Model year record

2001 GMC Yukon XL recalls & problems

The 2001 GMC Yukon XL has 5 safety recalls and 120 owner complaints on file with NHTSA. The most-reported problem area is service brakes, hydraulic (34 complaints).

Recalls5safety recalls

Complaints120filed by owners

Crashes · fires6 · 0reported in complaints

Injuries · deaths6 · 2reported in complaints

Safety recalls

WheelsDec 17, 2007

Hub

Recall 07E106000130,000 vehicles

Problem: CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Risk: WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Fix: FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.

Service brakes, hydraulicAug 29, 2005

Antilock/traction control/electronic limited slip

Recall 05V3790001,353,718 vehiclesopened after NHTSA action (ODI)

Problem: CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.
Risk: THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.
Fix: DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Fuel system, gasolineApr 14, 2005

Delivery › Fuel pump

Recall 05V155000316,508 vehiclesopened after NHTSA action (ODI)

Problem: CERTAIN TRUCKS AND SPORT UTILITY VEHICLES WERE BUILT WITH FUEL MODULE RESERVOIR ASSEMBLIES THAT CONTAIN FUEL PUMP WIRES CONNECTORS MAY OVERHEAT UNDER CERTAIN OPERATING CONDITIONS.
Risk: IF THE IGNITION CIRCUIT WIRE IS EXPOSED, THE FUEL PUMP FUSE WILL BLOW, DISABLING THE FUEL PUMP AND CAUSING AN ENGINE STALL OR NO-START CONDITION. IF SUFFICIENT HEAT IS CONDUCTED TO THE PASS-THROUGH CONNECTOR, A HOLE IN THE CONNECTOR MAY RESULT, WHICH MAY CAUSE A 'SERVICE ENGINE SOON' LIGHT TO BE ILLUMINATED DURING THE EMISSION SYSTEM DIAGNOSTIC ROUTINE. FUEL VAPOR AND IN SOME CASES LIQUID FUEL MAY LEAK OUT OF THE FUEL TANK THROUGH THE HOLE IN THE CONNECTOR BODY. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. ALSO IF THE IGNITION CIRCUIT OR GROUND WIRE IS EXPOSED AND SHORTS TO THE FUEL LEVEL SENDER CARD WIRES, INACCURATE FUEL LEVEL READINGS MAY RESULT.
Fix: DEALERS WILL REMOVE THE FUEL TANK, AND REMOVE THE MODULE RESERVOIR ASSEMBLIES FROM THE TANK, AND INSTALL A NEW SERVICE KIT FREE OF CHARGE. AN INTERIM LETTER TO OWNERS WAS MAILED ON MAY 25, 2005. THE OWNERS WERE RE-NOTIFIED ON OCTOBER 19, 2005, SINCE PARTS ARE NOW AVAILABE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.

Seat beltsMay 17, 2001

Front › Retractor

Recall 01V1590009,196 vehicles

Problem: VEHICLE DESCRIPTION: PICKUP AND UTILITY TRUCKS. SOME OF THESE VEHICLES HAVE AN INTERNAL COMPONENT IN THE OUTBOARD SEAT BELT RETRACTORS FOR THE 2ND AND 3RD ROW OF SEATS THAT COULD BE CRACKED. WITH REPEATED ACTUATION OF THE LOCKING MECHANISM, THE CRACK COULD SPREAD TO THE POINT SUCH THAT THE SEAT BELT WOULD NO LONGER LOCK.
Risk: IN A CRASH, INCREASED OCCUPANT INJURY COULD RESULT FROM THE NO-LOCK CONDITION.
Fix: DEALERS WILL INSPECT THE OUTBOARD SEAT BELTS FOR SPECIFIC LOT NUMBERS AND REPLACE THE BELTS IF NECESSARY. GM IS ENCLOSING AN INSPECTION PROCEDURE FOR THE OWNERS TO USE OR THEY CAN HAVE THEIR DEALERS DO THE INSPECTIONS. OWNER NOTIFICATION BEGAN JULY 2, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

