Model year record
1996 Mercedes-Benz E320 recalls & problems
The 1996 Mercedes-Benz E320 has no safety recalls on file with NHTSA, and 45 owner complaints. The most-reported problem area is suspension (20 complaints).
Safety recalls
No safety recalls have been filed for the 1996 Mercedes-Benz E320.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Fuel economy
E320
| City / highway | 17 / 24 mpg |
|---|---|
| Fuel | Premium Gasoline |
3.2 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,350/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| SuspensionFront › Springs › Coil springs; Front | 20 | 90,000 mi |
| Electrical system12v/24v/48v battery; Wiring › Front underhood | 13 | 125,500 mi |
| Engine and engine coolingEngine › Gasoline; Engine | 6 | 95,000 mi |
| Air bagsFrontal | 5 | 93,477 mi |
| StructureFrame and members; Frame and members › Underbody shields | 5 | 110,948 mi |
| EquipmentAppliance › Air conditioner | 3 | — |
| SteeringLinkages › Tie rod assembly | 3 | — |
| Fuel system, gasoline | 2 | — |
| Fuel/propulsion system | 2 | — |
| Tires | 1 | — |
| Engine | 1 | — |
| Seat belts | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Suspension
TL* THE CONTACT OWNS A 1996 MERCEDES-BENZ E320. WHILE DRIVING APPROXIMATELY 60 MPH, THE FRONT END OF THE VEHICLE SUDDENLY SHOOK AND VIBRATED BEFORE COLLAPSING. DURING THE INCIDENT, THE FRONT DRIVER SIDE SUSPENSION SPRING SEPARATED FROM THE VEHICLE AND CAUSED A PUNCTURE TO THE FUEL TANK. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 60,000.
- Air bagsCrash1 injury
TL* THE CONTACT OWNED A 1996 MERCEDES BENZ E320. WHILE DRIVING 65 MPH, THE AIR BAGS FAILED TO DEPLOY AFTER THE CONTACT'S VEHICLE CRASHED INTO ANOTHER VEHICLE. THE DRIVER SUSTAINED KNEE, BACK, NECK, AND CHEST INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 131,000.
- Air bags
WHEN YOU REPLACE THE BATTERY ON THESE VEHICLES THE SAFETY RESTRAINT SYSTEM MALFUNCTIONS RENDERING THE SAFETY EQUIPMENT USELESS IE. AIR BAGS THE AUTOMOBILE SHOULD HAVE A RECALL WHEREBY MERCEDES FIXES THE DEFECTIVE SYSTEM. *TR
- Fuel/propulsion system
AFTER FILLING UP ON GAS JUST TWO DAYS AGO, THERE WAS A VERY PECULIAR SMELL. IT SMELLED OF GAS FUMES. JUST TODAY, I NOTICED THAT MY GAS GAUGE WAS GOING DOWN QUITE FAST AND IT WASN'T UNTIL JUST NOW THAT MY GAS TANK IS LEAKING.
- Suspension
SPRING PERCH SNAPPED AND SPRING SHOT OUT ON FRONT PASSENGER SIDE WHILE WIFE AND CHILDREN WERE IN THE CAR. THANK GOD THEY WERE LESS THE 200 FEET FROM THE HOUSE AND ONLY TRAVELING ABOUT 5 MPH. *TR
- Electrical systemCrash
MY VEHICLE WAS PARKED IN FRONT OF STORE ALLOWING A 93 YEAR OLD LADY TO GO SHOPPING,AS I WAS PARKED THERE I WAS SIDESWIPED, I IMMEDIATELY TOOK IT TO THE AUTO SHOP TO HAVE IT REPAIRED, AFTER DOING THIS I DISCOVERED THAT THE KEY CAN'T START THE CAR BECAUSE THE IGNITION IS JAMMED OR KEY WILL NOT TURN, SO THE CAR WON'T START. I CALLED A LOCKSMITH AND DISCOVERED THAT THE IGNITION IS DEFECTED. *TR
- Electrical system
TL* THE CONTACT OWNS A 1996 MERCEDES BENZ E320. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE STARTER WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TOWED BACK TO THE MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE WIRING HARNESS HAD BEGAN TO DRY ROT AND WAS TO DETERIORATING. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 48,000. ..UPDATED 07-01-13 *BF
- Fuel/propulsion system
TL* THE CONTACT OWNS A 1996 MERCEDES-BENZ E 320. THE CONTACT STATED THAT FUEL WAS LEAKING FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TEST. THE TECHNICIAN STATED THAT THE SENDING UNIT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 102,000.
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
- FRONT SUSPENSION COIL SPRING EJECTIONClosed
ODI HAS FOCUSED THIS INVESTIGATION ON ASSESSING THE RISKS POSED BY A SEPARATED SPRING AS (1) A ROAD HAZARD AND (2) THE POTENTIAL FOR VEHICLE CONTROL TO BE COMPROMISED AFTER THE FRONT COIL SPRING HAS BEEN EJECTED FROM ITS INTENDED POSITION IN THE VEHICLE.BOTH RISKS ARE ASSOCIATED WITH CORROSION, FLEXING, AND FRACTURE OF THE UPPER FRONT SUSPENSION MOUNTING BRACKET.TIME-IN-SERVICE FAILURE RATES ARE NOTABLY HIGHER IN SALT BELT STATES SINCE CORROSION IS A PRIMARY CONTRIBUTOR TO THE FAILURE MODE.SINCE A NUMBER OF INCIDENTS HAVE OCCURRED WHILE THE VEHICLE WAS BEING OPERATED, ODI IS SKEPTICAL THAT OWNERS CAN ALWAYS DETECT THE SUBTLE SIDE TO SIDE DIFFERENCE IN RIDE HEIGHT AND/OR INSPECT OR NOTICE THAT THE UPPER SUSPENSION BRACKET HAS BEEN COMPROMISED BY CORROSION.(1) ROAD HAZARD - ALTHOUGH THE (APPROX. 7 LB.) FRONT SUSPENSION SPRING THAT MAY BE EJECTED AT HIGHWAY SPEEDS COULD POSE A SERIOUS ROAD…