1997 Chevrolet Monte Carlo recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Steering

  TL* THE CONTACT OWNS A 1997 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING 85 MPH, THE STEERING WHEEL BECAME LOOSE AND CAUSED THE CONTACT TO TEMPORARILY LOSE CONTROL OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN ADVISED THAT THE LOWER PINION BEARING FOR THE STEERING RACK NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 03V527000 (STEERING:RACK AND PINION) HOWEVER, THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 220,000.

  Dec 1, 2012 · 220,000 miles
• Engine and engine cooling

  MY 97 MONTE CARLO Z34 STARTED DYING ON ME WHENEVER I CAME TO A COMPLETE STOP AND AFTER I HAD BEEN DRIVING IT FOR A WHILE. AND IT WOULD SHOOT FORWARD AFTER I STARTED IT AGAIN IN NEUTRAL(THE ONLY WAY IT WOULD START). PLACING MYSELF IN THE MIDDLE OF INTERSECTIONS UNWILLINGLY, I WOULD HAVE TO START MY CAR AND MAKE SURE NO CARS WERE COMING ANY WAY OR ELSE I WOULD HAVE CRASHED! NOW MY CAR IS COMPLETELY UNDRIVABLE AND DIES WHENEVER I HIT MY BRAKES, I TOOK THE CAR TO SEVERAL MECHANICS SINCE THIS STARTED AND HAVE HAD THE FOLLOWING CHANGED/REPAIRED: UPPER AND LOWER INTAKE GASKET SET, THROTTLE BODY GASKET, THERMOSTAT, SPARK PLUGS AND WIRES, AIR FILTER, NUMEROUS VACUUM LEAKS, VALVE COVERS. *TR

  Jul 20, 2009
• Engine and engine cooling › Cooling system

  MY 1997 CHEVROLET MONTE CARLO WAS RECENTLY DIAGNOSED WITH AN INTAKE MANIFOLD GASKET THAT NEEDS TO BE REPLACED (DUE TO LEAKING OF ENGINE COOLANT). TWO MECHANICS INFORMED ME THE REPAIR COSTS WOULD BE BETWEEN $800-$1000. AFTER FURTHER RESEARCH, I DISCOVERED SEVERAL GENERAL MOTORS VEHICLES BETWEEN 1996-2002 HAD THIS SAME PROBLEM. THOUGH NO OFFICIAL RECALL WAS DONE, GM DID PUBLISH A TECHNICAL SERVICE BULLETIN REGARDING THIS PROBLEM A FEW YEARS AGO. I KNOW CANADA HAS FILED CLASS ACTION SUITS AGAINST CANADA GM CONCERNING THIS ISSUE. THE CAR ONLY HAS 120K MILES ON IT, AND THE BLUEBOOK STATES THE VALUE TO BE AROUND $2200. DOES THE STATE OF MARYLAND HAVE INFORMATION ON THIS ISSUE REQUIRING GM TO…

  May 23, 2008 · 119,000 miles
• Electrical system › Wiring › Interior/under dash

  MY 97 CHEVY MONTE CARLO HAS HAD NO LOWER BRAKE LIGHTS FOR SOME TIME . I HAD MY CAR CHECKED BY AN AUTO ELECTRICIAN AND WAS TOLD THAT THE PROBLEM WAS SO SEVERE AND IT WOULD PROBABLY NEVER FIND THE SOURCE OF THE PROBLEM. I AM VERY CONCERNED WITH THIS ISSUE BEING IT MAY CAUSE SERIOUS INJURY TO MY SELF/FAMILY OR OTHERS. AS I DRIVE ON THE ROAD I NOTICE MANY AUTOS OF THE SAME YEAR AND TYPE HAVE THE SAME PROBLEM SO I KNOW ITS NOT ONLY MY VEHICLE .I THOUGHT IT COULD OF BEEN THE FACTORY INSTALLED SECURITY SYSTEM SO I HAD IT UNINSTALLED TO COME TO THE FACT THAT IT WAS NOT THE SECURITY SYSTEM AFTER ALL. PLEASE HELP WITH THIS ISSUE . THIS IS MY ONLY SOURCE OF TRANSPORTATION AS I AM DISABLED AND CANNOT…

  May 10, 2007
• Engine and engine cooling › Engine

  TL*THE CONTACT OWNS A 1997 CHEVROLET MONTE CARLO. WHILE DRIVING 5 MPH, THE ENGINE FELL OUT OF THE VEHICLE. THE MECHANIC STATED THAT THE FAILURE WAS CAUSED BY THE SUB FRAME BOLTS NOT BEING TIGHTENED. THE BOLTS WERE RE-ATTACHED. AS OF AUGUST 14, 2007, NO OTHER FAILURES HAVE OCCURRED. THE CURRENT AND FAILURE MILEAGES WERE 145,000.

  Apr 1, 2007 · 145,000 miles
• Electrical system › Wiring › Interior/under dashFire

  THIS IS MY SECOND GM VEHICLE WITH THE SAME MALFUNCTION. FIRST, THE WINDSHIELD WIPERS WOULD NOT TURN ON. THEN THE RIGHT BLINKER WOULD NOT WORK (STAYS SOLID, DOESN'T FLASH). THEN THERE WAS A SMALL FIRE ACCOMPANIED BY A LOT OF SMOKE COMING FROM THE STEERING COLUMN. THIS IS A 1997 CHEVY MONTE CARLO. THE OTHER CAR I HAD WITH THE SAME MALFUNCTION WAS A 1995 CHEVY BERETTA. ALL REPAIRS ARE COSTLY. *JB

  Sep 12, 2006 · 120,000 miles
• Exterior lighting › Turn signal › Switch

  THE TURN SIGNAL SWITCH HAS AN UNNATURAL TENDENCY TO FAIL ON ALL 95-99 MONTE CARLO AND 95- 00 LUMINA'S MADE BY CHEVROLET THIS CAN CAUSE A FAILURE IN THE ELECTRICAL SYSTEM RESULTING IN THE FAILURE OF THE BRAKE LIGHTS. THE TURN SIGNAL SWITCH WILL NEED TO BE REPLACED. THIS HAS RESULTED IN THE PROPER OPERATION OF THE BRAKE LIGHTS. OLD PART NOT AVAILABLE. *NM

  Aug 16, 2006 · 55,000 miles
• Service brakes, hydraulic › Foundation components

  DECREASE BRAKING ABILITY ON WET PAVEMENT. *JB

  Mar 15, 2006 · 96,450 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• POWER RACK AND PINION STEERING FAILUREClosedLed to recall 03V527000

  GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER…

  EA03019 · opened Sep 15, 2003 · closed Dec 18, 2003
• POWER RACK AND PINION STEERING FAILUREClosed

  GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED…

  RQ03001 · opened Jan 2, 2003 · closed Sep 15, 2003
• DEGRADED BRAKING PERFORMANCEClosed

  There is no summary currently available

  EA98019 · opened Aug 31, 1998 · closed Dec 13, 2001
• DEGRADED BRAKING PERFORMANCEClosedLed to recall 01I014000
  PE98023 · opened Apr 23, 1998 · closed Aug 31, 1998