Model year record

2006 Chrysler Town and Country recalls & problems

The 2006 Chrysler Town and Country has 4 safety recalls and 431 owner complaints on file with NHTSA. The most-reported problem area is steering (112 complaints).

Recalls4safety recalls

Complaints431filed by owners

Crashes · fires23 · 15reported in complaints

Injuries · deaths32 · 1reported in complaints

Safety recalls

EquipmentAug 10, 2010

Equipment

Recall 10E0340006,686 vehicles

Problem: CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.
Risk: IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.
Fix: CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.

Air bagsJan 11, 2010

Frontal › Sensor/control module-inactive

Recall 10V008000308,950 vehiclesopened after NHTSA action (ODI)

Problem: CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, ALASKA AND THE DISTRICT OF COLUMBIA. THE FRONT CRASH SENSORS MAY CRACK UNDER CERTAIN ENVIRONMENTAL CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THIS CAN CAUSE THE SENSOR TO BECOME INOPERATIVE AND ILLUMINATE THE AIRBAG WARNING LIGHT. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE AIRBAG SYSTEM IN CERTAIN FRONTAL CRASHES.
Risk: IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.
Fix: CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

VisibilityDec 11, 2007

Glass, side/rear

Recall 07E1040001,657 vehicles

Problem: CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
Risk: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
Fix: SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

VisibilityMar 8, 2006

Windshield wiper/washer › Motor

Recall 06V067000268,800 vehicles

Problem: ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.
Risk: DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.
Fix: DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

Town and Country 2WD

19mpg combined

City / highway	17 / 24 mpg
Fuel	Regular Gasoline

3.3 L · 6 cyl · Automatic 4-spd · 2-Wheel Drive · about $3,550/year to fuel

Town and Country 2WD

18mpg combined

City / highway	16 / 23 mpg
Fuel	Regular Gasoline

3.8 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,700/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
SteeringRack and pinion; Rack and pinion › Rack	112	3	1	0	50,900 mi
Electrical systemInstrument cluster/panel; Wiring	74	2	7	1	80,000 mi
Exterior lightingTurn signal; Headlights	72	1	5	0	92,500 mi
Air bagsFrontal › Sensor/control module; Frontal	63	10	1	22	70,000 mi
Service brakes, hydraulicFoundation components › Disc › Pads; Foundation components › Disc › Rotor	27	1	0	0	22,045 mi
Fuel/propulsion system	26	0	0	0	100,000 mi
StructureBody › Door; Body	19	2	0	9	69,500 mi
VisibilityGlass, side/rear; Power window devices and controls	17	0	0	1	30,000 mi
Engine	16	1	0	0	97,650 mi
Engine and engine coolingEngine; Cooling system	15	0	0	0	38,100 mi
Power trainAutomatic transmission; Axle assembly › Axle shaft	14	1	0	0	79,000 mi
Fuel system, gasoline	14	0	0	0	74,000 mi

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Unknown or otherCrash
Vehicle hasn't been inspected, issue is still present. My child was able to move gear shift and change gears causing vehicle to roll down driveway into woods, without key in ignition or foot on brake. I have video evidence of occurrence and video of issue without key or foot on brake
Dec 28, 2023
Unknown or other
The horn does not work and there was a recall for this.
Oct 1, 2020
Service brakes
UNKNOWN
Apr 15, 2022
Latches/locks/linkages › Doors › Latch
The contact owns a 2006 Chrysler Town and Country. The contact stated that while driving at various speeds, the turn signal, and brake light failed to function as needed. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who diagnosed that the center third brake light needed to be replaced. The contact stated that the vehicle was repaired; however, the failure had been reoccurring while driving. The contact also stated that the rear driverâs side door failed to open. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The approximate failure mileage was unknown.
Dec 10, 2018
Air bagsCrash3 injuries
Was rearended by an 18 wheeler doing 55 mph I was stopped waiting for oncoming traffic to pass so I could turn left. He never braked. The van was pushed 200feet before it began to roll into trees. None of the airbags were deployed nor did the seatbelts lock. All 3 people were injured.
Nov 21, 2021
Latches/locks/linkages
The contact owns a 2006 Chrysler Town and Country. The contact stated that while he was a passenger in the vehicle, the driverâs side rear sliding door failed to open, and the contact had to exit from the trunk of the vehicle. The dealer was made aware of the failure and informed the contact that there was no recall associated with the Vin. The dealer inspected the vehicle and provided the contact with an estimate for the repair. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 99,000.
Dec 25, 2020 · 99,000 miles
Exterior lighting › Headlights
TL* THE CONTACT OWNS A 2006 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT WHEN THE HEADLIGHT SWITCH WAS TURNED ON, THE HEADLIGHTS FAILED TO ILLUMINATE. ADDITIONALLY, ON SEVERAL OCCASIONS, THE HEADLIGHTS FAILED TO REMAIN ILLUMINATED WHILE DRIVING AT NIGHT. THE CONTACT STATED THAT THE HEADLIGHTS RETURNED TO NORMAL OPERATION AFTER MANIPULATING THE HEADLIGHT SWITCH SEVERAL TIMES. THE VEHICLE WAS TAKEN TO STEVE WHITE MOTORS (3470 HIGHWAY 70 SE, HICKORY, NC 28603, (828) 414-1499) HOWEVER, THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS CONTACTED AND STATED THAT THERE WAS NO WARRANTY COVERAGE ON THE VEHICLE AND REFUSED TO OFFER FURTHER ASSISTANCE. THE FAILURE MILEAGE…
Nov 2, 2015 · 65,000 miles
Suspension
EACH FRONT COIL SPRING BROKE ABOUT TWO YEARS APART I WAS DRIVING ABOUT 55 MPH ON A BUSY CITY HIGHWAY WHEN I SUDDENLY FELT WHAT APPEARED TO BE A BADLY BALANCED TIRE. I MANAGED TO EXIT AND STOP IN A RETAIL PARKING LOT AND INSPECT THE TIRES. WHAT I FOUND WAS A BROKEN FRONT DRIVER SIDE COIL SPRING RESTING ON THE TIRE. THE TIRE WAS HOT ENOUGH TO SMOKE. THE TIRE WAS NO LONGER USABLE. ABOUT 2 YEARS AGO ON THE SAME VEHICLE THE PASSENGER SIDE FRONT COIL SPRING BROKE, BUT DID NOT RUB ON THE TIRE. IT SEEMS SO ODD THAT TWO COILED SPRINGS BROKE ON THE SAME VEHICLE. AFTER HEARING OF OTHER FAILURES I THOUGHT IT SHOULD BE REPORTED. I DO FEEL BLESSED THAT AN ACCIDENT DID NOT OCCUR IN EITHER CASE. MODEL…
Nov 7, 2020 · 109,775 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Engine Stall After RefuelingClosed
This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand Caravan, Dodge Caravan, Chrysler Town and Country and Chrysler Voyager minivans.NHTSA evaluated the petition by analyzing consumer complaints submitted to the Agency, analyzing field data, reviewing technical information provided in Chrysler's response to an Agency information request and testing an RS minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, NHTSA has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these…
DP14002 · opened Sep 5, 2014 · closed Apr 6, 2015
Loss of headlight illuminationClosed
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA,…
EA11010 · opened Sep 6, 2011 · closed Nov 29, 2012
Fleet Vehicle Recall Completion AuditClosed
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and…
AQ10001 · opened Nov 18, 2010 · closed Dec 28, 2015
FRONT AIR BAG CRASH SENSOR FAILUREClosedLed to recall 10V008000
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE…
RQ09003 · opened Jul 1, 2009 · closed Feb 18, 2010