CarRecordBook

Model year record

2004 Volvo Vn recalls & problems

The 2004 Volvo Vn has 4 safety recalls and 1 owner complaint on file with NHTSA. The most-reported problem area is electrical system (1 complaint).

Recalls4safety recalls
Complaints1filed by owners
Crashes · fires0 · 0reported in complaints
Injuries · deaths0 · 0reported in complaints

Safety recalls

Seat beltsOct 18, 2012

Seat belts

Recall 12V5100001,496 vehicles

Problem
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 210, "Seat Belt Assembly Anchorages."
Risk
In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. This increases the risk of injury to the seat occupant.
Fix
Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
VisibilitySep 17, 2004

Windshield wiper/washer › Motor

Recall 04V45700056,154 vehicles

Problem
ON CERTAIN TRUCKS EQUIPPED WITH VALEO WIPER SYSTEMS, THE WIPER MOTOR MAY BE SUSCEPTIVE TO SALT INTRUSION THAT COULD POSSIBLY LEAD TO A CONDITION WHERE THE CONNECTOR OVERHEATS TO A POINT WHERE THE CONNECTOR COULD IGNITE.
Risk
IF THIS OCCURS, EXCESSIVE HEAT AND SMOKE COULD RESULT IN AN UNDER HOOD FIRE.
Fix
DEALERS WILL INSPECT AND REPLACE THE CONNECTOR PLATE ON THE WINDSHIELD WIPER MOTOR. PHASE 2 OF THE RECALL BEGAN ON NOVEMBER 1, 2004. OWNERS SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
Power trainAug 12, 2004

Driveline › Driveshaft

Recall 04V4050004,032 vehicles

Problem
ON CERTAIN TRUCKS, THE BOLTS THAT RETAIN THE UNIVERSAL JOINT TO THE YOKE AT THE TRANSMISSION MAY NOT BE TIGHTENED CORRECTLY.
Risk
THIS CAN RESULT IN THE DRIVE SHAFT COMING LOOSE FROM THE TRANSMISSION, INCREASING THE RISK OF A CRASH.
Fix
DEALERS WILL REMOVE AND INSTALL REMOVING NEW BOLTS, INSPECT FOR CROSS-THREADED BOLTS, AND REPLACE THE YOKE IF NECESSARY. THE RECALL BEGAN OCTOBER 1, 2004. OWNERS SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
Trailer hitchesJul 2, 2004

Fifth wheel assembly

Recall 04V3150001,374 vehicles

Problem
ON CERTAIN TRUCKS, A MALFUNCTION IN THE SOLENOID VALVE MAY ALLOW AIR TO BE RELEASED TO FIFTH WHEEL LATCH WHEN THE PARK BRAKE IS ENGAGED.
Risk
THIS CONDITION COULD CAUSE THE FIFTH WHEEL LATCH TO RELEASE INADVERTENTLY WHEN THE PARK BRAKE IS ENGAGED, CREATING THE POTENTIAL FOR LOSS OF THE TRAILER. A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Fix
DEALERS WILL ADD AN ADDITIONAL SOLENOID VALVE IN SERIES WITH THE EXISTING PNEUMATIC CIRCUIT FOR THE FIFTH WHEEL AIR RELEASE. THE RECALL BEGAN ON AUGUST 9, 2004. OWNERS SHOULD CONTACT VOLVO AT 1-800-528-6586.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem areaComplaintsCrashesFiresInjuriesTypical mileage*
Electrical systemWiring › Fuses and circuit breakers1000—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations