Model year record

2001 Winnebago Adventurer recalls & problems

The 2001 Winnebago Adventurer has 6 safety recalls and 14 owner complaints on file with NHTSA. The most-reported problem area is visibility (3 complaints).

Recalls6safety recalls

Complaints14filed by owners

Crashes · fires1 · 0reported in complaints

Injuries · deaths1 · 0reported in complaints

Safety recalls

EquipmentOct 26, 2010

Equipment

Recall 10V52500018,461 vehicles

Problem: WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
Risk: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Fix: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.

EquipmentJul 29, 2009

Equipment

Recall 09V3000001,547 vehiclesopened after NHTSA action (ODI)

Problem: WINNEBAGO IS RECALLING 1,547 MODEL YEAR 2001-2003 RECREATIONAL VEHICLES EQUIPPED WITH NORCOLD MODEL 1200LRIM REFRIGERATORS, MANUFACTURED FROM MARCH 1, 2001 TO DECEMBER 31, 2002, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.
Risk: IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.
Fix: WINNEBAGO IS WORKING WITH NORCOLD AND NORCOLD WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE (PLEASE SEE 09E-027). OWNERS MAY CONTACT NORCOLD'S RECALL CENTER AT 1-800-767-9101.

Service brakes, hydraulicFeb 21, 2003

Brake fluid low warning › Lamp

Recall 03V0600008,532 vehicles

Problem: CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105,"HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY THE STANDARD.
Risk: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE SYSTEM WARNING INDICATOR.
Fix: DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 25, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-3535.

Fuel system, otherAug 7, 2001

Delivery › Hoses, lines/piping, and fittings

Recall 01V252000154 vehicles

Problem: VEHICLE DESCRIPTION: MOTOR HOMES BUILT ON A WORKHORSE CHASSIS. THE BLACK PIPE SUPPLYING LIQUID PROPANE (LP) GAS TO THE FURNACE WAS NOT LONG ENOUGH, WHICH COULD CAUSE THE COPPER LINE THAT IS CONNECTED TO THIS PIPE TO COME IN CONTACT WITH THE END OF THE LEAF SPRING OF THE SUSPENSION.
Risk: IF THIS HAPPENS, THE COPPER LINE MAY GET DAMAGED AND OVER TIME, A LEAK COULD DEVELOP WHICH HAS THE POTENTIAL TO IGNITE, RESULTING IN BODILY INJURY AND/OR PROPERTY DAMAGE.
Fix: DEALERS WILL REPLACE THE BLACK PIPE AND REPLACE THE LP LINE. OWNER NOTIFICATION BEGAN AUGUST 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-6939.

Seat beltsApr 30, 2001

Front › Buckle assembly

Recall 01V1280044,370 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: CLASS A MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES BUILT BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
Risk: SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.
Fix: DEALERS WILL INSPECT THE LAP BELTS AND, IF NECESSARY, REPLACE IT WITH A NEW BELT ASSEMBLY. OWNER NOTIFICATION BEGAN MAY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AM-SAFE AT 1-219-266-8330 OR WINNEBAGO AT 1-641-585-6939.

