2000 Mercedes-Benz ML430 recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Service brakes

  Problem is with the BAS/ABS. The problem was confirmed by two (2) separate drivers of the vehicle in question. The problem occurred on 4 or 5 separate occasions, all within the last 120 days. The BAS/ABS light on the dashboard indicated random conditions (off when first starting the engine, then on after approximately 1 to 2 minutes). Regardless of the BAS/ABS light status the vehicle appeared to be operating normally. Then suddenly without warning the brakes jammed on pulling hard to the right, then to the left. The problem occurs randomly at various speeds. Speeds as lows 3 to 5 MPH. Other times at highway speeds often in heavy traffic. On each occasion, cars following behind, and on each…

  Mar 28, 2023
• Service brakes

  I have 2000 ML 430. When I drive my car once a while brakes will engage without the warning, no matter how fast or slow I go. It is a very scarry situation.. The shop I went to replaced the ABS module and the problem went away for about 6 months. After that I have experienced one more hard braking but again everything went to "normal". I do take good care of mine old ML 430 and the car is in in excellent condition,, so lack of proper maintenance is not an issue here. No matter what it is, I drive my car with both hands on the steering wheel since. I have posted a thread about this in Facebook and other Mercedes Benz Forums and asked how many others have experienced this brakes locking…

  May 12, 2021
• EngineFire

  The contact owned a 2000 Mercedes Benz ML430. The contact stated that while driving approximately 40 mph the ABS light had illuminated and smoke was present coming from the steering column. Moments later flames were present coming from under the hood and the subframe of the vehicle. The driver exited the vehicle and the local fire department was called to the scene and extinguished the flames. During the incident, the vehicle was destroyed and later towed away. A police report was filed at the scene. The cause of the failure was not yet determined. The local dealer and manufacturer were not contacted. The failure mileage was 135,000. The VIN was not available.

  May 26, 2021 · 135,000 miles
• Air bags

  SRS LIGHT ON

  Aug 1, 2019
• Service brakes

  WHILE DRIVING AT 60 MILES PER HOUR ON EXPRESSWAY, CAR SUDDENLY BRAKED ON ONLY THE LEFT FRONT WHEEL. BRAKING WAS A SEVERE PUMPING THAT LASTED ABOUT 2 SECONDS. WAS ABLE TO MOVE OFF TO THE SIDE OF THE ROAD ONTO AN EXIT RAMP WITHOUT CAUSING AN ACCIDENT. FORTUNATELY TRAFFIC WAS NOT HEAVY AND CARS BEHIND ME WERE ABLE TO AVOID HITTING ME AS THE CAR BUCKED AND I MOVED TO THE SIDE OF TH ROAD ONTO AN EXIT RAMP. I STOPPED TO SEE WHAT MAY HAVE HAPPENED. NOTING NOTHING RELATED TO THE LEFT RONT WHEEL, I EXITED THE EXIT RAMP AND PROCEEDED DOWN A SIDE STREET AT AB OUT 35 MPH WHEN SUDDENLY THE LEFT FRONT WHEEL BRAKED AGAIN. I TURNED OFF THE ESP ELECTRONIC STABILITY FUNCTION AND PROCEEDED SLOWLY DOWN THE…

  Nov 16, 2017 · 187,300 miles
• Exterior lighting

  TL* THE CONTACT OWNS A 2000 MERCEDES-BENZ ML430. WHILE DRIVING 30 MPH, THE POWER STEERING, EST, AND ABS WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF PITTSBURGH (4709 BAUM BLVD, PITTSBURGH, PA 15213) WHERE IT WAS DIAGNOSED, BUT NO CODES WERE POPULATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 172,000. UPDATED 11/03/17*LJ THE CONSUMER PROVIDED CODES C114214 AND C114209 UPDATED 12/1/2017*JS

  Aug 11, 2017 · 172,000 miles
• Electrical system

  TL* THE CONTACT OWNS A 2000 MERCEDES-BENZ ML430. THE CONTACT STATED THAT VARIOUS WARNING INDICATORS FLASHED ON THE INSTRUMENT PANEL SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A DEALER (BOBBY RAHAL MOTORCAR COMPANY, 10701 PERRY HWY, WEXFORD, PA 15090, (724) 935-9300) WHO WAS UNABLE TO REPLICATE AND DIAGNOSE THE FAILURE WITH THE DTC PRESENT WHEN THE VEHICLE WAS INSPECTED BY THE DEALER'S MECHANIC(S). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE TO DETERMINE IF THEY COULD PROVIDE A TECHNICIAN AND A SOLUTION TO REPAIR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 172,000. UPDATED 10/26/17*LJ THE CONSUMER STATED PROBLEMS WITH VAN CONTROL, ABS LIGHT ON, BALL JOINT…

  Jul 28, 2017 · 172,000 miles
• Vehicle speed control

  MY VEHICLE WAS UNDER RECALL AND WAS SERVICED ON FEB 9TH 2015 FOR BRAKE SWITCH DEALING WITH CRUISE CONTROL AND POWER STEERING LOW PRESSURE HOSE ON 3/11/2017 THE SAME PROBELMS OCCURED AND IT IS A MANUFACTOR ISSUE AND NOT GETTING JUSTICE FOR GETTING MY VEHICLE REPAIRED FOR SAME ISSUE VEHICLE AS I WAS DRIVING CAR IT WAS FIXED BY MERCEDES-BENZ OF WAPPINGERS FALLS ON FEB 9TH 2015 BUT SAME ISSUE RETURNED.

