1999 Mercedes-Benz ML430 recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Electrical system

  DECEMBER 11, 2013 I WAS DRIVING HOME FROM WORK MY BENZ QUIT ON ME IN THE ROAD WOULD NOT START BACK (MY HOME IS WITHIN 2 MILES OF MY WORK) THE DAY BEFORE IT HAD QUIT AS I WAS MAKING A TURN BUT RESTARTED A COUPLE OF DAYS PRIOR I HAD THE CAR WARMING AND IT SHUT OFF WHILE WARMING UP BUT RESTARTED. THERE WAS NO LIGHTS ON THE INSTRUMENT DASH PANEL LIT OR STAYING LIT. AFTER SOME INTERNET INVESTIGATING I ASSUME IT WAS THE CRANKSHAFT POSITION SENSOR AS IT HAD ALL THE SIGNS THAT OTHERS HAVE HAD I PURCHASED ONE FOR THE REPAIR SHOP TO INSTALL. THEY HAVE INSTALLED IT BUT BELIEVE THERE IS A PROBLEM WITH THE CRANKSHAFT SO I AM NOT CURRENTLY DRIVING IT. I AM AFRAID TO DRIVE IT WITH IT QUITTING WITHOUT ANY…

  Dec 11, 2013 · 65,000 miles
• Engine

  AFTER EXITING THE FREEWAY I NOTICED A LOUD EXHAUST SOUND COMING FROM UNDERNEATH THE CAR. AFTER PULLING OVER IOOKED UNDERNEATH THE CAR ANT THE FRONT DRIVER'S SIDE CATALYTIC CONVERTER SPLIT IN HALF ALONG THE WELDS. *TR BASICALLY, THE EXHAUST IS VENTING DIRECTLY TO THE OPEN AIR WITHOUT GOING THROUGH THE EMISSION SYSTEM. THE LEFT SIDE EXHAUST NOT HOLDING TOGETHER CORRECTLY. I THEN FOUND THAT MY CAR HAS A MANUFACTURER DEFECT: MERCEDES-BENZ USA, LLC AND DAIMLERCHRYSLER AG SETTLEMENT (EPA) AFFECTED VEHICLES: THE FOLLOWING VEHICLES HAVE BEEN RECALLED TO INSPECT AND REPLACE, IF NECESSARY, THE CATALYTIC CONVERTER: 1999-2001 MERCEDES BENZ ML 320 (VIN RANGE A036519-A260405) 1999 -2001 MERCEDES BENZ ML…

  Apr 19, 2013 · 120,000 miles
• Service brakes, hydraulic

  THE BRAKELINES RUSTED THROUGH CAUSING A COMPLETE LOSS OF FLUID AND THE ABILITY TO STOP THE CAR. *TR

  Oct 20, 2011 · 71,000 miles
• Engine and engine cooling › Exhaust system › Emission control › Catalytic convertor

  TL* THE OWNS A 1999 MERCEDES-BENZ ML 430. THE CONTACT STATED WHILE DRIVING 25 MPH THE CATALYTIC CONVERTER STARTING MAKING A NOISE AND LEAKING. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC AND THE MECHANIC NOTICE THE WELDING WAS CRACKING. THE MECHANIC PULLED UP A RECALL AND SUGGESTED THE CONTACT TAKE THE VEHICLE TO THE DEALER. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR THE RECALL REMEDY REPAIR AND THE DEALER STATED DUE TO THE VIN NUMBER, THE VEHICLE IS NOT INCLUDED IN THE RECALL. THE DEALER SUGGESTED TO THE CONTACT THAT HE CALL MANUFACTURER. THE CONTACT CALLED THE MANUFACTURER AND THEY INFORMED THE CONTACT THEIR IS NOTHING THEY CAN DO AND THE RECALL CAMPAIGN IS CLOSED. THE CONTACT…

  Sep 15, 2010 · 98,000 miles
• Engine and engine cooling › Exhaust system › Emission control › Catalytic convertor

  TL* THE CONTACT OWNS A 1999 MERCEDES BENZ ML430. WHILE DRIVING AT 25 MPH, THE CONTACT HEARD A LOUD, UNUSUAL POP. THE CONTACT STATED THE VEHICLE SOUNDED SIMILAR TO A LOUD MOTORCYCLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE TWO FRONT CATALYTIC CONVERTERS WOULD NEED TO BE REPLACED. THERE WAS NOT A RECALL FOR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 131,700 AND THE CURRENT MILEAGE WAS 132,000.

  Jul 14, 2010 · 131,700 miles
• Visibility › Rearview mirrors/devices

  TL* THE CONTACT OWNS 1999 MERCEDES ML-430. THE CONTACT STATED THERE WAS OIL LEAKING FROM THE LED REAR VIEW MIRROR, FILTERING THROUGH THE MIRROR AND CAUSING VISIBILITY DIFFICULTIES. IN ADDITION, THE OIL WAS LEAKING INTO THE VEHICLE INTERIOR CORRODING THE STEERING WHEEL AND DASHBOARD. THE CONTACT FELT THE FAILURE WAS A SAFETY ISSUE BECAUSE IT WAS AFFECTING HER LINE OF SIGHT. THE FAILURE MILEAGE WAS 57,000 AND THE CURRENT MILEAGE WAS 57,000.