Fuel system, otherMar 26, 2001

Delivery › Hoses, lines/piping, and fittings

Recall 01V0990001,437 vehicles

Problem: VEHICLE DESCRIPTION: MOTOR HOMES. THE COPPER LINE SUPPLYING LIQUID PROPANE GAS (LPG) TO THE FURNACE MAY HAVE BEEN IMPROPERLY CLAMPED, WHICH COULD CAUSE THE LINE TO COME IN CONTACT WITH A METAL FLANGE.
Risk: IF THIS HAPPENS, THE COPPER LINE COULD BE DAMAGED AND COULD DEVELOP A LEAK WHICH HAS THE POTENTIAL TO IGNITE.
Fix: DEALERS WILL RE-ROUTE THE LPG LINE. OWNER NOTIFICATION BEGAN APRIL 12, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-6939.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Injuries	Typical mileage*
VisibilityGlass, side/rear; Defroster/defogger/hvac system	3	1	0	—
SuspensionRear › Springs › Leaf spring assembly	2	0	0	—
Service brakes, hydraulicBrake fluid low warning › Lamp	2	1	0	—
EquipmentRecreational vehicle/trailer	2	0	1	—
Service brakes	2	0	0	—
Engine and engine cooling	1	0	0	—
Power trainDriveline	1	0	0	—
Vehicle speed controlCruise control	1	0	0	—
TiresSidewall	1	0	0	—
Structure	1	0	0	—
Fuel system, gasoline	1	0	0	—
Parking brake	1	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Service brakes
THIS MOTORHOME WAS PURCHASED NEW IN MAR OF 2001. IN APR OF THAT YEAR THE PARKING BRAKES WOULD NOT DISENGAGE. IT WAS TOWED TO A SERVICE FACILITY AND REMAINED THERE FOR SEVERAL WEEKS BECAUSE OF PARTS SHORTAGE. OVER THE YEARS THE PARKING BRAKES HAVE LOCKED EITHER WHILE THE VEHICLE WAS IN MOTION (62 MPH) OR WHILE ATTEMPTING TO PLACE IT IN MOTION: 20 APR 2005, 13 OCT 2006, 19 OCT 2006, 5 SEP 2008,2 FEB 2011. NOW THE PARKING BRAKES INTERMITTENTLY DO NOT ENGAGE: 13 MAR 2012, 5 JUN 2012, 11 DEC 2012, 11 JAN 2013, 15 MAY 2013. *TR
Apr 19, 2001 · 780 miles
Service brakes
TL* THE CONTACT OWNS A 2001 WINNEBAGO ADVENTURER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A MECHANIC FOR ROUTINE MAINTENANCE. THE MECHANIC ADVISED THE CONTACT THAT THE BRAKES WERE OVERHEATED AND CAUSING THE CALIPERS TO STICK AND BOIL THE BRAKE FLUID. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 41,000.
Jul 23, 2012 · 41,000 miles
Parking brake
TL*THE CONTACT OWNS A 2001 WINNEBAGO ADVENTURER. WHILE DRIVING BETWEEN 35-40 MPH, THE AUTO PARK BRAKE ACTIVATED ON THE P32 WORKHORSE CHASSIS. THE CONTACT PLACED THE VEHICLE INTO NEUTRAL, PUMPED THE BRAKE, AND STOPPED THE VEHICLE. HE THEN TURNED OFF THE VEHICLE AND RELEASED THE BRAKE. TWENTY FIVE MILES DOWN THE ROAD, THE AUTO PARK LOCKED UP AGAIN. THE CONTACT CALLED EMERGENCY ROADSIDE SERVICE TO DISCONNECT THE BRAKE LINE. CURRENTLY, THERE IS NO PARKING BRAKE ON THE VEHICLE. THE CURRENT MILEAGE WAS 37,500 AND FAILURE MILEAGE WAS 37,450. UPDATED 04-29-09 *BF UPDATED 04/30/09.*JB
Mar 21, 2009 · 37,450 miles
Fuel system, gasoline
I OWN A 2001 WINNEBAGO ADVENTURER MODEL 35U. IT IS ON A WORKHORSE CHASSIS. IN 2005 ONE OF THE TWO STRAPS SUPPORTING THE 75 GALLON GAS TANK BROKE. IN JULY OF 2008 THE OTHER STRAP BROKE. IN OCTOBER OF 2008 THE FIRST REPLACEMENT STRAP BROKE. I HAVE BEEN IN CONTACT WITH WORKHORSE AND THE ONLY THING THEY HAVE TO SAY IS "WE HAVE NEVER HEARD OF THIS PROBLEM". THE TANK IS ALSO FASTENED TO THE FRAME, BUT ALL THREE STRAPS BROKE IN THE SAME SPOT. IT WAS NOT DUE TO RUST. I WOULD GUESS THAT THE STRAPS ARE SUPPORTING SOME OF THE WEIGHT OF THE GAS TANK. I HAVE THE MOST RECENT BROKEN STRAP. ONE END IS GROUND DOWN DUE TO DRAGGING ON THE ROAD. WHEN THE FIRST STRAP BROKE, A MOTORIST FLAGGED ME DOWN TO LET ME…
Oct 30, 2008
VisibilityCrash
LEFT FRONT AND RIGHT FRONT DOUBLE PANED SIDE WINDOWS ARE SO FOGGED UP THAT I CANNOT SEE THE MIRRORS VERY WELL. WINDOWS MADE BY ATWOOD. *TR
Jan 10, 2008 · 7,900 miles
Visibility › Glass, side/rear
DRIVER SIDE AND PASSENGER SIDE DOUBLE PANE GLASS WINDOWS FOG UP INSIDE THE GLASS PERMANENTLY PREVENTING OPERATOR FROM VIEWING MIRRORS WHICH COULD CAUSE A SERIOUS ACCIDENT! *TR
Oct 23, 2007
Structure
I HAVE A FAILURE IN PROGRESS THAT SEEMS TO BE AFFECTING OTHER OWNERS OF WINNEBAGO MOTORHOMES AND NOT JUST MINE. DUE TO LIGHT GAUGE METALS USED IN THE STEP MOUNTING AREAS AND IMPROPER ATTACHEMENT PROCEEDURES USED DURING MANUFACTURE THE ENTRY STEP MOUNTING PLATE IS CRACKING AND THE STEP IS AT THE POINT OF FAILURE OF ITS MOUNTS. THIS FAILURE HAS BEEN NOTED ON SEVERAL OTHER WINNEBAGO\ITASCA MOTORE HOMES THAT I AM AWARE OF AND IS NOT LIMITED TO ONE UNIT BUT SEEMS TO BE A WIDE SPREAD PROBLEM. WINNEBAGO'S RESPONCE IS THAT IT IS A KNOWN FAILURE BUT THEY ARE NOT WILLING TO PUT OUT A TSB OR RECALL. THEY ARE ALSO REFUSING TO HELP WITH THE COST OF THESE REPAIRS AND ARE LEAVING THE FULL BURDEN UPON THE…
Oct 1, 2006
Tires › Sidewall
WE GOT OUR 3RD. BLOW OUT IN LESS THEN 1 YR. ON GOODYEAR TIRES. FIRST TIME AUG.04 SECOND TIME FEB.05 3RD.TIME JULY 05. 1ST. & 2ND. TIME DAMAGE TO THE MOTORHOME COMBINED ABOUT $7-$8,000.00 WORTH OF DAMAGE. FINALLY GOODYEAR REPLACED ALL 7 TIRES 4/30/05. FIRST TIME OUT FOR 4TH OF JULY WEEKEND WE GOT ANOTHER BLOW OUT. THERE WAS ABOUT 450 MILES ON THE NEW SET OF TIRES. THE TIRE SPLIT ON THE SIDE OF THE INSIDE REAR PASSANGERS SIDE. CALLED AAA AND THEY SENT SOMEONE OUT TO CHANGE TIRE HE SAID IT BLOW FROM HAVING TO MUCH AIR IN TIRE. THEY SPARE HAD 110 LBS. AND THE REQUIRED AMOUNT IS 70 LBS. HE LET OUT AIR AND PUT ON. WE THEN TOOK BLOWN OUT TIRE TO MOUNTAIN VEIW TIRE WHERE THYE WHERE PUT ON. ROBERT…
Jul 5, 2005 · 27,450 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.