*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
EngineFire
I am reporting a vehicle fire involving my 2008 BMW X3, which had an active safety recall for the Positive Crankcase Ventilation (PCV) valve heater (Recall Campaign No. 22V-119). This recall identifies a risk of short circuiting, overheating, and potential fire. On February 27, 2026, I contacted BMW after discovering multiple active recalls on my vehicle. I specifically asked whether the vehicle was safe to drive. After consulting internally, I was advised that I did not need a tow and that the vehicle was safe to drive. Based on this guidance, I scheduled a repair appointment for March 24, 2026. On March 14, 2026, before starting the vehicle, I noticed a very faint smell of burning…
Mar 14, 2026Electrical system › Seat heater › Wiring harness
The contact owns a 2008 BMW X3. The contact stated while driving approximately 20 MPH with the front driver's seat heater activated, the contact felt a sharp pain on the buttock and immediately leaned forward. The contact stated that upon touching the seat, the contact noticed that the seat heater had burned the seat through the seat leather cover. There was no warning light illuminated. The contact was able to pull to the side of the road immediately, and the contact turned off the seat heater. The contact noticed that the seat burn hole was the size of a cigarette hole, and there was a burn mark on the contact's pants. The contact stated that the burning sensation he had sustained did not…
Dec 25, 2024 · 130,000 milesTires
The contact owns a 2008 BMW X3 equipped with Arroyo Tires, Tire Line: Grand Sport A/S, Tire Size: 254/40/R19, DOT Number: 1TBY3KB5C. The contact stated while driving at an undisclosed speed, the contact noticed that the tread of the tires became inoperable. The contact stated that the vehicle became difficult to control. The contact parked the vehicle and inspected all the tires and the contact noticed that the inside of all the tires tread had separated. The vehicle was taken to an independent where it was diagnosed that the tires failed due to the tires being delaminated, and the tires needed to be replaced. The tires were replaced. The manufacturer was notified of the failure. The tire…
Oct 28, 2024 · 325,000 milesAir bags
The contact owns a 2008 BMW X3. The contact stated while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the front passengerâs side seat occupant detection mat. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 17V605000 (Air Bags), but the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 142,000.
Jul 29, 2024 · 142,000 milesEngine
The car no longer starts. When towing it to a BMW dealership, they informed me that there is a problem with the VANOS bolts and that "they snap easily"; however after some research into it I realized that these engines have a recall for this specific issue only that my vehicle isn't listed under the recall. I believe this is a mistake and that it should be.
Mar 12, 2024Engine and engine cooling
The contact owns a 2008 BMW X3. The contact stated that while driving at 20 MPH in cold weather, there was smoke coming from the engine compartment. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted; however, the contact received no response. The contact stated that the failure was related to NHTSA Campaign Number: 22V119000 (Engine and Engine); the VIN was included. The failure mileage was approximately 200,000.
Oct 1, 2023 · 200,000 milesElectrical system
The wiring insulation inside of the headlight on my vehicle deteriorated, causing the wires to be exposed. The headlight stopped working because of the wires touching, and a defective lamp dash light came on. Exposed wires touching has the potential to start fires. I have completely re wrapped all of the wiring inside of the headlights with heat shrink so I no longer have the problem, although the problem first appeared after I tried replacing the light bulb
Oct 2, 2023Air bags
The steering angle sensor has faulted, at around 60,000 miles. This fault results in possible airbag failure, in conjunction with inability to perform safety breaking mechanisms, as well as disabling the cars 4x4 stability control features. BMW as well as other BMW third-party mechanics have told me this is a reoccurring problem and could pose a serious danger if in an accident. BMW officially told me to put a complaint in so that a recall could be performed. I will not pay 2000 for my airbags to work, as it is a feature required by law to operate properly. I will upload all necessary documentation if needed, should this complaint be taken into consideration.
Jul 7, 2019
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.