Model year record

1994 Chevrolet Corvette recalls & problems

The 1994 Chevrolet Corvette has 1 safety recall and 29 owner complaints on file with NHTSA. The most-reported problem area is service brakes, hydraulic (5 complaints).

Recalls1safety recalls

Complaints29filed by owners

Crashes · fires1 · 1reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

Fuel system, gasolineMay 19, 2006

Fuel system, gasoline

Recall 06E04300088,303 vehicles

Problem: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Risk: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Fix: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

Corvette

18mpg combined

City / highway	15 / 23 mpg
Fuel	Premium Gasoline

5.7 L · 8 cyl · Manual 6-spd · Rear-Wheel Drive · about $4,550/year to fuel

Corvette

18mpg combined

City / highway	15 / 22 mpg
Fuel	Premium Gasoline

5.7 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,550/year to fuel

Corvette

18mpg combined

City / highway	15 / 24 mpg
Fuel	Premium Gasoline

5.7 L · 8 cyl · Manual 6-spd · Rear-Wheel Drive · about $4,550/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Typical mileage*
Service brakes, hydraulicFoundation components › Disc; Foundation components › Disc › Caliper	5	0	0	—
Electrical systemIgnition; Wiring	5	0	0	—
Air bagsFrontal; Frontal › Sensor/control module	4	2	0	—
Power trainAutomatic transmission	4	0	1	—
StructureFrame and members; Body › Roof and pillars	3	0	0	—
Wheels	3	1	0	—
Engine	3	0	0	—
VisibilityGlass, side/rear; Windshield wiper/washer	2	0	0	—
Vehicle speed controlLinkages; Cruise control	2	0	0	—
Unknown or other	1	0	0	—
Tires	1	0	0	—
Latches/locks/linkagesHood › Latch	1	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Service brakes
The contact owns a 1994 Chevrolet Corvette. The contact stated while driving at various speeds and depressing the brake pedal, the vehicle was shaking with the brake pads abnormally grabbing. The contact stated that he had to lightly depress the brake pedal to prevent the vehicle from shaking and the brake pads grabbing. The contact stated no warning light was illuminated. Additionally, the contact stated that the power locks would unlock and lock unintendedly. The contact also stated that the interior lights would turn off and on independently. The contact stated that the failures had become constant. The contact had taken the vehicle to an independent mechanic who was unable to determine…
Sep 21, 2019 · 77,000 miles
Fuel/propulsion system
FUEL ODER FROM REAR OF THE VEHICLE
Jun 11, 2016 · 94,000 miles
Electrical system
AT 19,528 MILEAGE. MY TIRES NEED TO BE REPLACED,SIDE WALLS WHERE CRACKED, NO SAFE TO DRIVE IN MOTION. REPLACE BACK UP LAMP SWITCH INTERNAL SHORTED,PART NO LONGER AVAILABLE THRU GM. LIGHTING SYSTEMS FOR VEHICLE MOTION INTENT ,IN MOTION IN CITY AND HIGHWAY. AT 23,353 MILEAGE. FOUND # 5 CYLINDER IS MISFIRING AND THE SPARK PLUG IS FOULED. FOUND NO SPARK ON THAT CYLINDER ALSO. FOUND THE ABITS DISTRIBUTOR MODULE IS FAULTY .NEED TO REPLACE THE ABITS. REPLACED THE ABITS DISTRIBUTOR. SPARK PLUGS AND WIRES,IN MOTION IN CITY AND HIGHWAY. THEN AGAIN AT 27,011MILAGE. REPLACE SERPENTINE BELT. REPLACE HUB ASSEMBLY RF ,FRONT WHEEL BEARINGS. REPLACE BROKEN R+R ROCKER ARM STUD,IN MOTION IN CITY AND HIGHWAY.…
Sep 28, 2010
Electrical system
THE CHEVROLET LT1 5.7 LITER ENGINE HAS A DEFECT WITH THE WATER PUMP. IT IS A CAM SHAFT DRIVEN WATER PUMP AND LEAKS ANTIFREEZE ONTO THE OPTISPARK(AKA DISTRIBUTOR) WHICH SHORTS OUT THE OPTISPARK. IF THE CAR IS DRIVING IT WILL NO LONGER RUN. THIS ALSO DISABLE POWER STEERING. THIS DEFECT WAS ACKNOWLEDGED AND FIXED IN 1995 AND NEWER MODELS BUT THE PREVIOUS YEAR MODELS HAVE THIS PROBLEM. THIS IS A SAFETY ISSUE AS A MOVING CAR CAN BE DISABLED WHILE DRIVING. THIS THE EXACT SAME RESULT AS THE GM IGNITION KEY RECALL AND IT SHOULD NOT BE IGNORED. *TR
Jun 3, 2007 · 8,000 miles
Engine
TL* THE CONTACT OWNS A 1994 CHEVROLET CORVETTE. THE CONTACT STATED WHILE TRAVELING AT UNKNOWN SPEEDS, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC SEVERAL TIMES WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE.
Apr 1, 1998
Power train › Automatic transmissionFire
TL*THE CONTACT OWNS A 1994 CHEVROLET CORVETTE. WHILE DRIVING 40 MPH, THE CONTACT NOTICED SMOKE UNDERNEATH THE HOOD. THE VEHICLE WOULD NO LONGER ACCELERATE AND WAS TAKEN TO A LOCAL REPAIR SHOP. THE MECHANIC STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE CONTACT DID NOT NOTICE ANY ISSUES BEFORE THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 134,000.
Jan 14, 2006 · 134,000 miles
Vehicle speed control › Cruise control
CRUISE CONTROL WILL NOT DISENGAGE AND ACTUALLY ACCELERATES ON MY 1994 CORVETTE. TO BRAKE THE CAR, THE ENGINE HAS TO BE SHUT OFF WHILE THE CAR IS MOVING IN EXCESS OF 85 MPH. THIS FIRST HAPPENED IN JANUARY 1999. I TOOK THE CAR TO TWO CHEVROLET DEALERSHIPS, ONE IN FLORIDA THE OTHER KELLE CHEVROLET, FARMINGDALE, NJ 07727, AND WAS TOLD THERE WAS NO PROBLEM WITH THE CRUSIE CONTROL. I HAVE NOT USED THE CRUSIE SINCE THEN FOR FEAR THAT THE SAME THING WOULD HAPPEN. I LENT THE CAR TO MY COUSIN IN MAY OF 2007, AND NOT KNOWING THAT THERE COULD BE A PROBLEM, HE USED THE CRUISE AND ONCE AGAIN IT WOULD NOT DISENGAGE AND THE CAR CONTINUED TO ACCELERATE. I CONTACTED GENERAL MOTORS, CASE NUMBER, 71-526476194,…
May 26, 2007 · 38,610 miles
Air bags
DT*: THE CONTACT STATED WHILE DRIVING 42 MPH THE ENTIRE AIR BAG CAME OFF, BUT DID NOT DEPLOY. IT REQUIRES 4 SCREWS TO HOLD IT ON, BUT THE CONTACT ONLY FOUND 2 SCREWS. ATTEMPTED TO PUT THEM IN BUT ONLY ONE SEEMED TO TAKE, AND EVEN THAT ONE WAS NOT TIGHT. THE DEALER WOULD NOT HELP. THIS REPRESENTED A SAFETY CONCERN. HOWEVER, THIS VEHICLE HAS NEVER BEEN IN AN ACCIDENT. UPDATED 05/30/06. *AK
May 11, 2006 · 95,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

