Model year record
2000 Volkswagen EuroVan recalls & problems
The 2000 Volkswagen EuroVan has no safety recalls on file with NHTSA, and 25 owner complaints. The most-reported problem area is engine and engine cooling (13 complaints).
Safety recalls
No safety recalls have been filed for the 2000 Volkswagen EuroVan.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Fuel economy
Eurovan
| City / highway | 13 / 18 mpg |
|---|---|
| Fuel | Regular Gasoline |
2.8 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $4,450/year to fuel
Eurovan Camper
| City / highway | 13 / 17 mpg |
|---|---|
| Fuel | Regular Gasoline |
2.8 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $4,800/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Engine and engine coolingCooling system › Fan; Cooling system | 13 | 43,001 mi |
| VisibilityWindshield; Power window devices and controls | 3 | — |
| Electrical systemWiring › Front underhood; Wiring › Interior/under dash | 3 | 49,000 mi |
| Service brakes, hydraulicFoundation components › Disc; Foundation components › Drum | 2 | — |
| EquipmentAppliance › Air conditioner; Mechanical › Carrier/rack | 2 | — |
| Exterior lightingBrake lights; Headlights | 2 | — |
| Seat beltsRear/other › Buckle assembly | 2 | — |
| Latches/locks/linkages | 1 | — |
| Unknown or other | 1 | — |
| SteeringHydraulic power assist › Power steering fluid | 1 | — |
| Fuel/propulsion system | 1 | — |
| Seats | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Seat belts1 injury
I WAS DRIVING IN TOWN ON A CITY STREET ON MY WAY TO CHURCH AND THE DRIVERS SIDE SEAT HEATER BURNED THROUGH AND MELTED MY COAT A LITTLE BIT. MY BACK FELT BURNED A LITTLE BIT BUT WENT AWAY AFTER AWHILE SO I DID NOT HAVE ANY LASTING PAIN. BUT MY GOOD CHURCH COAT WAS LEFT WITH A SLIGHTY MELTED AREA ON IT. THE PASSENGER SIDE DID NOT BURN BECAUSE THE HEATER DOESNT WORK ANYMORE.
- Fuel/propulsion system
THE ISSUE WITH THE VEHICLE IS THAT AN EXCESSIVE AMOUNT OF PRESSURE AND HEAT BUILDS UP INSIDE THE GAS TANK WHILE DRIVING AT ANY SPEED AND TO EVEN A GREATER EXTENT WHEN IN STOP-N-GO TRAFFIC OR SITTING IN THE PARKING LOT IDLING. THE RESULT IS THAT WHEN OPENING THE GAS CAP FROM HOT FUMES AND FUEL SPRAY OUT AFTER RUNNING THE VEHICLE FOR LESS THAN AN HOUR. THERE ARE NO CHECK ENGINE LIGHTS OR CHECKS IN PLACE TO WARN OR PREVENT THIS FROM HAPPENING. IT IS A MAJOR SAFETY CONCERN! I HAVE BEEN WORKING WITH THE VW DEALER FOR OVER ONE YEAR NOW BUT STILL NO RESOLVE. UNDER THE DIRECTION OF VW OF AMERICA THEIR CERTIFIED MECHANICS HAVE SYSTEMATICALLY REPLACED ALMOST ALL OF THE COMPONENTS RELATING TO THE FUEL…
- Engine and engine cooling › Cooling system
FAN FOR COOLING THE AIR CONDITIONING UNIT (IN ENGINE COMPARTMENT) BLEW APART, DAMAGING ELECTRONIC COMPONENTS ADJACENT TO IT. THE OTHER FAN (FOR ENGINE COOLING) FAILED LAST YEAR. *TR
- Equipment › Mechanical › Carrier/rack
TL*THE CONTACT OWNS A 2000 VOLKSWAGEN EUROVAN. THE CONTACT STATED THAT THE METAL BRACKET, WHICH HOLDS THE LUGGAGE RACK ONTO THE VEHICLE, WAS RUSTED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT IT WAS CAUSED BY THE WEATHER. THE CURRENT MILEAGE WAS 90,000 AND FAILURE MILEAGE WAS 30,000. UPDATED 10/18/07 *TR