StructureOct 25, 2000

Body

Recall 00V34300035,659 vehicles

Problem: VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE LOOSE OR MISSING REAR WHEELHOUSE PLUGS. UNDER CERTAIN VEHICLE OPERATING CONDITIONS, EXHAUST GASES CAN FLOW FORWARD AND ACCUMULATE IN THE REAR WHEELHOUSE.
Risk: THESE GASES COULD FLOW INTO THE PASSENGER COMPARTMENT IF THE PLUG IS MISSING OR LOOSE AND COULD CAUSE POSSIBLE ILLNESS, UNCONSCIOUSNESS, OR DEATH.
Fix: DEALERS WILL INSPECT THE VEHICLE FOR LOOSE OR MISSING WHEELHOUSE PLUGS AND INSTALL NEW PLUGS IF NECESSARY.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2001 GMC Yukon XL 4-DR. w/SAB

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	★★★★★

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

What owners report

Problem area	Complaints	Crashes	Injuries	Typical mileage*
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Antilock/traction control/electronic limited slip › Control unit/module	34	2	1	53,500 mi
Parking brakeConventional › Mechanical	24	0	2	52,000 mi
Service brakes	13	1	0	120,000 mi
Fuel system, gasolineDelivery › Fuel pump; Fuel injection system	10	0	0	67,600 mi
SteeringHydraulic power assist › Pump; Hydraulic power assist system	9	1	0	69,414 mi
TiresTread/belt; Temporary/emergency spare tire	8	0	0	55,500 mi
StructureBody › Hatchback/liftgate › Hinge and attachments; Body › Tailgate › Hinge and attachments	7	0	1	79,620 mi
Electrical system12v/24v/48v battery; 12v/24v/48v battery › Cables	7	0	0	66,815 mi
Unknown or other	6	2	0	162,728 mi
Service brakes, airAntilock › Control unit/module; Antilock › Wheel speed sensor	5	1	0	70,500 mi
Power trainAutomatic transmission; Automatic transmission › Park/neutral start interlock switch	4	0	2	—
Exterior lightingHeadlights	4	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Service brakes
The ABS system in this vehicle and many other similar GM vehicles of this year have abs pumps that malfunction and/or randomly stop working just to begin working later. My vehicle currently has the abs fuse removed because whenever itâs in the abs pump runs continuously even when the vehicle is off. The vehicle I own is in good shape with only 80,000 miles. similar gm vehicles of this age with more miles have even more issues specially with the abs system itâs worse in vehicles that also come equipped with traction control.
Dec 14, 2025
Service brakes
This is the 3rd Yukon I have owned all 2001-2003. Every one of them have had serious brake issues, ABS illuminated, Parking Brake does not work, and light is illuminated, brake fluid everywhere, which when hot starts eating away at electrical components, or in my case at cooling system hoses. Which all lead too one issue after another. I really think that this shoudl be address becasue eveyone i speak with has the same issue. It's exhausting anf expensive too fix, but i have no choice becausei need 3 rows too fit all my children and cannot afford a brand new car.
Mar 1, 2025
Unknown or otherCrash
IMPACT AND ACCIDENT AT A 2 WAY STOP SIGN, WHERE MY TRUCK WAS STOPPED, and a TESLA DUAL MOTOR MODEL3, SEVERED AND HIT MY TRUCK, DUE TO THE DRIVER BEING ON AUTONOMOUS MODE ORFSD BETA 10.XZXX69.
May 26, 2022
Electronic stability control (esc)Crash
DRIVING TRUCK AND COULDN'T GAIN CONTROL AND WAS DRIVING ON ITS OWN.
Aug 27, 2020 · 196,000 miles
Unknown or other
5.3 ENGINE KNOCKS AT START UP. *TR
Aug 15, 1917 · 150,456 miles
Service brakes
WHILE DRIVING TO WORK IN SPRING 2018, I APPROACHED TRAFFIC LIGHT, DEPRESSED BRAKE, WHICH WENT TO FLOOR AND HAD TO USE PARKING BREAK TO STOP. HAD VEHICLE TOWED TO REPLACE FRONT BRAKE LINES. THEN, 6-8 MONTHS LATER, WHILE DRIVING, CAME TO ANOTHER STOP LIGHT, DEPRESSED BRAKES AND COULD NOT STOP UNTIL I USED PARKING/EMERGENCY BRAKE. HAD YUKON XL TOWED TO REPAIR SHOP AND HAD REAR BRAKE LINES REPLACED IN FALL, 2018. SINCE THEN, BRAKE LIGHTS AND ABS LIGHTS COME ON AND STAY ON, WHEREAS OTHER TIMES WHEN STARTING AND DRIVING, BRAKE & ABS LIGHTS COME ON AND THEN GO OFF WHILE DRIVING. BRAKING HAS ALWAYS SEEMED TO BE INSUFFICIENT.
Mar 1, 2018 · 160,000 miles
Unknown or other
VEHICLE STALLS AND LOSES ALL POWER AT SPEED (60+MPH). AFTER A FEW MINUTES, IT RESTARTS, BUT STALLS AGAIN A FEW MILES OR A FEW HUNDRED YARDS DOWN THE ROAD. I HAVE SPENT THOUSANDS OF DOLLARS TRYING TO GET IT FIXED, REPLACED FUEL PUMPS, SENSORS ETC. WITH NO LUCK. NO ERROR CODES SHOW UP.
Dec 20, 2016 · 175,000 miles
Service brakes
TL* THE CONTACT OWNS A 2001 GMC YUKON XL. WHILE DRIVING 25 MPH, THE ANTI-LOCK BRAKE SYSTEM ENGAGED WITHOUT BEING PROMPTED AND CAUSED THE VEHICLE NOT TO STOP IN A TIMELY MANNER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 246,000.
Nov 25, 2015 · 246,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