BRAKE PULLClosed
THE PETITIONS STATED THAT:WE REPRESENT THE OWNER OF A 1990 CHEVROLET CORVETTE WHICH, WHEN THE BRAKES WERE APPLIED, SUDDENTLY, VIOLENTLY, AND UNEXPECTEDLY PULLS TO THE LEFT.THIS IS A INTERMITTENT DEFECT WHICH DOES NOT OCCUR WITH AN REGULARITY.
DP96006 · opened May 14, 1996 · closed Oct 18, 1996
ENGINE WIRING HARNESS ROUTINGClosed
THIS CONDITION POSES NO SAFETY-RELATED CONSEQUENCE IF THE IDENTIFIED WIRING HARNESS WERE TO CONTACT THE EXHAUST SHIELD.ONLY ONE MONTH OF PRODUCTION WAS INVOLVED IN THIS CAMPAIGN.THE SUBJECT WIRING HARNESS CONTAINS THE GROUND WIRES FOR THE ENGINE OIL TEMPERATURE SENSOR, O2 SENSOR, KNOCK SENSOR, AND THE OIL LEVEL SENSOR.ALL SENSORS INVOLVED OPERATE AT A VERY LOW VOLTAGE (LESS THAN 1 V).THE ONLY REPORTED ADVERSE EFFECT IF THE HARNESS WERE TO CONTACT THE EXHAUSE SHIELD, WOULD BE THE ILLUMINATION OF THE CHECK ENGINE LIGHT OR ERRATIC DASH GAUGE MOVEMENT.THIS SQ IS CLOSED.
SQ94015 · opened Mar 11, 1994 · closed Mar 21, 1994