- Engine and engine cooling › Cooling system › Fan
ENGINE COOLING FAN ON DRIVER'S (LEFT) SIDE BROKE AND LOST A PIECE, CAUSING THE FAN TO BECOME UNBALANCED. THE LACK OF BALANCE CAUSED SEVERE VIBRATION IN THE CAR. CAR IS CURRENTLY IN THE SHOP FOR REPAIR (REPLACEMENT) OF THE FAN. *TR
- Seat belts › Rear/other › Buckle assembly
MY KID PULLED ON HIS SEAT BELT TO FASTEN IT, AND THE MALE LATCH CAME DETACHED FROM THE BELT. THE LATCH IS MADE BY TRW-AUTOMOTIVE, THE WORLD'S LARGEST PROVIDER OF SEAT BELT SYSTEMS. IT HAS THE FOLLOWING IDENTIFICATION: 0006 5980 TRW. THE SEAT BELT THAT FAILED IS A LAP-BELT ONLY (CENTER-SEAT). THE LATCH CONSISTS OF TWO SLIDING METAL PARTS AND A PLASTIC COVER. WHEN THE PLASTIC COVER BREAKS, THE BELT COMES LOOSE FROM THE MALE LATCH. THE SEAT BELT CAN FAIL IN A CRASH RESULTING IN INJURY FROM THE CRASH. I REPORTED THIS TO VW CUSTOMER CARE, 800-822-8987. THEY ENTERED IT INTO THEIR DATABASE, AND TOLD ME TO GO TO A VW DEALER TO GET A REPAIR. *NM
- Engine and engine cooling › Cooling system › Fan
MY WIFE, ON A RECENT DRIVE FROM NO. CALIFORNIA TO SOUTHERN CA NOTED AN UNUSUAL SOUND FROM UNDER THE HOOD. NO OVERHEATING OR OTHER ISSUES THOUGH. WHEN SHE STOPPED SHE NOTED ONE OF THE PLASTIC RADIATOR FANS WAS BROKEN IN MULTIPLE PIECES. SINCE SHE WAS AWAY FROM HOME I TOLD HER TO GO TO THE LOCAL DEALER FOR REPAIRS. THEY DECIDED THE ENTIRE FAN ASSEMBLY HAD TO BE REPLACED, AND THAT THE RADIATOR HAD TO BE REPLACED AS WELL. THE PARTS ALONE WERE ABOUT $2300 TOTAL REPAIR FOR THIS ABOUT $2900. WHEN THEY RETURNED THE CAR SHE FOUND THAT THE AC WAS NO LONGER WORKING. SO BACK TO THE DEALER. THEY STATED THE AC COMPRESSOR WAS BAD (BTW THE AC WORKED WELL PRIOR TO THE RADIATOR EVENT) SO THE COMPRESSOR AND…
- Engine and engine cooling › Cooling system › Fan
2000 VOLKSWAGEN EUROVAN ENGINE COOLING FAN BROKE APART.*MR WHILE DRIVING THE VEHICLE BEGAN TO VIBRATE VIOLENTLY. THE CONSUMER PULLED OFF TO THE SIDE OF THE ROAD TO INSPECT THE VEHICLE. UPON INSPECTION HE NOTICED THAT ONE OF THE COOLING FANS HAD BROKEN. THE CONSUMER DID SOME RESEARCH ABOUT FOUND OUT THAT 1998-2000 EUROVANS HAD BEEN RECALLED FOR THE EXACT SAME PROBLEM BUT THE CONSUMER'S VEHICLE WAS NOT INCLUDED DUE TO VIN. *NM
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
- ENGINE COOLING FAN BLADE SEPARATIONClosed
THE OFFICE OF DEFECTS INVESTIGATION OPENED A PRELIMINARY EVALUATION (PE)03-015 ON APRIL 15, 2003, BASED ON THREE REPORTS ALLEGING THAT FAN BLADES SEPARATED FROM THE ENGINE ELECTRONIC COOLING FAN.ALL THREE VEHICLES WERE WINNEBAGO RIALTA CLASS C MOTOR HOMES BUILT ON A VOLKSWAGEN EUROVAN CHASSIS.DURING THE PE INVESTIGATION, VOLKSWAGEN PROVIDED 125 ADDITIONAL REPORTS OF FAN FAILURES.THE ADDITIONAL REPORTS INCLUDED 107 REPORTS ON RIALTA VEHICLES (ALL USING A SIEMENS MANUFACTURED COOLING FAN) AND 18 REPORTS ON EUROVAN VEHICLES (15 USING SIEMENS FANS AND 3 USING BOSCH FANS).AN ENGINEERING ANALYSIS INVESTIGATION (EA03-013) HAS BEEN OPENED FOR FURTHER STUDY.