Model year record

1999 Chevrolet Lumina recalls & problems

The 1999 Chevrolet Lumina has 3 safety recalls and 103 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (43 complaints).

Recalls3safety recalls

Complaints103filed by owners

Crashes · fires10 · 4reported in complaints

Injuries · deaths13 · 1reported in complaints

Safety recalls

Engine and engine coolingOct 26, 2015

Exhaust system › Manifold/header/muffler/tail pipe

Recall 15V7010001,003,556 vehicles

Problem: General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Risk: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Fix: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engineÂs front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Components: Engine and engine cooling › Exhaust system › Manifold/header/muffler/tail pipe; Engine and engine cooling › Engine

Engine and engine coolingApr 8, 2009

Engine and engine cooling

Recall 09V1160001,497,516 vehiclesopened after NHTSA action (ODI)

Problem: GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Risk: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Fix: DEALERS WILL REPLACE THE ENGINEÂS FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINEÂS PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.

Fuel system, otherMar 12, 2007

Storage › Tank assembly › Pressure relief devices

Recall 07E021000742 vehicles

Problem: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Risk: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Fix: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

1999 Chevrolet Lumina 4-DR.

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Engine and engine coolingExhaust system › Manifold/header/muffler/tail pipe; Cooling system	43	1	2	0	63,200 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components	19	2	0	0	7,000 mi
Electrical systemAlternator/generator/regulator; Wiring	8	0	1	1	111,000 mi
Power trainAutomatic transmission; Axle assembly › Axle shaft	7	0	0	0	85,500 mi
Air bagsFrontal	7	2	0	7	—
SteeringSteering wheel/handle bar; Hydraulic power assist system	7	1	0	1	79,528 mi
Vehicle speed controlAccelerator pedal	5	4	0	0	—
VisibilityWindshield wiper/washer › Motor; Windshield	5	0	0	1	—
TiresTread/belt	4	0	0	0	—
EquipmentAppliance › Air conditioner	4	0	0	0	—
Exterior lightingBrake lights; Turn signal › Switch	4	0	0	0	—
Engine	4	0	0	0	123,500 mi

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Engine
I WAS DRIVING THE CAR HOME AND IT SHUT OFF , NOW IT WON'T TURN BACK ON
Aug 6, 2019 · 13,600 miles
Electrical system
1999 CHEVROLET LUMINA LS. CONSUMER WRITES IN REGARDS TO VEHICLE SHUTTING OFF WHILE DRIVING. *LD THE CONSUMER STATED THE PASS-KEY 11 SECURITY SYSTEM ACTIVATED WHILE DRIVING CAUSING THE VEHICLE TO LOSE STEERING AND BRAKING FUNCTIONS WHILE BEING DRIVEN. *JS
Nov 13, 2018
Steering
MY STEERING WHEEL HAS BEEN LOCKING UP WHILE DRIVING AND I HAVE ALMOST CRASHED INTO OTHER VEHICLES AND BUILDINGS.
Oct 8, 2017 · 5 miles
Structure › BodyFire
I TOOK MY CAR FOR A SERVICE REPAIR. (TUNE UP) ONLY TO DISCOVER ON THE WAYA AWKWARD SMELL AND MISFIRE. UPON ARRIVING I WAS NOTIFIED THAT THE INTERNAL HOOD INSULATION BROKE FREE AND CRUMBLED IN CHUNKS ON TOP OF MY FUEL INJECTOR AND CREATED A HEAT THAT MELTED FOUR OF THE FUEL INJECTOR WIRES COVERS AND ALL.
Apr 4, 2017 · 15 miles
Engine and engine cooling
TL* THE CONTACT OWNS A 1999 CHEVROLET LUMINA. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING OIL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE VALVE COVER GASKET FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000. UPDATED 08/16/16*LJ UPDATED 08/17/16 *JB
Jun 12, 2015 · 102,000 miles
Engine
TL* THE CONTACT OWNS A 1999 CHEVROLET LUMINA. THE CONTACT STATED THAT THE VEHICLE WAS NO LONGER OPERABLE. THE VEHICLE WAS INSPECTED BY A TECHNICIAN WHERE IT WAS DIAGNOSED THAT THE FAILURE WAS DUE TO THE HEAD GASKETS LEAKING WATER INTO THE PISTONS. THE HEAD GASKETS NEEDED TO BE REPLACED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 116,000. PARTS DISTRIBUTION DISCONNECT.
Feb 26, 2015 · 116,000 miles
Tires
DRIVING AT 70MPH THERE WAS A THERE WAS A LARGE INCREASE IN NOISE AND VIBRATION FOR A MINUTE FOLLOWED BY A LOUD BANG. INSPECTION REVEALED THAT AN EXPLOSIVE TIRE FAILURE HAD OCCURRED. SEVERAL PLACES ON THE SIDEWALL WERE TORN AND THE TREAD HAD BULGES ON IT. THE DEFECTIVE TIRE WAS REPLACED. 2 MONTHS LATER THE SAME BRAND AND MODEL TIRE ON THE OTHER SIDE OF THE CAR STARTED TO RUMBLE - FORTUNATELY AT ONLY 45 MPH IN TOWN. INSPECTION REVEALED THAT THERE WAS A BULGE ON THE TREAD SO THE TIRE WAS REPLACED. SINCE 2 PRIMEWELL TIRES ON THE SAME AXLE FAILED WITHIN 2 MONTHS OF EACH OTHER, I BELIEVE THIS IS MANUFACTURERS DEFECT - NOT JUST A SIMPLE COINCIDENCE.
Dec 15, 2015 · 25,000 miles
Engine
TL* THE CONTACT OWNS A 1999 CHEVROLET LUMINA. THE CONTACT STATED THAT OIL WAS LEAKING ON THE EXHAUST MANIFOLD AND A BURNING ODOR WAS PRESENT. THE CONTACT RECEIVED NOTIFICATION OF NHSTA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 131,000. PARTS DISTRIBUTION DISCONNECT.
Dec 8, 2015 · 131,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

ENGINE COMPARTMENT FIRESClosedLed to recall 04V090000
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA02030 · opened Oct 22, 2002 · closed Mar 9, 2004