PARKING BRAKE FAILUREClosed
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
DP05009 · opened Dec 20, 2005 · closed May 31, 2006
UNWANTED LOW-SPEED ABS ACTIVATIONClosedLed to recall 05V379000
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE…
PE05020 · opened Apr 28, 2005 · closed Sep 13, 2005
OVERHEATED FUEL PUMP WIRINGClosedLed to recall 05V155000
IN A LETTER DATED APRIL 14, 2005, GENERAL MOTORS (GM) NOTIFIED ODI THAT IT HAD IDENTIFIED A DEFECT RELATED TO MOTOR VEHICLE SAFETY IN APPROXIMATELY 316,508 MODEL YEAR (MY) 2000-01 1500 SERIES CHEVROLET SUBURBAN AND GMC YUKON XL VEHICLES (RECALL 05V-155).GM DETERMINED THAT SOME OF THESE VEHICLES WERE EQUIPPED WITH FUEL MODULE RESERVOIR ASSEMBLIES (MRAS) THAT CONTAIN FUEL PUMP WIRES AND/OR CONNECTORS THAT MAY OVERHEAT UNDER CERTAIN OPERATING CONDITIONS.ACCORDING TO GM, FUEL PUMP WIRES THAT OVERHEAT MAY RESULT IN ONE OR MORE CONDITIONS THAT PRESENT RISKS TO MOTOR VEHICLE SAFETY:(1) FUEL LEAKAGE FROM THE MRA PASS-THROUGH CONNECTOR IF THE OVERHEATING PRODUCES A HOLE IN THE PLASTIC CONNECTOR; (2) ENGINE STALL IF WIRING EXPOSED BY THE OVERHEATING SHORTS TO GROUND AND CAUSES THE FUEL PUMP FUSE TO BLOW; OR (3) INACCURATE FUEL LEVEL READINGS IF OVERHEATED WIRING IS SHORTED TO THE FUEL LEVEL…
EA04026 · opened Sep 9, 2004 · closed Aug 2, 2005
OVERHEATED FUEL PUMP WIRINGClosedLed to recall 05V155000
THE FUEL PUMP WIRING AND CONNECTOR MAY OVERHEAT AND MELT A HOLE IN THE TOP OF THE FUEL PUMP MODULE.POSSIBLE CONSEQUENCES INCLUDE FUEL TANK LEAKAGE AND ENGINE STALL WITH NO RESTART.FOURTEEN OF THE 20 COMPLAINTS TO ODI ALLEGE FUEL TANK LEAKAGE, INCLUDING ONE THAT REPORTED THAT A FIRE DEPARTMENT WAS CALLED TO THE SCENE AFTER A POOL OF GASOLINE WAS DISCOVERED BENEATH THE VEHICLE.MOST OF THE ODI COMPLAINTS REPORT INCIDENTS THAT OCCURRED WITHIN THE PAST YEAR. ACCORDING TO GM, FUEL LEAKAGE CAN OCCUR IN THE SUBJECT VEHICLES IF THE HEAT IS SUFFICIENT TO MELT A HOLE IN THE PLASTIC CONNECTOR LARGE ENOUGH FOR LIQUID FUEL TO FLOW THROUGH.ON-BOARD EMISSIONS DIAGNOSTICS MAY DETECT HOLES THAT ARE APPROXIMATELY 0.040 INCHES OR MORE AND SET A SERVICE ENGINE SOON WARNING LIGHT.THE CONNECTOR POSITION IN THE SUBJECT VEHICLES IS BELOW THE FUEL LEVEL WHEN THE TANK IS FULL.WHILE GM DOES NOT KNOW HOW MUCH FUEL…