  Apr 5, 2010 · 57,000 miles
• Fuel system, gasoline

  THE CHECK ENGINE LIGHT CAME ON AND I TOOK IT TO THE MERCEDES DEALER. I WAS TOLD THAT MY FUEL TANK SENSOR IS BROKEN AND IT NEEDS TO BE REPLACED. MERCEDES DEALERS SELL THE FUEL TANK SENSOR WITH THE FUEL TANK AS ONE UNIT. THEREFORE THE COST OF REPLACEMENT IS ENORMOUS. IN ADDITION AFTER RESEARCHING THIS ISSUE. I HAVE FOUND THAT COMPLAINTS FOR THE ML MODELS AND THE FUEL TANK IS NUMEROUS AND WORTH NOTICING. THIS DEFECT HAS OCCURRED IN THE MAJORITY OF MERCEDES ML MODELS AND THE DEALER ACTUALLY HAS A HUGE INVENTORY OF FUEL TANKS IN ORDER TO PROFIT FROM THIS DEFECT. NOT ONLY IS IT DANGER BUT IT CAUSES A HEADACHE FOR CONSUMERS FOR FAIL THE EMISSIONS TEST BECAUSE OF THE CHECK ENGINE LIGHT AND THE…

  Apr 20, 2008 · 106,000 miles
• Power train › Driveline › Driveshaft

  TL*THE CONTACT OWNS A 1999 MERCEDES BENZ ML430. WHILE DRIVING IN REVERSE AND FORWARD AT 25 MPH, THE CONTACT HEARD A CLICKING SOUND UNDERNEATH THE CENTER OF THE VEHICLE. HE ASSUMED SOMETHING WAS LOOSE UNDER THE VEHICLE AND DROVE TO THE DEALER. THE DEALER NOTICED THAT THE FRONT DRIVESHAFT BEARING WAS LOOSE. AFTER REPAIRING THE SHAFT, THE DEALER DISCOVERED THAT THE TRANSFER CASE WAS ALSO CAUSING THE ISSUE. THE CONTACT FEELS THAT THE MANUFACTURER SHOULD REPAIR THE VEHICLE BECAUSE THE OWNER'S MANUAL DOES NOT STATE ANYTHING ABOUT REPAIRING THE TRANSFER CASE. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE CURRENT MILEAGE WAS 115,000 AND FAILURE MILEAGE WAS 85,000. UPDATED 04/13/09.*JB THE CONSUMER…

  Mar 21, 2009 · 85,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• BRAKE LINE CHAFEClosed

  ANALYSIS OF COMPLAINTS TO ODI AND MERCEDES AND WARRANTY CLAIM DATA SUBMITTED BY MERCEDES INDICATES THAT THE ALLEGED DEFECT HAS OCCURRED AT A LOW RATE (36.5 COMPLAINTS PER 100,000 VEHICLES AND 0.29 PERCENT WARRANTY CLAIM RATE), WITH NO DISCERNABLE DEFECT TREND INDICATING THAT THE RATE OF CHAFING RELATED BRAKE LINE FAILURES IS INCREASING.THERE HAVE BEEN NO NEW COMPLAINTS SINCE JANUARY 2009.WHEN THE ANALYSIS IS LIMITED TO INCIDENTS OF BRAKE LINE LEAKAGE THAT RESULTED IN ALLEGATIONS OF REDUCED BRAKE EFFECTIVENESS, THE RATE DROPS EVEN FURTHER (22.3 COMPLAINTS PER 100,000 VEHICLES AND 0.04 PERCENT WARRANTY CLAIM RATE). MERCEDES PROVIDED DATA SHOWING THAT IN THE RARE INSTANCES WHEN CHAFING DID PROGRESS TO BRAKE LINE LEAKAGE THE DRIVER WOULD BE IMMEDIATELY ALERTED TO A PROBLEM BY ILLUMINATION OF THE BRIGHT YELLOW ESP/BAS WARNING LAMP AND CHANGES IN BRAKE PEDAL FEEL.CONTINUED OPERATION WITH A…

  EA08009 · opened Apr 28, 2008 · closed Dec 16, 2009
• ENGINE CRANKSHAFT PULLEY FAILUREClosed

  THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF ENGINE CRANKSHAFT PULLEY HARMONIC BALANCER FAILURE THAT COULD RESULT IN LOSS OF POWER-STEERING ASSIST.ODI HAS RECEIVED A TOTAL OF 546 NON-DUPLICATIVE REPORTS THAT ALLEGE ENGINE CRANKSHAFT PULLEY HARMONIC BALANCER FAILURE ON ALL MERCEDES-BENZ VEHICLES USING THE SUBJECT COMPONENT.THE SUBJECT COMPONENT FAILURES ARE PROGRESSIVE IN NATURE AND ONLY A SMALL PERCENTAGE OF THE COMPLAINTS AND WARRANT CLAIMS INVOLVED A FAILURE THAT HAD PROGRESSED FAR ENOUGH TO EFFECT POWER STEERING PERFORMANCE (6 OF 55 ODI COMPLAINTS REFERENCE INCREASED STEERING EFFORT).THERE HAVE BEEN NO CRASHES OR INJURIES RELATED TO THE ALLEGED DEFECT.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE…

  PE03058 · opened Dec 17, 2003 · closed Apr 22, 2004