Model year record

2013 Chevrolet Volt recalls & problems

The 2013 Chevrolet Volt has 3 safety recalls and 308 owner complaints on file with NHTSA. The most-reported problem area is air bags (161 complaints).

Recalls3safety recalls

Complaints308filed by owners

Crashes · fires8 · 2reported in complaints

NHTSA overall5 ★crash-test stars

2013 Chevrolet Volt in an NHTSA crash test — NHTSA crash test

Safety recalls

Air bagsJul 27, 2023

Frontal › Driver side › Inflator module

Recall 23V516000767 vehicles

Problem: General Motors, LLC (GM) is recalling certain 2013 Buick Verano, Chevrolet Camero, Sonic, and Volt vehicles. The driver-side air bag inflator may explode during deployment due to a manufacturing defect.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Fix: Dealers will replace the driver-side air bag module, free of charge. On some 2013 Volt vehicles, the steering wheel will be replaced as well, free of charge. Owner notification letters were mailed October 23, 2023. Owners may contact Buick customer service at 1-800-521-7300 and Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232413120.

Hybrid propulsion systemJun 14, 2018

Hybrid propulsion system

Recall 18V3970004,606 vehicles

Problem: General Motors LLC (GM) is recalling certain 2013 Chevrolet Volt vehicles. An update to the Hybrid Powertrain Control Module 2 (HPCM2) may have disabled the cell balancing function causing a low-voltage condition.
Risk: If the voltage drops, the vehicle may lose propulsion, increasing the risk of crash.
Fix: GM will notify owners, and dealers will reprogram the HPCM2, free of charge. The recall began July 24, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18215.

Electrical systemMar 13, 2015

Ignition

Recall 15V14500050,236 vehicles

Problem: General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Risk: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Fix: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.

Components: Electrical system › Ignition; Engine and engine cooling › Engine › Gasoline

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2013 Chevrolet Volt 4 DR FWD

Overall★★★★★

Frontal crash	★★★★★
Side crash	★★★★★
Rollover	★★★★★
Rollover risk	9.3%

Forward collision warning: Optional · Lane departure warning: Optional

2013 Chevrolet Volt NHTSA side crash test — NHTSA side barrier crash test

2013 Chevrolet Volt NHTSA side pole crash test — NHTSA side pole crash test

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Volt Plug-in Hybrid

37mpg combined

City / highway	35 / 40 mpg
Electric range	38 mi
On electricity	98 MPGe · 35 kWh/100 mi
Fuel	Premium Gasoline

1.4 L · 4 cyl · Automatic (variable gear ratios) · Front-Wheel Drive · about $2,200/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Air bagsFrontal › Sensor/control module	161	1	0	1	76,000 mi
Electrical systemPropulsion system; 12v/24v/48v battery	63	1	1	3	57,000 mi
Fuel/propulsion system	53	2	1	2	60,000 mi
Engine	37	1	0	2	48,082 mi
Seats	31	0	0	0	68,257 mi
Power train	24	2	0	2	47,082 mi
Service brakes	19	4	0	1	23,000 mi
Unknown or other	15	1	0	1	73,000 mi
StructureBody; Body › Trunk lid	6	0	0	0	62,000 mi
TiresTread/belt; Pressure monitoring and regulating systems	6	1	0	1	2,176 mi
Vehicle speed control	6	0	0	1	67,890 mi
Steering	5	2	0	1	18,000 mi

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Electrical system
Fully charged. Goes from electric to generator/gas propulsion and abruptly slowes about 1/2 speed. Very dangerous.
Apr 27, 2026
Air bags
The passenger presence sensor is failing or failed because every time someone sit in there the airbag turns on and off repeatedly every 2-3 mins and gives a service airbag warning and if no one is sitting in the passenger seat then it just stays on. Could be really dangerous if a wreck happens while itâs glitching in the off mode and could cause death. Multiple people have had this problem with the volts and there is even a thing you can by to completely bypass the airbag going off which shows how common the problem is if there is a solution to eliminate it in an unsafe/not factory manner
Oct 13, 2025
Fuel/propulsion system
I received the "Propulsion Power is Reduced" Alert engine light while driving in "Normal" mode on the freeway at around 60mph with 8-9 miles of Battery capacity, it showed 0 miles of Battery forcing the Gas Engine on and the vehicle hesitated upon applying the accelerator for the remainder of the drive. My safety and that was others was at risk because the acceleration dropped quickly and I was on a busy freeway at the time when the Alert happened causing further hesitation. Upon stopping I could not get the vehicle to take a charge nor would it start up until a mechanic arrived and was able to confirm the problem.
Feb 3, 2026
Engine and engine cooling
The contact owns a 2013 Chevrolet Volt. The contact stated that while driving at approximately 45 MPH, the vehicle stalled. The Check Engine warning light was flashing, and the messages "No Propulsion Power" and "No Power To Engine" were displayed. The contact stated that two individuals pulled over and assisted the contact in pushing the vehicle to the side of the road to prevent a crash. The vehicle was towed to an independent mechanic, who made the contact aware of an unknown NHTSA Campaign Number; however, the VIN was not included. The vehicle was towed to a dealer, but the vehicle was not diagnosed or repaired. The contact requested vehicle rental assistance, but the dealer was unable…
Dec 13, 2025 · 141,323 miles
Air bags
The passenger occupancy sensor gives a false positive. The only way I can get rid of the beeping is plug in the seatbelt. I have read on Reddit forums that this is a very common problem with 2013 volts, but for some reason there isn't a recall. This is a safety issue. Thank you!
Jul 6, 2025
Fuel/propulsion system
Propulsion power reduced error has happened many times but the recall lookup shows that there are no active recalls on our car. There was a recall on this problem in 2018 so I think it may have been done my the last owner but it is still having this problem.
Sep 10, 2025
Seat belts2 injuries
The drivers side front seatbelt pretensioner assembly contains a braided steel cable. The cable, through normal use, has become damaged to the point that individual wires have broken free from the crimped connector. The damaged wires of the cable have penetrated through the plastic sheath covering the cable causing a needle sharp poking hazard when reaching oneâs hand toward the seat back adjustment lever. My wife had a minor laceration to her finger and I was also poked when trying to identify the cause. Upon further inspection I found that approximately 80 percent of the diameter of the pretensioner cable had broken free from the crimped connector. In the event of a collision, the cable…
Sep 26, 2025
Fuel/propulsion system
Fuel leaking from fuel tank at filler inlet. Defect in fuel tank assembly. Large puddle of gasoline formed under car after refueling causing buildup of fumes in closed garage. Vehicle has not been inspected by anyone other than owner. There were no warning lamps prior to failure.
Sep 13, 2025

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Pedestrian alert soundsClosedLed to recall 22V063000
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review…
DP22005 · opened Jan 27, 2023 · closed Aug 7, 2023
Passenger Sensing SystemClosed
In September 2019, the Office of Defects Investigation (ODI) opened PE19-013 to assess the potential safety related effects of a malfunction of the Passenger Sensing System (PSS) in 2012-2013 Model Year (MY) Chevrolet Volt vehicles. Consumers reported that due to a malfunction of the PSS, the air bag system malfunction indicator light (MIL) was activated. Many of the complaints noted the malfunction occurred after the warranty period expired and mentioned high repair costs as a major deterrent to the repair of the vehicle.The PSS sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the frontal passenger air bag. The PSS may develop a malfunction due to bunching of the sensor mat in the seat trench. The bunching of the sensor mat could cause the mat to repeatedly fold in the same…
PE19013 · opened Sep 17, 2019 · closed Jul 2, 2021