Model year record
2003 Mercedes-Benz ML350 recalls & problems
The 2003 Mercedes-Benz ML350 has no safety recalls on file with NHTSA, and 25 owner complaints. The most-reported problem area is steering (11 complaints).
Safety recalls
No safety recalls have been filed for the 2003 Mercedes-Benz ML350.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Fuel economy
ML350
| City / highway | 14 / 17 mpg |
|---|---|
| Fuel | Premium Gasoline |
3.7 L · 6 cyl · Automatic 5-spd · 4-Wheel or All-Wheel Drive · about $5,500/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| SteeringHydraulic power assist system; Hydraulic power assist › Hose, piping, and connections | 11 | 60,750 mi |
| SeatsFront assembly › Seat heater/cooler | 7 | 38,277 mi |
| Engine and engine coolingEngine | 4 | 42,246 mi |
| Electrical system | 4 | 77,500 mi |
| Engine | 2 | — |
| Unknown or other | 2 | — |
| Equipment | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Unknown or other
The Floor Mats I received for my vehicle covered a portion of my accelerator pedal and would when up into the back above the pedal and to the right of it and would get caught and force my accelerator pedal to stay down. I told the company of their design flaw, and they said would not do anything about it. If I wanted to send it back it would cost more than the pads were worth. I paid $189.95. I got PayPal involved and if I paid the shipping cost to send them back they would rebate me the money that I paid. That's only if the mats are in perfect condition when they receive them. So it cost hours of BS and $60 so I get back at least $129. But with that said I felt you should know that they…
- Steering
TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ ML350. WHILE DRIVING 35 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER WHEN TURNED TO THE LEFT. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME SYMPTOMS AS LISTED IN NHTSA CAMPAIGN NUMBER: 08V465000 (STEERING). THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE POWER STEERING FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 175,000.
- Steering
I RECENTLY HAD TO REPLACE THE POWER STEERING PUMP, RESEVIOUR, AND HOSE AFTER LOOSING CONTROL WHILE DRIVING ON THE HIGHWAY. IMMEDIATELY AFTER REFILLING WITH FLUID ALL THE CONTENTS RAN RIGHT OUT. I DO SEE THAT THERE WAS A RECALL FOR THIS PROBLEM IN 2008, BUT I DID NOT TAKE OWNERSHIP OF THIS VEHICLE UNTIL 2/15. IS THERE ANY WAY POSSIBLE FOR THIS PROBLEM TO BE FIXED UNDER THE RECALL?
- Steering
TL* THE CONTACT OWNS A 2003 MERCEDES BENZ ML350. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE POWER STEERING PUMP ASSEMBLY TWICE BUT THE FAILURE RECURRED. THE STEERING WHEEL WAS EXTREMELY TIGHT AND THE VEHICLE WAS TAKEN BACK TO THE INDEPENDENT MECHANIC. THE APPROXIMATE FAILURE MILEAGE WAS 99,000.
- Electrical system
RANDOM LOSS OF POWER ' (THE ENTIRE PANEL LIGHTS UP) AS THE CAR SUDDENLY AND SLOWLY POWERS OFF WHILE TAKING OFF FROM A DROP, DRIVING, BREAKING, AND TURNING, COMING TO A STOP AND ON THE HIGHWAY. IN THE PAST 6 MONTHS WE HAVE SPENT MORE THAN 3800.00 FOR CAR REPAIR ON THE ML 350. IT SHUTS OFF MORE AND MORE FREQUENTLY. SO MUCH SO WE DO NOT ALLOW OUR DAUGHTER TO DRIVE UNLESS I AM THERE AND NOW NOT EVEN THEN UNTIL WE HAVE HAD IT FIXED FOR THE 4TH TIME (WE THOUGHT) AFTER CRANK SHAFT, SPARK PLUGS AND NOW ELECTRICAL WORK WE ARE AT A TOTAL LOSS. THIS ISSUE IS NOT ISOLATED BUT MERCEDES BENZ HAS HAD OTHER REPORTS OUR AND OTHERS ' NOT REPAIR / OR RECALLED BUT IT SEEMS MAJOR TO OUR FAMILY ' AS MY ONLY…
- Engine
WITHIN THE PAST 8 MONTHS I HAVE TAKEN MY CAR TO THE DEALERSHIP FOUR TIMES WITH THE ISSUE RELATING ENGINE SHUT OFF AND CHECK ENGINE LIGHT COMES ON. I WAS TOLD THE CRANKSHAFT NEEDED TO BE REPLACED TWO TIMES AND AS OF TODAY THE PROBLEMS REMAINS. MERCEDES BENZ HAS ACKNOWLEDGED THIS IS PROBLEM IN THIS VEHICLE BUT HAS NOT ADDRESSED IT. I FEAR DRIVING THIS VEHICLE WITH MY CHILDREN IT SHUT OFF IN THE MIDDLE OF THE HIGHWAY AT ONE POINT AND THEY HAVEN'T ADDRSSED IT. I'VE SPENT $4500 TO REPAIR AND THEY CANNOT RESOLVE THE PROBLEM AND I'M NOT CERTAIN THEY KNOW HOW.
- Steering
I HAVE A 2003 ML350 SUV. I BOUGHT MY CAR USED. I WAS WONDERING IF THERE WERE ANY RECALLS REGARDING STEERING. I HAVE REPLACED ONE RACK AND PIN WHICH I BELIEVE WAS USED. NOW I AM IN NEED OF ANOTHER ONE. *TR
- Seats1 injury
FRONT DRIVERS SIDE SEAT, BURNS WHEN HEATER IS TURNED ON. BURN SMELL, BURNED SKIN OF DRIVER. HAS THERE BEEN A RECALL ON THIS. I HAVE READ OF MANY INSTANCES OF THIS SAME COMPLAINT ON THE INTERNET. MERCEDES NEEDS TO REPLACE SEAT. *TR
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.