*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Power train
The contact owns a 2019 Chevrolet Volt. The contact stated that while the vehicle was shifted to park(P), the message to âShift to Parkâ remained displayed. The contact was unable to turn off the vehicle. The contact stated that for approximately 10 minutes, the gear shifter was shifted out of and back into park to be able to turn off the vehicle. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 35,000.
Aug 12, 2025 · 35,000 milesElectrical system
The contact owns a 2019 Chevrolet Volt. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the battery high-voltage disconnect relay. The vehicle was not repaired due to a lack of part availability. The manufacturer was notified of the failure, a case was opened, and the manufacturer confirmed that the part was on backorder. The failure mileage was 80,000.
Apr 21, 2025 · 80,000 milesPower train
When shifted into park, persistent error message that car was not in park. Unable to shut off the car despite numerous manipulations of shift. Few similar preceeding incidents were resolved by shift to drive then back to park. Goes to dealer tomorrow. Car running endlessly is dangerous. What if I could not stay with the car, or the car was on the local ferry. No one has inspected it yet. First time problem occured was in November 2024. Most recent more serious problem occured Friday. I am afraid to use the car since, and have not driven it since.
Dec 13, 2024Seats
Driver seat frame has a loud squeak during normal operation of vehicle. Driver seat is a critical safety item, and my concern is that the seat frame has a manufacturing defect.
Dec 1, 2021Power train
Two incidents related to the powertrain. 1) In December, 2023, the EV battery was drained and the car would not start based on the gas motor. The dealer fixed it in our recollection. 2) On [XXX], I was driving the car out of a Detroit Convention Center parking lot, going up the ramp when the car, with no warning, completely lost power and stopped. The message on the display said "Powertrain loss" or "Powertrain lost." I wish I had taken a photo of it, but I was panicked. Cars were backed up behind me on the ramp out of the parking garage, honking and having to back up. I tried turning the car off and on, googling the problem, and was about to call a tow truck when after 12-13 minutes, I was…
May 18, 2024Engine
Mileage: 38523 Engine Not Available Service Soon Propulsion Power Is Reduced Fuel Range Low: 3/4 Tank full of gas [XXX] - I was driving Northbound on [XXX] South of Castlewood in Northern California. I was driving 70 mph when I suddenly received the error messages above on my dashboard screen. The vehicle immediately had power from 70 mph quickly going below 59 mph. The traffic was extremely high and I had to quickly use my hazard flashes and carefully maneuver to the right shoulder of the frwy. The vehicle lost power so quickly I could have easily been rear ended or in a serious vehicle accident. The dealer test drove the vehicle and stated they received the errors at 95 mph. The…
Jun 1, 2024Steering
While driving home one evening, the power steering suddenly failed. A warning message displayed to service the power steering. It became very difficult to steer the car. I had to pull extremely hard on the wheel to be able to make turns. For the turn into my community, I had to make four attempts to get the car to clear the turn through the entrance gate, needing to back up repeatedly and retry. Fortunately I did make it home safely and shut the car down. I made an emergency repair appointment for the next day at a Chevrolet dealership. In the morning the power steering was back. The car was inspected at the dealership. They told me a software update was needed and they charged me $450 to…
Dec 4, 2023Electrical systemCrash
Vehicle lost propulsion and all power mid turn at approximately 45mph. Powe steering and assisted brakes were gone. Conditions were rainy, resulting in single car crash. Car did not restart. No codes present. Occurred again after repairs at 70mph on highway. Codes P0AC4 and P0C0E indicating Drive Motor Power Inverter B. Despite being under warranty, GM cannot repair, and has no replacement parts. GM has ignored messages requesting buyback per federal law.
Sep 23, 2023
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
