Model year record

2007 Lexus Rx Hybrid recalls & problems

The 2007 Lexus Rx Hybrid has 3 safety recalls and 59 owner complaints on file with NHTSA. The most-reported problem area is vehicle speed control (11 complaints).

Recalls3safety recalls

Complaints59filed by owners

Crashes · fires10 · 0reported in complaints

Injuries · deaths3 · 0reported in complaints

Safety recalls

Hybrid propulsion systemSep 4, 2013

Inverter

Recall 13V396000133,081 vehicles

Problem: Toyota is recalling certain model year 2006-2010 Highlander hybrid vehicles manufactured February 16, 2005, through July 29, 2010; and model year 2006-2008 Lexus RX400h vehicles manufactured February 23, 2005, through December 2, 2008. The Intelligent Power Module (IPM) inside the inverter module may contain transistors that have higher operating temperatures than the solder can support and the transistors may be heat damaged by the solder. If this occurs, various warning lamps, including the malfunction indicator lamp, slip indicator light, brake system warning light, and master warning light, will be illuminated on the instrument panel.
Risk: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. It is possible that the hybrid system will shut down while the vehicle is being driven, causing the vehicle to stall unexpectedly, increasing the risk of a crash.
Fix: Toyota will notify owners, and dealers will replace the IPM free of charge. Owners may contact Toyota at 1-800-331-4331. Vehicles that had their IPM replaced under recall 11V-342 are not affected by this campaign.

Electrical systemJun 29, 2011

Electrical system

Recall 11V34200082,273 vehiclesopened after NHTSA action (ODI)

Problem: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006-2007 HIGHLANDER HYBRID AND LEXUS RX400H PASSENGER CARS MANUFACTURED FROM FEBRUARY 16, 2005, THROUGH AUGUST 30, 2006. A MODULE INSIDE THE INVERTER MODULE MAY CONTAIN INADEQUATELY SOLDERED TRANSISTORS THAT DURING HIGH-LOAD DRIVING, MAY BE DAMAGED BY HEAT CAUSED BY THE LARGE CURRENT. IF THIS OCCURS, VARIOUS WARNING LAMPS, INCLUDING THE MALFUNCTION INDICATOR LAMP, SLIP INDICATOR LIGHT, BRAKE SYSTEM WARNING LIGHT, AND MASTER WARNING LIGHT, WILL BE ILLUMINATED ON THE INSTRUMENT PANEL.
Risk: THE VEHICLE MAY ENTER A FAIL-SAFE/LIMP-HOME MODE THAT LIMITS THE DRIVABILITY OF THE VEHICLE. IT IS POSSIBLE THAT THE HYBRID SYSTEM WILL SHUT DOWN WHILE THE VEHICLE IS BEING DRIVEN, CAUSING THE VEHICLE TO STALL UNEXPECTEDLY, INCREASING THE RISK OF A CRASH.
Fix: TOYOTA/LEXUS MAILED AN INTERIM OWNER NOTIFICATION ON JULY 19, 2011 TO ADVISE OWNERS OF THIS RECALL AND THE FACT THAT THEY WILL RECEIVE A FUTURE NOTICE WHEN PARTS BECOME AVAILABLE TO COMPLETE REPAIRS. TOYOTA DEALERS WILL INSPECT THE HYBRID INVERTER PRODUCTION NUMBER TO DETERMINE WHETHER THE INVERTER CONTAINS SUSPECT TRANSISTORS AND REPLACE THE MODULE FREE OF CHARGE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Vehicle speed controlFeb 24, 2011

Accelerator pedal

Recall 11V112000769,379 vehiclesopened after NHTSA action (ODI)

