Model year record

2004 Honda VFR800 recalls & problems

The 2004 Honda VFR800 has 2 safety recalls and 3 owner complaints on file with NHTSA. The most-reported problem area is electrical system (2 complaints).

Recalls2safety recalls

Complaints3filed by owners

Crashes · fires1 · 0reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

Electrical systemAug 15, 2007

Wiring

Recall 07V3590006,952 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN MOTORCYCLES, THE FRONT FAIRING SUB-HARNESS (SECTION OF THE WIRING HARNESS) TRANSFERS THE ELECTRICAL GROUNDING LOAD OF THE HEADLIGHTS, FRONT TURN SIGNALS, INSTRUMENT PANEL, AND VARIOUS RELAYS TO THE MAIN WIRING HARNESS VIA AN 18-PIN CONNECTOR. UNDER CERTAIN CONDITIONS, THE GROUND WIRE TERMINALS INSIDE THE CONNECTOR CAN OVERHEAT, RESULTING IN MELTING OF THE CONNECTOR AND A LOSS OF POWER TO VARIOUS CIRCUITS.
Risk: AS A RESULT, A LOSS OF CRITICAL LIGHTING OR ENGINE POWER COULD OCCUR WITHOUT WARNING, WHICH COULD CAUSE A CRASH.
Fix: DEALERS WILL INSTALL A RE-DESIGNED SUB-HARNESS. IF DAMAGE IS FOUND, THE MAIN WIRING HARNESS WILL ALSO BE REPLACED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON SEPTEMBER 26, 2007. OWNERS WERE RE-NOTIFIED ON NOVEMBER 10, 2007, TO TAKE THEIR MOTORCYCLES TO DEALERS TO HAVE THE PARTS INSTALLED. OWNERS MAY CONTACT HONDA AT 1-866-784-1870.

Service brakes, hydraulicJan 24, 2005

Service brakes, hydraulic

Recall 05V01000036,046 vehicles

Problem: CERTAIN MOTORCYCLES EQUIPPED WITH COMBINED-BRAKE SYSTEMS HAVE A PROPORTIONING CONTROL VALVE (PCV) THAT MECHANICALLY PROPORTIONS BRAKE FORCE WHEN THE REAR BRAKE IS APPLIED. A SEAL IN SOME PCVS IS IMPROPERLY SHAPED, AND BRAKE FLUID LEAKAGE MAY OCCUR.
Risk: IF THE MOTORCYCLE CONTINUES TO BE USED AFTER A LEAK OCCURS, THE REAR BRAKE WOULD EVENTUALLY BECOME INOPERATIVE. A LOSS OF REAR BRAKE FORCE COULD INCREASE THE RISK OF A CRASH.
Fix: DEALERS WILL INSPECT THE REAR BRAKE FORLEAKAGE. IF LEAKAGE IS CONFIRMED, THE DEALER WILL REPLACE THE PCV FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS MAY CONTACT HONDA AT 866-784-1870.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Electrical systemWiring	2	1	0	0	—
Engine and engine cooling	1	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Electrical system › Wiring
TL*THE CONTACT OWNS A 2004 HONDA VFR800. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 07V359000 (ELECTRICAL SYSTEM, WIRING). WHILE DRIVING BETWEEN 55-60 MPH, THE INSTRUMENT PANEL SHUT OFF. WHEN HE EXITED THE FREEWAY, THE INSTRUMENT PANEL BEGAN WORKING AGAIN. WHEN HE MERGED BACK ONTO THE FREEWAY, EVERYTHING WORKED NORMALLY, EXCEPT THE SPEEDOMETER. THE CONTACT STATED THAT THE SPEEDOMETER CONTINUOUSLY FLUCTUATED ON AND OFF. HE DOES NOT WANT TO RIDE THE VEHICLE BECAUSE HE DOES NOT WANT TO GET A SPEEDING TICKET. THE FAILURE MILEAGE WAS 12,550. UPDATED 07/29/08 *BF AFTER THE WIRING HARNESS WAS REPLACED, THE CONSUMER EXPERIENCED THE SAME PROBLEMS WITH THE DASH LIGHTS AND SPEEDOMETER. UPDATED…
Jun 28, 2008 · 12,550 miles
Engine and engine cooling
TL*THE CONTACT OWNS A 2004 HONDA VFR800. WHILE RIDING 30 MPH, THE VEHICLE SHUTS OFF AND STALLS RANDOMLY. THE CONTACT HAS BEEN UNABLE TO GET ANY OF THE HONDA DEALERS TO REPAIR OR DUPLICATE THE FAILURE. HE CALLED THE MANUFACTURER AND THEY INFORMED HIM TO TAKE THE VEHICLE TO THE HONDA DEALER, BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 7,000. UPDATED 4/2/08 *CN UPDATED 04/02/08 *TR
Feb 5, 2008 · 7,000 miles
Electrical system › WiringCrash
INTERMITTENT ELECTRICAL PROBLEMS, LOSS OF POWER, LIGHTS, INSTRUMENTS. LOSS OF POWER AND LIGHTS AT NIGHT RESULTED LOST CONTROL OF MOTORCYCLE, WHICH CAME IN CONTACT WITH REFLECTOR/BARRIER ON HIGHWAY. AT HIGHER SPEEDS THIS MAY HAVE RESULTED IN SERIOUS INJURY. *JB
Sep 16, 2007 · 8,800 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Southern Honda PowersportsClosed
NHTSA opened Audit Query (AQ) 12-001 to determine whether Southern Honda Powersports (Southern Honda) of Chattanooga, Tennessee, had complied with the requirements of the National Traffic and Motor Vehicle Safety Act, as amended, 49 U.S.C. Chapter 301 (Safety Act) and its implementing regulations. The Safety Act requires, among other things, that a motor vehicle or equipment manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with federal motor vehicle safety standards.In turn, a dealer may not sell and deliver a new vehicle subject to a recall unless the recall remedy has been performed.(see 49 U.S.C. 30120(i); 49 C.F.R. 573.11)NHTSA issued an information request to Southern Honda on May 14, 2012 to which they responded on July 6, 2012.NHTSA?s inquiry led it to believe that Southern Honda had failed to complete the requirements of five recalls…
AQ12001 · opened May 14, 2012 · closed May 13, 2013