PE04042 · opened May 3, 2004 · closed Sep 9, 2004
ALLEGED FAILURE OF 2ND ROW SEATBELT ALRClosed
THE AUTOMATIC LOCKING RETRACTOR (ALR) IS A FEATURE INCORPORATED IN THE SUBJECT VEHICLE FOR LOCKING THE WEBBING TO PROPERLY SECURE A CHILD SAFETY SEAT INTO A VEHICLE.THIS PE WAS OPENED BASED ON A GM TECHNICAL SERVICE BULLETIN STATING THAT WITH CERTAIN CHILD SAFETY SEATS THE WEBBING MAY NOT REMAIN LOCKED.THERE ARE NO COMPLAINTS IN THE ODI DATABASE AND ONLY TWO COMPLAINTS TO GM.GM'S INSTRUCTIONS STATE FOR THE FINAL STEP IN USING THE WEBBING LOCK FEATURE TO PUSH AND PULL THE CHILD RESTRAINT TO BE SURE IT IS SECURE. IF THE ALR IS NOT LOCKED, THE USER WOULD BE FULLY AWARE OF THIS CONDITION PRIOR TO COMPLETING PROPER INSTALLATION OF THE CHILD SAFETY SEAT IN THIS VEHICLE.THIS INVESTIGATION DID NOT UNCOVER ANY COMPLAINTS OF THE ALR INADVERTENTLY UNLOCKING WHILE THE VEHICLE IS IN MOTION.THE EMERGENCY LOCKING RETRACTOR (ELR) FEATURE REMAINS AVAILABLE TO LOCK THE RETRACTOR IN A CRASH.A…
PE02067 · opened Sep 25, 2002 · closed Feb 11, 2003
THROTTLE STICKING CLOSEDClosed
THIS INVESTIGATION INVOLVES THE GENERAL MOTORS CORPORATION (GM)THROTTLE BODY (TB) UTILIZED IN MODEL YEAR (MY) 1999-2002 SILVERADO, SIERRA, TAHOE, SUBURBAN, AVALANCHE AND YUKON (SUBJECT VEHICLE(S)) WITH 4.8L, 5.3L, AND 6.0L ENGINES. THE TB VALVE MAY INTERMITTENTLY STICK IN A CLOSED POSITION.IN SUCH A SITUATION, AN OPERATOR MAY APPLY ADDITIONAL ACCELERATOR PEDAL FORCE TO INCREASE ENGINE SPEED.THE APPLICATION OF ADDITIONAL ACCELERATOR PEDAL FORCE, TO OPEN A STUCK THROTTLE VALVE, MAY OPEN THE THROTTLE VALVE MORE THAN INTENDED AND, IN TURN, ACCELERATE THE ENGINE AND VEHICLE MORE THAN INTENDED AND REASONABLY EXPECTED BY THE DRIVER.ON AUGUST 1, 2002, THE OFFICE OF DEFECTS INVESTIGATION (ODI), OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), OPENED THIS ENGINEERING ANALYSIS.THE INVESTIGATION REVEALED THAT TWO FACTORS MAY CAUSE THE DEFECT: 1) TB MANUFACTURING PROCESS PROBLEMS; AND…
EA02015 · opened Aug 1, 2002 · closed Jan 12, 2004