Problem: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
Risk: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Injuries	Typical mileage*
Vehicle speed controlAccelerator pedal	11	6	3	10,500 mi
Service brakes	10	1	0	111,917 mi
Electrical system	8	0	0	110,000 mi
StructureBody	8	1	0	72,500 mi
Steering	7	1	0	121,000 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip › Control unit/module	5	1	0	17,798 mi
Service brakes, electric	4	1	0	25,000 mi
Engine	4	0	0	134,950 mi
Electronic stability control (esc)	3	0	0	114,500 mi
Air bags	2	0	0	—
TiresPressure monitoring and regulating systems	2	0	0	—
Suspension	2	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Service brakes
TL* THE CONTACT OWNS A 2007 LEXUS RX400H. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, THE ABS SENSOR LIGHT ILLUMINATED AND THE STOPPING DISTANCE WAS EXTENDED WHILE DEPRESSING THE BRAKE PEDAL. ADDITIONALLY, THE TRACTION CONTROL LIGHT WAS ALSO ILLUMINATED AND THE SPEED WAS REDUCED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER SOUTH BAY LEXUS LOCATED AT 24777 CRENSHAW BLVD, TORRANCE, CA 90505, WHO DIAGNOSED THAT THE ABS ACTUATOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 150,000.
Mar 1, 2020 · 150,000 miles
Steering
DRIVING VEHICLE ON LOCAL ROAD ~30 MPH AND SUDDEN/COMPLETE STEERING FAILURE. P/S LIGHT THEN ILLUMINATED AND EFFORT REQUIRED TO STEER VEHICLE IS BEYOND MOST PEOPLE'S STRENGTH.
Jul 25, 2019 · 155,000 miles
Service brakes
WHILE DRIVING FROM FLORIDA TO FAIRFAX, CA THE VEHICLE STALLED ~10 TIME UNEXPECTEDLY WITH LOSS OF POWER BRAKES AND POWER STEERING, MAKING A VERY DANGEROUS SITUATION. THE "CHECK HYBRID SYSTEM AND CHECK VSC SYSTEM" SHOWED ON THE DASH. CLEARING THE CODES RESTARTED THE VEHICLE. I STOPPED IN DENVER, CO AT KUNI LEXUS OF GREENWOOD VILLAGE, WHOM ROAD TESTED THE VEHICLE FOR 30 MILES BUT WERE UNABLE TO DUPLICATE THE FAULT. OBDII DTC P3105 WAS READ ON MY SCANNER BEFORE ARRIVAL. I HAVE RESEARCHED THE FAILURE MORE AND FOUND OUT ON LEXUS TIS SYSTEM; ON 01/15/2014, LEXUS OF MIAMI CLAIMED TO HAVE COMPLETED SAFETY RECALL 13V396000 (INTELLIGENT POWER MODULE (IPM) SOLDER FAILURES) BUT THEY ONLY DIAGNOSED SOME…
Jan 28, 2019 · 202,144 miles
Service brakes
TL* THE CONTACT OWNS A 2007 LEXUS RX400H. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND AS THE ABS WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT AFTER ABOUT 7 SECONDS THE BRAKES FUNCTIONED AS INTENDED. THE VEHICLE WAS TAKEN TO THE DEALER ATLANTIC LEXUS OF 110 (2090 BROADHOLLOW RD, FARMINGDALE, NY 11735 (516)-795-7600) WHERE A DIAGNOSTIC TEST WAS PERFORMED AND DETERMINED THAT THE BRAKE ACTUATOR ASSEMBLY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE WARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE WARRANTIES HAD EXPIRED. THE FAILURE MILEAGE WAS 200,000.
Oct 18, 2018 · 200,000 miles
Service brakes
ABS BRAKE LIGHT, TRACCIN LIGHT, NO POWER BRAKE, MY CARO HAS 90,996 MILES
Aug 29, 2018 · 50 miles
Service brakes
I WAS DRIVING ON HIGHWAY ON SPEED OF 65 MILES PER HOUR SUDDENLY MY POWER STRING AND BRAKES FAILED. LUCKILY I DIDN'T GET AN ACCIDENT. AFTER I CAME HOME AND START RESEARCHING I SAW THERE ARE A LOT OF PEOPLE WITH THE SAME PROBLEM.PLEASE MAKE A RECALL FOR THAT MAYBE SOMETHING HAPPENS TO SOMEONE.THANKS
Aug 13, 2018 · 199,000 miles
Air bags
DRIVER'S SIDE AIR BAG LIGHT STAYS ON, FLASHES, OR IS OFF INTERMITTENTLY. I HAVE TAKEN IT TO A MECHANIC AND BEEN TOLD THAT THE CONNECTOR WAS LOOSE AND THEY ZIP-TIED THE WIRING IN PLACE. THEY SAID IF THAT DOESN'T WORK THAT NEW SUPPORT ASSEMBLY FOR THE AIRBAG WILL NEED TO BE INSTALLED. THAT WOULD BE OVER $2,000, WHICH SEEMS LIKE A PRETTY EGREGIOUS AMOUNT TO FIX A LOOSE WIRE FOR A CRITICAL SAFETY ITEM.
Jan 8, 2018 · 105,000 miles
Structure › Body
THE REAR BUMPER HAS A PLASTIC COVER AND THE PAINT BUBBLED AND BEGAN TO PEEL FROM UNDER THIS PLASTIC MOLDING AS IF WATER WAS BEHIND IT. THE REAR BUMPER NOW HAS PEELING PAINT.
Jun 1, 2017 · 104,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Pedestrian alert soundsClosedLed to recall 22V063000
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review…
DP22005 · opened Jan 27, 2023 · closed Aug 7, 2023
Hybrid inverter failure - vehicle stallClosedLed to recall 11V342000
In a June 29, 2011 letter to NHTSA, Toyota submitted a Defect Information Report regarding a safety recall of certain Toyota Highlander Hybrid and Lexus RX400h vehicles to address a defect condition with the hybrid inverter assembly (NHTSA Recall No. 11V-342).Toyota's letter identified a defect related to inadequately soldered transistors on the Intelligent Power Module (IPM) of some of the subject vehicles that could result in sudden loss of power while driving.Toyota's remedy procedure instructs dealers to inspect the hybrid inverter production number to determine if the inverter contains suspect transistors.If so, the dealer will replace the IPM.The recall covers approximately 45,528 model year (MY) 2006 and 2007 Toyota Highlander Hybrid vehicles manufactured from February 16, 2005 through August 29, 2006 and approximately 36,745 MY 2006 and 2007 Lexus RX400h vehicles manufactured…
PE11005 · opened Feb 15, 2011 · closed Jul 20, 2011
Unintended and Uncontrolled AccelerationClosedLed to recall 11V112000
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as…
RQ10003 · opened Feb 16, 2010 · closed Mar 1, 2011