Model year record

2006 Chevrolet Monte Carlo recalls & problems

The 2006 Chevrolet Monte Carlo has 2 safety recalls and 113 owner complaints on file with NHTSA. The most-reported problem area is electrical system (29 complaints).

Recalls2safety recalls

Complaints113filed by owners

Crashes · fires11 · 0reported in complaints

Injuries · deaths15 · 2reported in complaints

2006 Chevrolet Monte Carlo in an NHTSA crash test — NHTSA crash test

Safety recalls

Electrical systemJun 23, 2014

Ignition

Recall 14V3550003,141,731 vehicles

Problem: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) is recalling certain model year 2005-2009 Buick LaCrosse, 2006-2011 Buick Lucerne, 2000-2005 Cadillac DeVille, 2006-2011 Cadillac DTS, 2006-2014 Chevrolet Impala, and 2006-2007 Chevrolet Monte Carlo vehicles. In the affected vehicles, the weight on the key ring and road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury. Additionally, a key knocked out of the run position will cause loss of engine power, power steering, and power braking, increasing the risk of a vehicle crash.
Fix: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 23, 2014. Owners may contact General Motors customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), and 1-800-222-1020 (Chevrolet). GM's number for this recall is 14299.

SteeringFeb 17, 2009

Steering

Recall 09E005000979 vehicles

Problem: DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Risk: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Fix: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2006 Chevrolet Monte Carlo 2-DR. w/ SAB

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

2006 Chevrolet Monte Carlo 2-DR.

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

2006 Chevrolet Monte Carlo NHTSA side crash test — NHTSA side barrier crash test

2006 Chevrolet Monte Carlo NHTSA side pole crash test — NHTSA side pole crash test

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Monte Carlo FFV

22mpg combined

City / highway	19 / 29 mpg
Fuel	Regular Gasoline

3.5 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,050/year to fuel

Monte Carlo

21mpg combined

City / highway	18 / 26 mpg
Fuel	Regular Gasoline

3.9 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,200/year to fuel

Monte Carlo

19mpg combined

City / highway	16 / 26 mpg
Fuel	Premium Gasoline

5.3 L · 8 cyl · Automatic 4-spd · Front-Wheel Drive · about $4,350/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Injuries	Typical mileage*
Electrical systemIgnition; Instrument cluster/panel	29	1	1	80,000 mi
Power trainAutomatic transmission	27	0	2	86,000 mi
SteeringHydraulic power assist › Hose, piping, and connections; Rack and pinion › Rack	21	2	0	45,000 mi
Air bagsFrontal › Sensor/control module; Frontal	10	8	12	80,000 mi
TiresPressure monitoring and regulating systems	9	0	0	20,250 mi
Engine and engine coolingCooling system	6	0	0	40,000 mi
Engine	6	0	0	72,140 mi
Seat beltsFront › Anchorage; Rear/other	5	0	0	37,000 mi
Unknown or other	4	0	0	—
VisibilityDefroster/defogger/hvac system; Rearview mirrors/devices › Exterior	4	0	0	—
StructureBody	3	1	4	42,000 mi
Vehicle speed controlAccelerator pedal	3	1	1	37,000 mi

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Power train
The contact owns a 2006 Chevrolet Monte Carlo. The contact stated while driving 30 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was no warning light illuminated. The contact restarted the vehicle; however, the failure returned soon after restart. The dealer was notified of the failure and the contact was informed that there were no recalls on the vehicle related to the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 200,000.
Feb 1, 2024 · 200,000 miles
Service brakes
These issues have been spotadic since I aquired the vehicle in october of 2021. Not infrequently the ABS system feels like it is trying to engage at low speeds with light braking such as in a parking lot. This also happens after coasting(no gas, no brake no cruise control))and then accelerating The radio will randomly stop playing or begin playing. The turn signal indicator chimes randomly stop chiming when the turn signal is in use though the interioir indicator light will flash normally. I have not been able to stop when this occurs with the turn signal still active to get out and verify it the turn signal is actually working At random times a loud clacking sound will come from behind the…
Feb 22, 2022
Electronic stability control (esc)
ABS AND TRACTION CONTROL LIGHT FLASHES WHEN TRYING TO ACCELERATE. IT LOSES POWER AND GAUGES DROP AS IF THE CAR SHUT DOWN. WILL DO THIS GOING DOWN THE HIGHWAY. *TR
Jun 8, 2020 · 135,000 miles
Air bagsCrash4 injuries
CAR MALFUNCTION MY PASSENGER WHO WAS MY BABYMAMMA PASAED AWAY
Sep 3, 2019 · 160,000 miles
Structure › Body
PAINT PEELING IN WHEEL WELLS
Oct 5, 2014 · 10,000 miles
Electrical system › Ignition
TL* THE CONTACT OWNS A 2006 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE WAS SERVICED FOR NHTSA CAMPAIGN NUMBER: 14V355000 (ELECTRICAL SYSTEM) BY WHALEN CHEVROLET INC. (1258 NY-29, GREENWICH, NY 12834, (518) 692-2241). HOWEVER, IT FAILED TO PROVIDE A PERMANENT REMEDY. WHILE DRIVING OVER A BUMP IN THE ROAD, THE VEHICLE LOST POWER AND SHUT OFF. IN ADDITION, THERE WERE INSTANCES WHEN THE KEY HAD TO BE MANEUVERED BACK AND FORTH IN ORDER TO BE REMOVED FROM THE IGNITION. THE VEHICLE WAS UNABLE TO BE DRIVEN DUE TO VARIOUS WARNING INDICATORS AND GAUGES FLICKERING AND THE VEHICLE WAS UNABLE TO START. THE CONTACT PLANNED TO TAKE THE VEHICLE BACK TO THE DEALER FOR SERVICING. THE…
Jun 1, 2016 · 25,000 miles
Electrical system
THE REAR WINDOW DEFOGGER NO LONGER WORKED. THE REASON BEING THAT THE REAR DEFROSTER WIRING HAD BURNED AT THE CONNECTOR BLOCK. CONNECTOR BLOCK IS LOCATED BEHIND THE PASSENGERS SIDE KICK PANEL. THIS COULD HAVE CAUSED A FIRE TO THE INTERIOR OF THE VEHICLE. THERE ARE VIDEOS ON THE INTERNET SHOWING HOW TO RESOLVE THIS PROBLEM SO IT MUST HAPPEN FREQUENTLY! YOU CAN SEE WHERE THE BURN OCCURED IN THE ATTACHED PHOTO. I REPAIRED THIS ON 3/9/2018, HOWEVER, IT HAPPENED AT LEAST TWO YEARS AGO.
Mar 9, 2018 · 80,000 miles
Electrical system
TL* THE CONTACT OWNS A 2006 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE INTERIOR LIGHTING AND INDICATORS ON THE INSTRUMENT PANEL WERE ILLUMINATED AFTER THE KEY HAD BEEN REMOVED FROM THE IGNITION. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER AN UNKNOWN RECALL REGARDING THE IGNITION, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO CONCORD CHEVROLET (1330 CONCORD AVE, CONCORD, CA 94520 (925) 682-6400) WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL SYSTEM FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 130,000.
Oct 1, 2017 · 130,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

POWER STEERING FLUID LEAKS - FIRESClosed
GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE, MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE…
PE09025 · opened May 13, 2009 · closed Oct 2, 2009