1reported in complaints

Injuries · deaths2 · 0reported in complaints

Safety recalls

Fuel system, gasolineMay 19, 2006

Fuel system, gasoline

Recall 06E04300088,303 vehicles

Problem: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Risk: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Fix: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Exterior lightingMar 23, 2006

Exterior lighting

Recall 06E02600061,944 vehiclesopened after NHTSA action (OVSC)

Problem: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Fix: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Exterior lightingMar 14, 2005

Brake lights › Switch

Recall 05V09900077,055 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN MINIVANS, THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE.
Risk: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD LEAD TO A VEHICLE CRASH.
Fix: DEALERS WILL REPLACE THE HAZARD WARNING FLASHER SWITCH AND APPLY SPECIAL GREASE TO THE CONTACTS AT THE TIME OF INSTALLATION OF THE MODULE FREE OF CHARGE. THE REPAIR WOULD BE USED IN VEHICLES IN WHICH THE HAZARD SLIDER BUTTON IS STILL MOVABLE. IF A VEHICLE HAS A HAZARD SLIDER BUTTON THAT IS NOT MOVABLE (FROZEN), THE ENTIRE MULTIFUNCTION SWITCH WILL BE REPLACED. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2002 GMC Safari

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Safari 2WD (cargo)

17mpg combined

City / highway	15 / 20 mpg
Fuel	Regular Gasoline

4.3 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,950/year to fuel

Safari 2WD (Passenger)

16mpg combined

City / highway	14 / 18 mpg
Fuel	Regular Gasoline

4.3 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,200/year to fuel

Safari AWD (cargo)

15mpg combined

City / highway	14 / 18 mpg
Fuel	Regular Gasoline

4.3 L · 6 cyl · Automatic 4-spd · 4-Wheel or All-Wheel Drive · about $4,450/year to fuel

Safari AWD (Passenger)

