Model year record

1997 Chevrolet Lumina recalls & problems

The 1997 Chevrolet Lumina has 2 safety recalls and 347 owner complaints on file with NHTSA. The most-reported problem area is steering (90 complaints).

Recalls2safety recalls

Complaints347filed by owners

Crashes · fires34 · 8reported in complaints

Injuries · deaths28 · 7reported in complaints

1997 Chevrolet Lumina in an NHTSA crash test — NHTSA crash test

Safety recalls

Fuel system, otherMar 12, 2007

Storage › Tank assembly › Pressure relief devices

Recall 07E021000742 vehicles

Problem: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Risk: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Fix: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

SteeringDec 11, 2003

Rack and pinion

Recall 03V527000750,283 vehiclesopened after NHTSA action (ODI)

Problem: CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Risk: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Fix: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

1997 Chevrolet Lumina 4-DR.

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
SteeringRack and pinion; Hydraulic power assist system	90	9	1	4	92,000 mi
Engine and engine coolingEngine › Gasoline; Engine	56	0	1	1	76,408 mi
Fuel system, gasolineStorage › Tank assembly; Delivery › Fuel pump	44	1	3	0	55,490 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components	38	4	0	2	—
Air bagsFrontal; Side/window	38	23	0	16	131,975 mi
Electrical systemAlternator/generator/regulator; Horn	28	1	2	1	65,245 mi
Power trainAutomatic transmission; Driveline › Differential unit	21	0	0	0	—
VisibilityWindshield wiper/washer › Motor; Windshield wiper/washer	20	0	0	0	51,147 mi
Exterior lightingHeadlights; Brake lights › Switch	17	0	2	0	66,826 mi
StructureBody; Frame and members	14	1	0	1	55,000 mi
Vehicle speed controlAccelerator pedal; Linkages	11	2	0	6	—
Unknown or other	11	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Electronic stability control (esc)Fire
I'M DRIVING AND MY STEERING IS TIGHT AND WHEN TURNING WHILE IN MOTION AND WHILE ITS PARK. YOU CAN ALSO SMELL LIKE SOME THING BURNING
Nov 11, 2019 · 189,632 miles
Air bags
DASHBOARD COVER ON PASSENGER SIDE AIRBAG HAS DETACHED/PULLED AWAY AND BUCKLED UP FROM THE FOAM AIR BAG CASING. GM/CHEVROLET WAS NOTIFIED OF THE PROBLEM VIA PHONE. THE RESPONSE GIVEN BY GM/CHEVROLET REPRESENTATIVE WAS THAT THE CAR WAS TOO OLD TO WARRANT THEIR ATTENTION/REPAIR. THIS DOES NOT ANSWER THE QUESTION, IF THE AIR BAG WILL DEPLOY PROPERLY. THE CHEVROLET DEALERSHIP STATED THAT THEY WOULD REPLACE AND PAINT IT AT COST AND04/16/2012 LABOR PAID BY CUSTOMER. AUTO INSURANCE HAS REFERRED THE PROBLEM TO THE MANUFACTURER. THIS PROBLEM HAS BEEN PROGRESSIVE IN NATURE, BEGINNING APPROXIMATELY 4 YEARS AGO.
Apr 16, 2012
Steering
KEY STUCK IN ON POSITION WILL NOT ALLOW ENGINE TO BE TURNED OFF IN EITHER PARK OR NEUTRAL. WILL TURN TOWARDS START. CAR WILL DRIVE BUT UNABLE TO TURN CAR OFF UNLESS POWER IS UNPLUGGED FROM STEERING COLUMN. WAS AT WORK WITH NO WAY TO TURN CAR OFF HAD TO LEAVE RUNNING TILL POWER WAS DISCONNECTED. UPON RESEARCH FOUND THAT THIS WAS A COMMON ISSUE REPORTED FOR THE 97-98 CHEVY LUMINA BELIEVE THAT THIS SHOULD BE A SAFETY RECALL
Aug 2, 2016
Air bagsCrash
MY SON WAS IN A BAD ACCIDENT THAT TOTALED THE CAR AND THE AIR BAGS DID NOT DEPLOY.
May 18, 2016 · 165,000 miles
Structure › BodyCrash
WHILE DRIVING HOME ONE DAY ANOTHER DRIVER HIT THE SIDE OF THE CAR CLOSE TO THE HEADLIGHT ON THE DRIVER SIDE THIS HIT CAUSED ME TO NO LONGER BE ABLE TO DRIVE THE VEHICLE. THE AIRBAGS IN THE VEHICLE DID NOT DEPLOY.
Jul 24, 2014
Steering › Rack and pinion
TL* THE CONTACT OWNS A 1997 CHEVROLET LUMINA. WHILE DRIVING 35 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE RACK AND PINION NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 228,890.
Sep 15, 2014 · 228,890 miles
Air bagsCrash1 injury
LOST CONTROL OF THE VEHICLE DRIVING HOME. CRASHED. POLICE REPORT IS IDENTICAL TO STEERING RECALL. WHICH NEVER WAS REPAIRED. THE VIN NUMBER I HAVE AT HOME. NEITHER AIRBAG DEPLOYED EVEN THOUGH I SMASHED INTO A CULVERT. *TR
Jul 19, 2013
Air bags1 injury
I WAS DRIVING HOME VEERED OFF THE LEFT SIDE OF THE ROAD LOST CONTROL THE POWER STEERING WENT OUT SPUN IN CIRCLES UNTIL FINALLY HITTING A CONCRETE CULVERT NEITHER AIRBAG DEPLOYED. I BROKE 4 VERTEBRAES 7 RIBS AND RECEIVED A TRAUMATIC BRAIN INJURY. COULDN'T EVEN RECALL MY PARENTS FOE MONTHS OR EVEN THEY LIVED TOGETHER . LAID IN THE CAR TIL PARAMEDIC FOUND ME ABOUT AN HOR LATER. THE AIRBAG WAS DESIGNED TO PREVENT HEAD INJURY. THE 1997 CHEVY LUMINA FAILED HORRIBLY. PLUS TENDAYS IN A COMA LOST A $50 K YR JOB AND SENT TO A NURSING HOME TO SPEND MY 33RD,THANKSGND CHRISTMAS IN UNTIL I WAS RELEASED FROM GUARDIANSHIP. 12/30/13 PLEASE HELP! HOW IS THE 1997 MALIBU DIFFERENT THAN ALL THE LUMINAS RECALLS?…
Jul 19, 2013

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

POWER RACK AND PINION STEERING FAILUREClosedLed to recall 03V527000
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER…
EA03019 · opened Sep 15, 2003 · closed Dec 18, 2003
POWER RACK AND PINION STEERING FAILUREClosed
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED…
RQ03001 · opened Jan 2, 2003 · closed Sep 15, 2003