2025 Toyota Corolla recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Tires

  225/40R18 88V

  Jan 6, 2026
• Electrical systemFire

  I pulled into XXX drive way at 6:53pm XXX. By 7:12 pm we were on the phone with 911. My car alarm when off. I went over to my car. It was smoking had a bad smell it smelt like it was about to explode. It wouldn’t let me unlock the car. Finally after 5 minutes it finally unlocked there is literal flames on the driver side dash and floor board. We used a fire extinguisher it was still smoking so we put water on it. When the fire department finally showed up the dash was still 182 degrees. They used their high water power fire extinguisher. The battery was also unplugs before the fire was completely out. And state farm called a tow truck to take it to pohanka in Salisbury Md.

  Aug 23, 2026
• Tires

  The contact owns a 2025 Toyota Corolla equipped with Dunlop Tires, Tire Line: SP Sport 5000, Tire Size: 225/40/R18, DOT Number: 1EUT74MBR5024. The contact stated that while driving on several occasions at various speeds, there was an abnormal sound coming from each tire, and the tires were slick while driving in inclement weather. The vehicle was taken to the dealer, where it was determined that all four tires needed to be replaced due to uneven wear. The vehicle was not repaired. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was 8,000.

  Jan 8, 2026 · 8,000 miles
• Tires

  Premature wear and tear

  Jan 15, 2026
• Air bagsCrash1 injury

  I was broadsided at the front end of the drivers side on Saturday 07/25/2026 by a wayward vehicle drifting into my lane. After the crash, the airbags deployed and then I could not open the driver seat door. Three other passer-bys who kindly stopped to check on me could not open the door from outside either. Finally, after being stuck for at least 10 minutes in the car, the police arrived, who somehow managed to open the door and let me out. This is a serious safety hazard; if the car caught fire, I could be burnt alive.

  Jul 25, 2026
• Air bagsCrash2 injuries

  It was heavy rain traffic came and when I slowed down the anti lock breaks effected me from stopping fast enough and were made me just slid into back off vehicle in front off me giving me injury's to my kneck due to the air bags did NOT deploy.

  Jun 8, 2026
• Tires

  The contact owns a 2025 Toyota Corolla equipped with Dunlop Tires, Tire Line: SP Sport, Tire Size; 225/40/R18, DOT Number: (N/A). The contact stated that while driving approximately 50–60 MPH, the rear end of the vehicle was uncontrollable. The vehicle was driven to the shoulder of the roadway. The contact inspected the vehicle and became aware that the rear driver's and passenger’s side tires were cupping. The contact stated that the tires were original equipment. The vehicle was towed to the dealer; however, the failure was not duplicated. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 28,000.

  Jun 18, 2026 · 28,000 miles
• Service brakesCrash

  I performed a search on Google for any corolla's braking problem and found an incident "EXACTLY" like my daughter experienced! Here is the link to it on Reddit - Terrifying brake failure on my new 2025 Corolla Hybrid – Pedal went to the floor with zero warning! [XXX] BELOW IS THE VERBIAGE FROM TOYOTA CUSTOMER SERVICE SENT BACK TO ME 06/19/2026: Thank you for contacting our Brand Engagement Center regarding the incident that occurred on [XXX], and was reported to us on May 12, 2026. You reported that while your daughter was driving your 2025 Toyota Corolla Hybrid, she experienced a brake failure incident causing a collision to occur. You stated that she was exiting to the right and applied…

  Apr 24, 2026

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.