*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Suspension
I am filing a formal safety complaint against Camping World for structural equipment overloading, unauthorized safety component manipulation, and willful public safety endangerment. On May 29, the dealer hitched a 37' long trailer to my half ton truck frame. This combination violates critical highway stability standards. A 37' trailer requires a minimum 178" tow vehicle wheelbase to counteract lateral wind forces and semi-truck displacement. Operating it with a 157" wheelbase leaves a catastrophic 21" layout deficit, causing uncontrollable highway sway. The tailer's loaded tongue weight (1,223 to 1,529 lbs based on a 10,195 lb GVWR) physically overloads the truck's factory stamped 1,22o lb…
May 30, 2026Suspension
The frame of the trailer has. cracked in 4 places. Directly behind each wheel. Right in the middle of. the steel. There is a known defect in these frames. Cheap steel? Who knows but I'm one of many that this has happened to. The company has denied any warrranty.
Aug 9, 2024Tires
All tires failed. 225/75 R15 Took my tires in for a routine rotation and balance cracks were on the tires. Dry rot
Oct 4, 2024Structure › Body
Frame is cracked. Both sides frame rails have horizontal cracks forming near the leaf spring mount brackets. The structural integrity of our camper is now compromised. If a frame rail were to fail during travel, the loss of control to the tow vehicle would follow, most likely on public roadways. The crack will be present no matter who inspects it. The failure was noticed when I inspected the frame after being made aware of how common frame rail failures are with Grand Design products. Will be following through with attempting to have the manufacturer cover this defect under warranty.
Jul 21, 2024Tires
The contact owns a 2020 Grand Design Imagine equipped with Westlake Tires, Tire Line: Super ST, Tire Size: 225/75/R15, DOT Number: JULT1CT. The contact stated while driving 60 MPH, the contact heard a loud explosion and became aware that the front driverâs side tire had experienced a blowout. The contact was able to pull over on the side of the roadway. The contact replaced the tire with the spare tire. The dealer was contacted and recommended that all of the tires be replaced. The manufacturer was not contacted. The failure mileage was 2,000.
Jul 17, 2023 · 2,000 milesTires › Sidewall
Tire size ST225/75/R15. Traveling on a two lane county highway in Pierce County, WI. Tire pressure as indicated on the Tire Minder i10 TPMS was 82 psi. Ambient air temperature was about 70F. Road surface was dry at the time. Incident began with suspected rupture in tire sidewall. No indication by TPMS prior to incident of increased temperature or decreased pressure. Sidewall failure was followed by separation of tread from tire body, causing damage to vehicle fender skirt, which departed the vehicle. Vehicle slowed under moderate breaking to a stop within about 300 yards. No reports with law enforcement filed. Photos attached.
Jun 12, 2023Tires
The tire came apart. The tread separated from the rest of the tire and the whole tire separated like it was cut in half. Others safety was at risk because of debris. It hasnât been presented to dealer yet. It has not been inspected yet. I use a tire pressure monitoring system and all tires were showing similar readings for psi and temperature 70-72psi and 93â.
Jun 26, 2022Equipment
There is currently an rv recall coming out concerning 150,000 2021 through 2023 travel trailers and fifth wheels for a faulty quick disconnect fitting in the propane system, which can crack, leak, and cause fires. I own a 2020 Grand Design, Imagine, travel trailer which had the exact same defect as this list describes. I paid my rv dealership $539 on 10/11/21 to trace the propane leak and replace the same connector which was cracked, with no signs of trauma or damage. This recall needs to be expanded to include 2020 models for sure and other manufacturers such as Grand Design.
Oct 11, 2021
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.