*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Latches/locks/linkages
The contact owns a 2023 Winnebago Ekko RV built on a 2023 Ford Transit chassis. The contact stated that the front passenger door failed to remain locked. The dealer was contacted and replaced the door actuator; however, the failure recurred. The contact expressed concern the vehicle was hacked. The manufacturer was notified of the problem. The failure mileage was 75,000.
Aug 2, 2026 · 75,000 milesUnknown or other
After starting the vehicle I noticed an unusual whine. After a few seconds of idling I noticed that it smelled like something was on fire. I turned off the vehicle and began looking for smoke. I did not find it. After a little research I discovered that it is a very well known failure that the Balmar alternator on Winnebago EKKOs fails catastrophically, sometimes catching on fire. I followed instructions to disable the Balmar. I let the vehicle cool completely. I restarted the vehicle and let it idle for a long while and the whine and the smell never returned. I used the Lithionics app to confirm that the batteries were not being charged while the engine was idling.
Jul 8, 2026Electrical systemFire
We had reported on Sat, 3/21/26 to Winnebago that we noticed our Balmar alternator had stopped charging the battery the night before on Fri, 3/20/26 during a 2.5 hour trip to Sebastapol, CA. We drove to Santa Clara, recharged batteries with shore power and then drove to Santa Cruz, CA. This morning on Sun 3/22/26, our 2nd Balmar Alternator installed by NIRVC/Las Vegas in Mar-April 2024 under the 174 Recall caught on fire. Fortunately, we were idling in a parking lot before getting on the freeway, and could hear the whining noise, smell the burning alternator, and see the smoke coming out of the engine before the fire grew too large. We were able to extinguish the fire and keep the damage…
Mar 22, 2026Electrical system
Balmar alternator began smoking and emitting a burning smell, also began discharging the house batteries. This condition caused us to be disabled along the roadway and entailed crawling under the vehicle to disconnect the wiring from the alternator. Unable to get immediately repaired as no Balmar replacement parts were available from Winnebago. Repairs completed December 2024 by dealer. Additional Service Campaign 75-09 on Balmar alternators May 20, 2025 to cut charging rate by approximately 50% to prevent overloading. This service also completed by dealer August 18, 2025
Sep 23, 2024Electrical system
Reference NHTSA Safety Recall 23V-234 Just experience failure of second Balmar alternator at about 26,000 miles. Replacement of first failure was done in conjunction of above referenced safefy recall. Work was performed in March of 2024. Subsequent to the above referenced recall Winnebago issued a Service Campaign (75-09) to derate (adjust/lower alternator output settings)in order to reduce the risk of overloading the alternator. The service campaign work was completed in June 2025. Numerous other Ekko owners have experience multiple Balmar alternator failures including some that have caught on fire. I was aware of the early warning signs of problems (high pitched whine that varies with…
Nov 1, 2025Electrical system › Alternator/generator/regulator
There is a Balmar alternator installed on my Winnebago EKKOs that failed by smoking and burning. Winnebago replaced it with the same piece of equipment and it too has failed. They will again replace with another Balmar putting me at risk of fire and failure. This is totally unacceptable! Please help all us EKKO owners force Winnebago to solve this with a safe solution. Some owners have had 6 Balmars replaced! This is a known problem that is not being resolved.
Oct 23, 2025Electrical system
The winnebago EKKO has a secondardy alternator (Balmer brand) that charges the coach Lithium battery. There is an existing Winnebago recall regarding this component , Winnebago #174 and I originally had the Balmer alternator fail in summer 2023 and it was repaired by Winnebago under the #174 recall. The Balmer alternator has now failed again as of January 2025, and is appearing to heat beyond normal. The symptom of this failure, is lack of charging of the battery during engine operation, as well as tripping of the main coach power breaker. I have disconnected the alternator to prevent any safety issues such as over heating. Others will same vehicle have reported safety issues such as…
Jan 6, 2025Tires › Tread/belt
Hankook Dynapro HT 205/75R16C We found out when we were having the oil changed. Both front tires have steel fibers showing on 14,882 miles. Lucky we weren't on the highway. I would never have guessed that 1.5 year old tires would be this worn. Properly inflated, by the way.
Feb 1, 2025
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.