Model year record
2007 Harley-Davidson Flhtc recalls & problems
The 2007 Harley-Davidson Flhtc has no safety recalls on file with NHTSA, and 14 owner complaints. The most-reported problem area is engine and engine cooling (6 complaints).
Safety recalls
No safety recalls have been filed for the 2007 Harley-Davidson Flhtc.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Engine and engine coolingExhaust system › Manifold/header/muffler/tail pipe; Engine | 6 | 2,800 mi |
| Power trainManual transmission | 5 | 13,881 mi |
| Exterior lightingBrake lights › Switch | 2 | — |
| Electrical system | 1 | — |
| Tires | 1 | — |
| Service brakes | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Power train
TL* THE CONTACT OWNS A 2007 HARLEY-DAVIDSON FLHTC. WHILE RIDING 75-80 MPH, AN ABNORMAL NOISE EMITTED FROM THE TRANSMISSION. THE DEALER DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MOTORCYCLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. UPDATED 04/06/17 LJ *TR
- Service brakes
THE REAR BRAKE LINE (PN 40971-00A) RUBBED THE FRAME AND CLUTCH CABLE, CAUSING A HOLE TO BE CREATED. THIS IS IN THE AREA BELOW THE CAM CHEST, BEHIND THE MASTER CYLINDER, INSIDE THE FRAME ON THE RIGHT SIDE. THE BRAKE LINE BLEW OUT WHEN THE REAR BRAKE WAS APPLIED. THERE WAS NO WARNING. AFTER DOING RESEARCH, I FOUND THIS TO BE A COMMON PROBLEM. *TR
- Exterior lighting › Brake lights › Switch
TL* THE CONTACT OWNS A 2007 HARLEY DAVIDSON FLHTC. THE CONTACT STATED THAT WHILE DRIVING AT 9 MPH, THE BRAKE LAMP FAILED TO ACTIVATE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT MENTIONED THAT THE BRAKE LAMP SWITCH WAS MELTED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LIGHT SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN NUMBER WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V506000 (EXTERIOR LIGHTING). THE FAILURE MILEAGE WAS 43,000.
- Power train
AS I WAS SLOWING DOWN IN MY DRIVEWAY THE ENGINE, WITH OUT WARNING, MADE A LOUD METALLIC NOISE FROM THE LEFT SIDE AND LOCKED UP ALONG WITH THE REAR WHEEL. IF THIS WOULD HAVE HAPPENED AT A GREATER SPEED, OR IN TRAFFIC, THE CONSEQUENCES COULD HAVE BEEN DIRE. I REMOVED THE PRIMARY COVER AND IMMEDIATELY NOTICE A LARGE PIECE OF STEEL HAD GOTTEN JAMMED BETWEEN THE CLUTCH SPROCKET AND PRIMARY DRIVE CHAIN. THIS LARGE PIECE OF STEEL HAD BROKEN OFF A PRESSED STEEL CAGE THAT ENCLOSED A SET OF DIAPHRAGM SPRINGS FROM THE CRANKSHAFT COMPENSATOR ASSEMBLY. THE OUTER EDGE OF THE SPRINGS, OVER TIME, HAD WORN THEIR WAY THROUGH THE CAGE THAT CONTAINS THEM IN PLACE CAUSING A SECTION OF THE CAGE TO SEPARATE. THIS…
- TiresCrash1 injury
WHILE RIDING THE MOTORCYCLE (2007 HARLEY DAVIDSON HERITAGE SOFTAIL CLASSIC) AT 57 MPH ON DRY PAVEMENT WITH NO ADVERSE ROAD CONDITIONS, THE REAR TIRE BLEW, THE RIDER FOUGHT TO KEEP THE BIKE UPRIGHT TO SLOW DOWN FOR 3-5 SECONDS, THEN LOST CONTROL AND CRASHED ON THE HIGHWAY. THE TIRE PRESSURE WAS CHECKED TO PROPER INFLATION 30 MINUTES BEFORE THE BLOWOUT AND ACCIDENT OCCURRED. THE RIDER SUFFERED A BRAIN CONCLUSION WITH MINOR HEMORRHAGING, A BROKEN COLLARBONE, AND BROKEN BONES IN THE RIGHT FOOT. THE TIRE, WHICH WAS NEW ON THE BIKE AND PURCHASED TWO MONTHS BEFORE THE ACCIDENT, HAD ONLY BEEN RIDDEN FOR 1400 MILES. THE TIRE, BRIDGESTONE EXEDRA G702, APPEARS TO BE DEFECTIVE, HAVING COME APART AT…
- Electrical system
WHEN SWITCH TO HIGH BEAM ALL LIGHTS GO OUT BECAUSE THE 15 AMP FUSE WILL BLOW. *TR
- Engine and engine cooling › Exhaust system
TL*THE CONTACT OWNS A 2007 HARLEY DAVIDSON FLHTC MOTORCYCLE. THE CONTACT STATED HIS EXHAUST PIPE TURNED RED AFTER OVERHEATING. THE OVER HEATING IS CAUSED BY THE EXHAUST PIPE AND CYLINDER HEAD. THE DEALER IS WAITING FOR APPROVAL FROM THE REGIONAL MANAGER TO MAKE THE REPAIRS. THE FAILURE MILEAGE WAS 2,800.
- Engine and engine cooling
MY 2007 FLHTC HARLEY DAVIDSON HAS BEEN A LEMON SINCE I BOUGHT IT IN 2007. THE BIKE ALWAYS RUNS HOT DUE TO THE FACT THERE IS NO OIL PRESSURE AT TIMES. THE CPK UNIT WENT OUT AND LEAKED OIL EVERYWHERE AFTER ONE MONTH. THE FRONT PART OF THIS UNIT, WHICH WAS INSIDE THE MOTOR, WAS DAMAGED. THE DEALERSHIP SAID SOMETHING HAD TO HAVE HIT IT. INSTEAD OF TEARING DOWN THE MOTOR TO FIND OUT WHAT HIT IT THEY JUST REPLACED IT. OIL PRESSURE CONSTANTLY DROPS AFTER RIDING FOR AWHILE. THE DEALERSHIP SAID THAT WAS NORMAL. NOW THE BIKE HAS NO OIL PRESSURE AND IS LEAKING OIL FROM SOMEWHERE. IT IS BACK AT THE DEALERSHIP BEING WORKED ON AGAIN. I DO NOT TRUST THIS BIKE TO GO ANYWHERE FAR FROM HOME. SOMETHING IS…
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.