Model year record

2002 BMW E46 recalls & problems

The 2002 BMW E46 has 2 safety recalls and 2 owner complaints on file with NHTSA. The most-reported problem area is visibility (1 complaint).

Recalls2safety recalls

Complaints2filed by owners

Crashes · fires0 · 0reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

Exterior lightingMay 11, 2009

Headlights

Recall 09E02500042,540 vehiclesopened after NHTSA action (OVSC)

Problem: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Fix: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Exterior lightingMay 15, 2006

Exterior lighting

Recall 06E0400001,648 vehiclesopened after NHTSA action (OVSC)

Problem: CERTAIN E SPEED RACING COMBINATION LAMPS SOLD AS REPLACEMENT EQUIPMENT FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Fix: E SPEED RACING WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN MAY 10, 2006. OWNERS MAY CONTACT E SPEED RACING 909-923-3636.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
VisibilityRearview mirrors/devices	1	0	0	0	—
Electrical system	1	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Electrical system
LOOK AT THIS - ANOTHER BMW RECALL IS IN ORDER MY BATTERY KEEPS GETTING FLOODED WITH WATER AND THEN THE CAR WON'T START UNDER SNOW THE ICE MELTS AND SOMEHOW GETTING INTO THE COMPARTMENT WITH THE BATTERY IN THE BOOT NOTHING ELSE IN THE BOOT IS WET - NOT EVEN ON THE PLASTIC PLATE THAT COVERS THE BATTERY BUT IT GETS INTO THE BATTERY COMPARTMENT AND THERE IS NO DRAIN FOR THE WATER TO GO SO MY CAR FAILS TO START MANY MANY COMPLAINTS ON THIS ONE WEBSITE IS THIS ALSO CHECK ON BIMMERFEST - TOO MANY PEOPLE HAVING THIS DANGEROUS CONDITION AND COMPLAINING TO BMW WHICH WON'T DO THE RECALL YOU NEED TO FORCE THEM TO DO THE RECALL HTTP://WWW.E90POST.COM/FORUMS/SHOWTHREAD.PHP?T=949111 THEY SHOULD BE FIXING…
Mar 11, 2015 · 45,000 miles
Visibility › Rearview mirrors/devices
THE REARVIEW MIRROR LEAKED AND IT IS BLURRY NOW IN MY 2002 BMW M3. I DID SOME RESEARCH AND IT HAS BEEN A COMMON PROBLEM FOR A LOT OF BMW'S. DEALER WON'T REPLACE AS THE CAR IS OUT OF WARRANTY. MIRROR IS OBVIOUSLY A SAFETY ITEM AND OBVIOUSLY DEFECTIVE. *TR
Dec 30, 2008 · 25,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Rear Lamp IlluminationClosedLed to recall 11V438000
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in…
EA09019 · opened Dec 18, 2009 · closed Sep 28, 2011
REAR LAMP ILLUMINATIONClosedLed to recall 11V438000
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
PE09036 · opened Aug 7, 2009 · closed Dec 22, 2009
REAR LAMP ILLUMINATIONClosed
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A…
DP09002 · opened Apr 8, 2009 · closed Aug 6, 2009