  Mar 11, 2017 · 199,205 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• Brake lamp switch failure.ClosedLed to recall 11V208000

  ODI opened the investigation based on reports that the subject vehicle brake lamp switch (switch) failure caused 1) inoperative brake lamps (stay on or fail to illuminate), and/or 2) shift interlock failure (shifter locked in park), and/or 3) the cruise control to fail to cancel with brake application.Consumers also reported the illumination of a warning lamp on the instrument panel.The switch contains three sets of electrical contacts and a (normally extended) spring loaded plunger that actuates the contacts as it moves.As installed in the vehicle, the plunger contacts the brake pedal arm and is pushed into the switch; as the driver applies the pedal the plunger extends.One set of contacts (BLS) operates the stop lamps, a second set (EWM) controls the shift interlock system, and a third set (BS) is used by an on-board diagnostic (OBD) system to monitor switch operation.The cruise…

  PE10050 · opened Dec 21, 2010 · closed May 4, 2011
• BRAKE LINE CHAFEClosed

  ANALYSIS OF COMPLAINTS TO ODI AND MERCEDES AND WARRANTY CLAIM DATA SUBMITTED BY MERCEDES INDICATES THAT THE ALLEGED DEFECT HAS OCCURRED AT A LOW RATE (36.5 COMPLAINTS PER 100,000 VEHICLES AND 0.29 PERCENT WARRANTY CLAIM RATE), WITH NO DISCERNABLE DEFECT TREND INDICATING THAT THE RATE OF CHAFING RELATED BRAKE LINE FAILURES IS INCREASING.THERE HAVE BEEN NO NEW COMPLAINTS SINCE JANUARY 2009.WHEN THE ANALYSIS IS LIMITED TO INCIDENTS OF BRAKE LINE LEAKAGE THAT RESULTED IN ALLEGATIONS OF REDUCED BRAKE EFFECTIVENESS, THE RATE DROPS EVEN FURTHER (22.3 COMPLAINTS PER 100,000 VEHICLES AND 0.04 PERCENT WARRANTY CLAIM RATE). MERCEDES PROVIDED DATA SHOWING THAT IN THE RARE INSTANCES WHEN CHAFING DID PROGRESS TO BRAKE LINE LEAKAGE THE DRIVER WOULD BE IMMEDIATELY ALERTED TO A PROBLEM BY ILLUMINATION OF THE BRIGHT YELLOW ESP/BAS WARNING LAMP AND CHANGES IN BRAKE PEDAL FEEL.CONTINUED OPERATION WITH A…

  EA08009 · opened Apr 28, 2008 · closed Dec 16, 2009
• ELECTRONIC STABILITY CONTROL MALFUNCTIONClosed

  ODI OPENED PE07-007 AFTER RECEIVING 4 COMPLAINTS WITHIN A 6 WEEK PERIOD ALLEGING INCIDENTS OF UNCOMMANDED BRAKE APPLICATION IN MODEL YEAR (MY) 2000 THROUGH 2001 MERCEDES M CLASS SPORT UTILITY VEHICLES.INFORMATION CONTAINED IN THE REPORTS OR GATHERED IN SUBSEQUENT CONSUMER INTERVIEWS INDICATED THAT THE INCIDENTS WERE CAUSED BY FAULTS IN THE ELECTRONIC STABILITY PROGRAM (ESP) SYSTEM WHICH WERE REPAIRED BY REPLACING THE YAW RATE SENSORS.ALTHOUGH THE SAME YAW RATE SENSOR IS USED IN APPROXIMATELY 800,000 OTHER MERCEDES M-CLASS, C-CLASS AND SLK MODELS, TO DATE THERE HAS BEEN ONLY ONE RELATED COMPLAINT TO ODI IN THOSE VEHICLES. DURING THIS INVESTIGATION MERCEDES BENZ PROVIDED ODI WITH 327 COMPLAINTS RELATED TO THE ESP SYSTEM IN THE MY 2000 THROUGH 2001 M CLASS VEHICLES.SEVEN OF THE COMPLAINTS SUBMITTED BY MERCEDES ALLEGED INCIDENTS OF UNCOMMANDED BRAKE ACTIVATION WHILE DRIVING, WITH TWO OF…

  PE07007 · opened Feb 1, 2007 · closed Jul 11, 2007
• ENGINE CRANKSHAFT PULLEY FAILUREClosed

  THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF ENGINE CRANKSHAFT PULLEY HARMONIC BALANCER FAILURE THAT COULD RESULT IN LOSS OF POWER-STEERING ASSIST.ODI HAS RECEIVED A TOTAL OF 546 NON-DUPLICATIVE REPORTS THAT ALLEGE ENGINE CRANKSHAFT PULLEY HARMONIC BALANCER FAILURE ON ALL MERCEDES-BENZ VEHICLES USING THE SUBJECT COMPONENT.THE SUBJECT COMPONENT FAILURES ARE PROGRESSIVE IN NATURE AND ONLY A SMALL PERCENTAGE OF THE COMPLAINTS AND WARRANT CLAIMS INVOLVED A FAILURE THAT HAD PROGRESSED FAR ENOUGH TO EFFECT POWER STEERING PERFORMANCE (6 OF 55 ODI COMPLAINTS REFERENCE INCREASED STEERING EFFORT).THERE HAVE BEEN NO CRASHES OR INJURIES RELATED TO THE ALLEGED DEFECT.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE…

  PE03058 · opened Dec 17, 2003 · closed Apr 22, 2004