Model year record

2005 Chevrolet Monte Carlo recalls & problems

The 2005 Chevrolet Monte Carlo has 4 safety recalls and 120 owner complaints on file with NHTSA. The most-reported problem area is electrical system (89 complaints).

Recalls4safety recalls

Complaints120filed by owners

Crashes · fires1 · 3reported in complaints

Injuries · deaths0 · 0reported in complaints

2005 Chevrolet Monte Carlo in an NHTSA crash test — NHTSA crash test

Safety recalls

Electrical systemJul 3, 2014

Ignition

Recall 14V4000005,877,718 vehicles

Problem: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Fix: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

SteeringFeb 17, 2009

Steering

Recall 09E005000979 vehicles

Problem: DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Risk: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Fix: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

SteeringOct 17, 2008

Steering

Recall 08E0630003,855 vehicles

Problem: DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Risk: IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.

Fuel system, otherMar 12, 2007

Storage › Tank assembly › Pressure relief devices

Recall 07E021000742 vehicles

Problem: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Risk: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Fix: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2005 Chevrolet Monte Carlo 2-DR.

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

2005 Chevrolet Monte Carlo NHTSA side crash test — NHTSA side barrier crash test

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Monte Carlo

22mpg combined

City / highway	19 / 29 mpg
Fuel	Regular Gasoline

3.4 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,050/year to fuel

Monte Carlo

21mpg combined

City / highway	18 / 28 mpg
Fuel	Regular Gasoline

3.8 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,200/year to fuel

Monte Carlo

20mpg combined

City / highway	17 / 26 mpg
Fuel	Premium Gasoline

3.8 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $4,100/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Typical mileage*
Electrical systemInstrument cluster/panel; Wiring › Interior/under dash	89	0	3	69,500 mi
Exterior lightingHeadlights › High/low beam dimmer switch; Tail lights	17	0	0	81,000 mi
Vehicle speed control	5	0	1	65,000 mi
Fuel system, gasolineDelivery › Fuel pump	5	0	0	68,500 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip	4	0	0	37,000 mi
Engine	4	0	0	—
Fuel/propulsion system	4	0	0	100,000 mi
Engine and engine coolingEngine	3	0	0	—
SuspensionFront	3	0	0	—
Power trainAutomatic transmission	3	0	0	—
Air bags	3	1	0	—
Electronic stability control (esc)	3	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Service brakes
I have had numerous lights, noise, continuously for the last 7 years have replaced numerous parts, only to last awhile then the lights, noise return. Seems there is no cure for this malfunctioning problem, have heard GM is aware of these problems but have never received a letter regarding them, the anti-lock traction control braking system on these cars are headaches and troublesome, and expensive with no cure in sight, have spent tons of money on these problems, still keep having them.
Jan 9, 2024
Power train
THE PCM FOR THE TRANSMISSION IS OUT OR DEFECTIVE AND FROM WHAT I'VE RESEARCHED THIS IS A VERY COMMON PROBLEM WITH THE MONTE CARLO. CHEVROLET SHOULD BE RESPONSIBLE FOR SELLING A KNOWN DEFECTIVE COMPUTER!
Mar 2, 2019
Air bags
TAKATARECALL STIL TILL I HAVE THAT PROBLEMS
Jul 3, 2014
Electrical system
WHEN I FIRST BOUGHT THIS CAR THE BOOST GAGE WAS NOT WORKING. A FEW DAYS LATER THE GAS OIL PRESSURE AND TEMPERATURE GAUGES STARTED GOING CRAZY. THE TEMPERATURE GAUGE NEEDS TO WORK TO SHOW OVERHEATING OF ENGINE TO AVOID DAMAGE. INTERNET FORUMS SAY THIS ISSUE A VERY COMMON ISSUE. PICTURE SHOWS GAUGES ON LEFT AFTER CAR RUNNING 10 MIN WITH APPROX HALF TANK OF GAS
May 2, 2018 · 94,000 miles
Exterior lighting
THE MULTI FUNCTION SWITCH IS FAULTY. MY BLINKERS NEVER WORK RIGHT. SOMETIMES I HAVE RIGHT AND NO LEFT TURN SIGNAL AND MANY TIMES THE HAZARD LIGHTS TURN ON WHEN I USE TURN SIGNAL. THE TURN SIGNAL SOUND OF CLICKING NEVER STOPS, CONSTANT CLICKING THAT OFTEN STARTS BUZZING. QUITE OFTEN MY TURN SIGNALS DO NOT FUNCTION PROPERLY AND I HAVE NO WAY TO ALERT OTHER DRIVERS THAT I AM SWITCHING LANES. IT SEEMS TO BE A COMMON PROBLEM WITH CHEVROLET AND GMC AND EXPENSIVE TO CORRECT.
May 10, 2010
Fuel/propulsion system
FEUL PRESSURE REGULATOR RECALL #07E021000 FOR 2005 IMPALA, BUT NOT FOR MY MONIE CARLO , GAS SMELL WHILE DRIVING/FUEL PRESSURE REGULATOR LEAKING.
Jul 21, 2017
Electrical system
TL* THE CONTACT OWNS A 2005 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE KEY FAILED TO TURN OVER IN THE IGNITION SO THE CONTACT WAS UNABLE TO START THE VEHICLE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS WAITING TO BE REFERRED TO AN AUTHORIZED DEALER TO DIAGNOSE THE FAILURE AND PROVIDE THE RECALL REMEDY. THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.
Mar 6, 2017
Fuel/propulsion system
MY CAR HAS A STRONG GAS ODOR PARTICULARLY IN COLDER WEATHER. I NOTICED IT LAST WINTER AND IT WENT AWAY DURING THE SUMMER. NOW THAT THE TEMPS ARE GETTING COOLER, IT HAS STARTED AGAIN. I TURN ON THE HEAT AND HAVE TO DRIVE WITH THE WINDOWS DOWN FOR VENTILATION. I'VE HAD THREE DIFFERENT MECHANIC SHOPS CHECK IT OUT. NONE HAVE BEEN ABLE TO FIND THE CAUSE. IT IS EMBARRASSING IN THE SCHOOL CAR RIDER LINE OR IN A DRIVE THROUGH. SOMEONE ALWAYS COMMENTS ON IT. I AM WORRIED IT MAY CATCH FIRE.
Nov 16, 2016 · 115,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.