15mpg combined

City / highway	13 / 17 mpg
Fuel	Regular Gasoline

4.3 L · 6 cyl · Automatic 4-spd · 4-Wheel or All-Wheel Drive · about $4,450/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Disc › Pads	11	2	0	0	26,037 mi
SuspensionFront; Front › Hub	4	0	0	0	—
Electrical systemIgnition › Module	3	0	1	0	—
VisibilityWindshield; Power window devices and controls	3	0	0	0	—
SteeringHydraulic power assist › Pump; Linkages › Arm › Idler and attachment	2	0	0	0	—
EquipmentElectrical	2	0	0	0	—
Air bags	2	2	0	2	—
Vehicle speed controlLinkages	1	0	0	0	—
StructureBody › Door	1	0	0	0	—
Interior lighting	1	0	0	0	—
Unknown or other	1	0	0	0	—
Engine and engine coolingCooling system › Radiator assembly	1	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Air bagsCrash1 injury
TL* THE CONTACT OWNS A 2002 GMC SAFARI. WHILE DRIVING 45 MPH, THE CONTACT'S VEHICLE WAS STRUCK ON THE DRIVER'S SIDE BY A 2006 DODGE CARAVAN. THE CONTACT'S VEHICLE THEN CRASHED INTO A POLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED LOWER BACK PAIN, A BRUISED TOE, A FOREHEAD GASH, AND DAMAGE TO THE RIBS. MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. *TT UPDATED 8/21/18*JB
Oct 31, 2017 · 100,000 miles
Service brakes
FRONT BRAKE LINE RUSTED OUT AND FAILED, NECESSITATING EXPENSIVE REPAIR AND REPLACEMENT. *TR
Apr 2, 2013 · 92,000 miles
Service brakes, hydraulic
MY 2002 GMC SAFARI WOULD NOT START. I WENT AND REPLACED THE 2.5 YEAR OLD BATTERY (IT WAS LEAKING AT THE TERMINALS) IT STARTED ONE TIME AND THEN ABOUT 45 MINUTES LATER IT WAS DEAD AGAIN. IT WAS TOWED TO THE DEALER. I WAS FIRST INFORMED THAT THE CHARGING SYSTEM WAS O.K. AND THAT THE PROBABLE CAUSE WAS THE BATTERY WAS NOT FULLY CHARGED. I WAS THEN INFORMED THAT THE BRAKE LIGHT WAS ON THE DASH AND A BRAKE LINING WAS LEAKING. THEY RECOMMENDED TO REPLACE BOTH LININGS AND FLUSH THE SYSTEM AND FILL WITH FRESH FLUID. AFTER SEVERAL HOURS I WAS TOLD THAT WHEN THE PARTS CAME AND THE TECH WAS TO INSTALL THE LININGS THAT THE FLUID WAS SMOKING AND THE TECH ALMOST BURNED HIS HANDS. THE VEHICLE WAS ON THE…
May 16, 2009 · 76,306 miles
Suspension › Front › Wheel bearing
TL*THE CONTACT OWNS A 2002 GMC SAFARI. WHILE DRIVING 5 OR 6 MPH, IT TOOK 40-50 FEET BEFORE THE CONTACT COULD STOP THE VEHICLE. A MECHANIC STATED THAT BOTH THE PASSENGER AND DRIVER SIDE WHEEL BEARINGS AND IDLER ARMS NEEDED TO BE REPLACED. THE LOCAL MECHANIC PERFORMED THE REPAIRS. GMC DENIED HIM REIMBURSEMENT BECAUSE THEY DID NOT MAKE THE REPAIR. THE CONSUMER HAD THE REPAIRS MADE A AN INDEPENDENT SHOP THE CURRENT MILEAGE WAS 28,550 AND FAILURE MILEAGE WAS 28,530. UPDATED 5/5/08 *CN UPDATED
Mar 11, 2008 · 28,530 miles
Exterior lighting › Brake lights › Switch
TL*THE CONTACT OWNS A 2002 GMC SAFARI. THE CONTACT STATED THAT THE BRAKE LIGHTS WORKED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THEY STATED THAT THE REPAIR REQUIRED THEM TO DISMANTLE SOME OF THE MAJOR COMPONENTS TO BETTER ACCESS THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED REQUESTING INFORMATION ON NHTSA CAMPAIGN ID NUMBER 05V099000 (EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH), BUT THE VIN WAS NOT INCLUDED IN THE RECALL. THE CURRENT MILEAGE WAS 44,500 AND FAILURE MILEAGE WAS 28,000. UPDATED 03/26/08. *LJ
Jan 1, 2006 · 28,000 miles
Service brakes, hydraulic › Foundation components › Disc › Pads
TL*THE CONTACT OWNS A 2002 GMC SAFARI. THE CONTACT STATED THAT THE VEHICLE'S BRAKES SQUEAKED AND SHE HAD THE BRAKE PADS REPLACED. THE PADS WERE REPLACED A SECOND TIME AT 40,000 MILES. THE BRAKES CONTINUE TO SQUEAK. THE VEHICLE'S PURCHASE DATE AND ENGINE SIZE WERE UNKNOWN. THE CURRENT MILEAGE IS 68,000 AND FAILURE MILEAGE WAS 22,000.
May 2, 2003 · 22,000 miles
Power train › Automatic transmission
HAD TO REPLACE TRANSMISSION AT 39,000 MILES. THEN AGAIN AT 131,000 MILES. NOW IT IS BACK IN THE SHOP WITH TRANSMISSION PROBLEMS YET TO BE DETERMINED AT 149,000 MILES. JUDGING FROM THE COMPLAINTS ON THE INTERNET, THIS SEEMS TO BE A DEFECT THAT IS COSTING THE CONSUMER A BUNDLE OF MONEY. SO FAR I HAVE SPENT OVER $3000 TO REPAIR THE TRANSMISSION. I AM NOW WAITING TO HEAR HOW MUCH MORE I WILL HAVE TO SPEND. THIS NEEDS TO BE INVESTIGATED. *JB
Aug 1, 2003 · 39,000 miles
Suspension › Front › Hub
WHEN BACKING OUT OF GARAGE BRAKES FAILED AND THE PEDAL WENT ALL THE WAY TO THE FLOOR. DEALER TOLD ME THERE WAS NO BRAKE PROBLEMS, BUT COULD BE ABS SENSORS RUSTED OR HAD DIRT BUILD UP. THE DEALER CLEANED ABS SENSORS AND SPRAYED A RUST INHIBITOR ON SENSORS AND HUBS , AND SAID THEY HOPED THIS WOULD SOLVE THE PROBLEM. IF PROBLEM PERSISTS TO COME BACK.*AK
Jan 9, 2006 · 43,514 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

LOSS OF BRAKE LAMP ILLUMINATIONClosedLed to recall 05V099000
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE…
PE04072 · opened Oct 19, 2004 · closed Mar 21, 2005