NHTSA recall 10V566000 · Nov 8, 2010 · 416 vehicles
Problem: VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Risk: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Fix: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Crash test ratings
NHTSA side barrier crash test
2009 Volvo XC90 4-DR. w/SAB
Overall
Not Rated
Frontal crash
Not Rated
Side crash
Not Rated
Rollover
★★★★★
Rollover risk
17.9%
Forward collision warning: Optional · Lane departure warning: Optional
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
Fuel economy
XC90 FWD
17mpg combined
City / highway
14 / 20 mpg
Fuel
Regular Gasoline
3.2 L · 6 cyl · Automatic (S6) · Front-Wheel Drive · about $3,950/year to fuel
XC90 AWD
16mpg combined
City / highway
14 / 20 mpg
Fuel
Regular Gasoline
3.2 L · 6 cyl · Automatic (S6) · 4-Wheel or All-Wheel Drive · about $4,200/year to fuel
XC90 AWD
15mpg combined
City / highway
13 / 19 mpg
Fuel
Regular Gasoline
4.4 L · 8 cyl · Automatic (S6) · 4-Wheel or All-Wheel Drive · about $4,450/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Electrical system
3
0
0
0
58,640 mi
Service brakes
2
0
0
0
—
Engine
1
0
0
0
—
Structure Body
1
0
0
1
—
Wheels
1
0
0
0
—
Vehicle speed control
1
0
0
0
—
Unknown or other
1
0
0
0
—
Fuel/propulsion system
1
0
0
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Sep 28, 2022Fuel/propulsion system A plastic Fuel Pressure Sensor bracket holder, part number: 30720139, found on Volvo V8 XC90 and S80 (2005-2011) can crack, resulting in a fuel leak within the engine compartment. See attached picture of 30720139, with highlight of plastic assembly. No replacement part is available from Volvo, since ~Dec 2021, per this link: https://www.swedespeed.com/threads/06-xc90-v8-fuel-pressure-sensor-mount-snapped.640161/post-7969481 However, an aftermarket solution is now recently available: https://www.swedespeed.com/threads/volvo-v8-fuel-pressure-sensor-bracket-replacement-billet-6061.656808/#post-7986238 https://www.ebay.com/itm/115630747349
Sep 20, 2021Service brakes I have installed a SprintDrive installed in my Volvo. Since the installation, I have had several safety and security issues occur that stop once the device is removed. The following issues have occurred: 1) Whilst driving on the Muskogee Turnpike, the cruising control system would disengage. This occurred at least three times during the drive. On the third time, the cruising control system disengaged and the braking system engaged causing the vehicle to go from 85 mph to 45 mph. 2) I was driving on C-470. The transmission system would not transition between the gears automatically. The vehicle remained in a low gear until I removed the device. 3) I was driving on I-70 when all of the…
Aug 11, 2017 · 125,000 milesWheels REAR SPARE TIRE DROPPED OFF VEHICLE IN TRAFFIC SLIDING ACROSS THE FREEWAY, CATASTROPHIC FAILURE OF CABLE HOLDING REAR TIRE UNDER THE VEHICLE
Nov 20, 2015 · 76,000 miles · 1 injuryStructure › Body OPENED TRUNK HATCH DOOR TO PUT ITEMS IN TRUNK AND LIFTED DOOR TO THE FULL OPEN POSITION, THE HYDRAULIC ARMS BOTH FAILED AND THE FULL WEIGHT OF THE DOOR FELL DIRECTLY ONTO HEAD CAUSING SEVERE HEAD INJURY WITH RESIDUAL EFFECTS. NO PROBLEMS WITH TRUNK DOOR PRIOR TO THIS.
Jan 11, 2015 · 94,000 milesElectrical system TL* THE CONTACT OWNS A 2009 VOLVO XC90. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT ABLE TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER. THE CONTACT WAS UNAWARE OF THE REPAIRS THAT WERE PERFORMED ON THE VEHICLE. THE FAILURE RECURRED AND A FUSE WAS REPLACED; HOWEVER, THE FAILURE RECURRED AND THE ECM MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 94,000. THE VIN WAS NOT AVAILABLE.
Apr 11, 2014 · 58,640 milesElectrical system DURING SWITCHING OFF IGNITION A WARNING LIGHT WAS VISIBLE, ON TURNING ON IGNITION AGAIN MULTIPLE FAULTS REGISTERED ON THE INSTRUMENT CLUSTER.NO ISSUES PRIOR TO THIS FAULT OCCURRED. LIST OF FAULTS NOTICED: 1: SRS WARNING LIGHT (INSTRUMENT CLUSTER NOTIFICATION) 2: ABS FAILURE (INSTRUMENT CLUSTER NOTIFICATION) 3: PASSENGER AIRBAG OFF (INSTRUMENT CLUSTER NOTIFICATION) 4: PASSENGER AIRBAG FAULT-SERVICE REQUIRED (INSTRUMENT CLUSTER NOTIFICATION) 5: PASSENGER ELECTRICAL ASSIST SEAT NOT WORKING 5: HAZARD LIGHTS ONLY WORK WHEN IGNITION IS ON 6: VEHICLE CANNOT LOCK OR UNLOCK 7: REAR TAIL LIGHTS STAY ON CONTINUOUSLY EVEN AFTER REMOVAL OF IGNITION KEY. 8: NO BRAKE LIGHTS 9: NO TURN RIGHT SIGNALS (BACK…
Nov 1, 2010 · 32,000 milesElectrical system TL* THE CONTACT OWNS A 2009 VOLVO XC90. THE CONTACT STATED THAT THE VEHICLE HAD BEEN SITTING IDLE FOR FOUR DAYS. AFTER FOUR DAYS, THE CONTACT ATTEMPTED TO START THE VEHICLE BUT TO NO AVAIL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS HOWEVER THE ELECTRICAL DRAIN COULD NOT BE LOCATED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 32,000 AND THE CURRENT MILEAGE WAS 41,000.
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
