Model year record

1993 Pontiac Trans Sport recalls & problems

The 1993 Pontiac Trans Sport has 3 safety recalls and 61 owner complaints on file with NHTSA. The most-reported problem area is seat belts (27 complaints).

Recalls3safety recalls

Complaints61filed by owners

Crashes · fires1 · 7reported in complaints

Injuries · deaths2 · 0reported in complaints

Safety recalls

Power trainJan 23, 1996

Automatic transmission › Cooling unit and lines

Recall 96V015000585,182 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES MANUFACTURED FROM AUGUST 1991 THROUGH JULY 1995. THE TRANSMISSION OIL COOLER LINE CAN SEPARATE WHEN THE VEHICLE IS OPERATED IN LOW TEMPERATURES IN COMBINATION WITH HIGH TRANSMISSION LOADS.
Risk: VEHICLE FIRES CAN OCCUR DUE TO THE SPILLAGE OF TRANSMISSION FLUID.
Fix: DEALERS WILL REPLACE THE TRANSMISSION OIL COOLER LINES.

Seat beltsMay 24, 1994

Front › Webbing

Recall 94V1000005,294 vehicles

Problem: THE SECOND ROW, RIGHT HAND SHOULDER BELT CAN BECOME "PINCHED" BETWEEN THE SEAT AND THE DOOR FRAME PILLAR TRIM. THE SHOULDER BELT MAY NOT RETRACT PROPERLY, WHICH DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE 1994 VEHICLES HAVE AN OPTIONAL INTEGRAL (BUILT IN) CHILDSEAT INSTALLED NEXT TO THE POWER SLIDING SIDE DOOR. THE 1993 INVOLVED VEHICLES HAVE STANDARD SEATS IN THAT SAME POSITION.
Risk: IMPROPER SHOULDER BELT RETRACTION DOES NOT PROVIDE ADEQUATE PROTECTION TO THE SEAT OCCUPANT IN THE EVENT OF A SUDDEN STOP OR COLLISION.
Fix: DEALERS WILL REPLACE THE DOOR FRAME PILLAR TRIM PANEL WITH A REDESIGNED TRIM PANEL. ALSO, A CAUTION LABEL WILL BE APPLIED TO THE CHILD SEAT ADVISING THE OWNER NOT TO INSTALL THE SEAT TO THE PASSENGER SIDE OF A VEHICLE WITH A POWER SLIDING SIDE DOOR.

Seat beltsJan 4, 1994

Rear/other

Recall 94V027000157,740 vehicles

Problem: VEHICLE FAILS TO CONFORM TO FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE SAFETY BELT OF THE LEFT THIRD ROW SEAT ON THE SIX PASSENGER VAN AND THE CENTER SECOND ROW SEAT OF THE SEVEN PASSENGER VAN MAY LOCK UP AND CANNOT BE WITHDRAWN FROM THE RETRACTOR.
Risk: CONSEQUENCE OF NON-COMPLIANCE: THE OCCUPANTS OF THESE SEATS WILL NOT BE ABLE TO USE THE AFFECTED BELT. IN THE EVENT OF A VEHICLE CRASH, UNBELTED OCCUPANTS ARE AT INCREASED RISK OF INJURY.
Fix: OWNERS ARE BEING ASKED TO INSPECT THEIR VEHICLES TO DETERMINE IF THE SUSPECT RETRACTOR EXHIBITS A LOCKUP CONDITION. BASED ON THIS INSPECTION, DEALERS WILL REPLACE THE SAFETY BELTS IF THE BELT LOCKS UP. REPLACEMENT OF THE SUSPECT SAFETY BELT WILL BE AVAILABLE TO CONSUMERS FOR THE LIFE OF THE VEHICLE.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

1993 Pontiac Trans Sport.

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Trans Sport 2WD

18mpg combined

City / highway	16 / 21 mpg
Fuel	Regular Gasoline

3.1 L · 6 cyl · Automatic 3-spd · Front-Wheel Drive · about $3,700/year to fuel

Trans Sport 2WD

18mpg combined

City / highway	15 / 23 mpg
Fuel	Regular Gasoline

3.8 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,700/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Seat beltsFront › Retractor; Front › Webbing	27	0	0	0	—
Power trainAutomatic transmission; Automatic transmission › Cooling unit and lines	9	0	5	1	—
Electrical systemWiring › Front underhood; Wiring	8	2	4	0	—
VisibilityWindshield wiper/washer; Power window devices and controls	6	1	1	1	—
Service brakes, hydraulicFoundation components › Disc › Rotor; Power assist › Vacuum › Hoses, lines/piping, and fittings	5	0	0	0	—
Engine and engine coolingEngine › Gasoline; Engine	5	1	1	0	—
WheelsLugs/nuts/bolts/studs	3	0	0	0	—
Unknown or other	3	0	0	0	—
Fuel system, gasolineDelivery › Fuel pump	3	1	1	0	—
Latches/locks/linkagesHatchback/liftgate › Lock; Doors › Latch	2	0	0	0	—
StructureBody › Door	2	0	0	0	—
Vehicle speed control	1	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Visibility/wiper
TL* THE CONTACT OWNS A 1993 PONTIAC TRANSPORT. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE WIPER MOTOR FAILED WITHOUT WARNING. THE VEHICLE WAS NOT REPAIRED AND THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 98,000. *TR
Jan 15, 2013 · 98,000 miles
Wheels › Lugs/nuts/bolts/studs
1993 PONTIAC TRANS SPORT, LOST RIGHT FRONT WHEEL FROM HUB. WHEEL STRUCK FRONT FENDER CAUSING DAMAGE. THE RIGHT FRONT HUB STRUCK THE PAVEMENT. *BF ACCORDING TO THE POLICE REPORT, ONE LUG STUD INTACT WAS BENT ON THE HUB. FOUR STUDS WERE SHEARED OR BROKEN OFF. (OHIO TRAFFIC CRASH REPORT # 10-0476-90)*JB UPDATED 09/13/10*BF
Jul 20, 2010
Electrical systemCrashFire
THIS IS A CONTINUAL PROBLEM SINCE I TOOK OWNERSHIP IN MARCH 2000. IT STARTED W/ THE "SERVICE ENGINE SOON" LIGHT OCCASIONALLY TURNING ON. AFTER HAVING THE VEHICLE LOOKED AT - THEY COULD FIND NO PROBLEM. AS TIME PASSED, THE LIGHT CAME ON MORE & MORE FREQUENTLY. THE ENGINE THEN BEGAN TO IDLE HIGH AND WOULD GO INTO A "SUPER IDLE" WHERE I WOULD HAVE TO NEARLY STAND ON THE BRAKE PEDAL TO STOP THE FORWARD MOTION AT A STOP. OW THE "SERVICE ENGINE SOON" LIGHT IS COMING ON CONSTANTLY AND THE VEHICLE STALLS CONSTANTLY. I DRIVE A TOTAL OF 10 MILES TO WORK & THIS VEHICLE WILL NOW STALL A MIN. OF 5X EACH WAY. I EXPERIENCE POWER DRAIN, THE BATTERY INDICATOR WILL SHOOT UP TO BETWEEN 18 + 15, LIGHTS WILL…
Jan 7, 2005
Electrical system › Wiring › Front underhoodFire
WHILE DRIVING VEHICLE STALLED. CONSUMER PULLED OVER AND NOTICED SMOKE COMING FROM THE HOOD. VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE. NO INJURIES REPORTED. VEHICLE WAS TOWED AND TOTALED BY THE INSURANCE COMPANY. *AK
Sep 30, 2004
Visibility › Windshield wiper/washer › Motor
WINDSHIELD WIPERS INTERMITTENTLY QUIT WHILE IN USE. THIS HAS BEEN OCCURING SINCE PURCHASING THE VAN IN 1998. OTHER GMC VEHICLES HAVE BEEN RECALLED FOR THIS PROBLEM BACK TO 1994. NUMEROUS TIMES I HAVE TO PULL OVER DURING A STORM BECAUSE OF THE FAILURE.*AK
Jan 1, 1999 · 100,000 miles
Seat belts › Rear/other
NHTSA# 94 V 027 000/SEAT BELT LAP REAR: CONSUMER STATES THAT THE DEALER, LONG PONTIAC IN CHATTANOOGA, TN. PHONE# 423/756-4501 REFUSED TO HONOR THE RECALL NOTICE. DEALER STATES THAT THE VEHICLE VIN# WAS NOT COVERED. *MRTHE SEAT BELT LOCKED UP AND IT WILL NOT RETRACT. DEALER STILL WILL NOT HONOR THE RECALL. *JG
Sep 10, 2002
Electrical system › 12v/24v/48v battery
SEAT BELTS:EVERY SEAT BELT IN THIS VEHICLE HAS BECOME "NON-FUNCTIONING" BETWEEN 7/01/97 AND PRESENT. SEAT BELT RETRACTORS NOT WORKING, AND THE LOCKING MECHANISM AT SUDDEN STOPS DOES NOT FUNCTION, MAKING EACH SEATBELT IN THIS VEHICLE USELESS AND ENDANGERING PASSENGERS. DEALERSHIP HAS BEEN CONTACTED SEVERAL TIMES, AND DENIES THEY HAVE ANY RESPONSIBILITY FOR REPAIRS. MANUFACTURER CLAIMS THERE ARE NO "OPEN" RECALLS ON THIS VEHICLE, ALTHOUGH THEY CANNOT VERIFY IF THE RECALLS LISTED HAVE IN FACT EVER BEEN COMPLETED. ALTERNATOR:HAVE HAD MAJOR ALTERNATOR/BATTERY PROBLEMS, SEVERAL REPLACEMENTS TO THE ALTERNATOR, LOW VOLTAGE AND GRADUAL LOSS OF POWER, UNSTEADY VOLTAGE METER...HAVE HAD THE FUSEABLE…
Jul 1, 1997
Visibility › Power window devices and controls
CONSUMER STATES WHILE DRIVING AND WITHOUT WARNING THE DRIVER SIDE WINDOW ROLLED DOWN ON ITS OWN, SECONDS LATER SMOKE STARTED SEEPING OUT OF THE CONTROLS.*JB
May 16, 2002

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

TRNSAXL OIL HOSE SEPARATESClosed
There is no summary currently available
PE94070 · opened Sep 15, 1994 · closed Jan 18, 1995