Model year record

2008 Ford F-350 Sd recalls & problems

The 2008 Ford F-350 Sd has 1 safety recall and 101 owner complaints on file with NHTSA. The most-reported problem area is steering (26 complaints).

Recalls1safety recalls

Complaints101filed by owners

Crashes · fires7 · 4reported in complaints

Injuries · deaths2 · 0reported in complaints

Safety recalls

EquipmentDec 9, 2020

Equipment

Recall 20E090000102 vehicles

Problem: Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.
Risk: If the steering locks, it can increase the risk of a crash.
Fix: Icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began December 21, 2020. Owners may contact Icon customer service at 1-951-689-4266.

Components: Equipment; Suspension › Front › Stabilizer bar; Steering

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
SteeringGear box (other than rack and pinion); Gear box › Shaft sector	26	5	0	1	52,250 mi
Engine and engine coolingExhaust system; Engine › Diesel	23	0	1	1	33,500 mi
SuspensionFront	13	1	0	0	34,900 mi
Power trainAutomatic transmission; Automatic transmission › Control module (tcm/pcm/tecm)	12	0	1	0	27,500 mi
TiresTread/belt	11	0	0	0	37,750 mi
Engine	10	0	0	0	62,000 mi
Service brakes, hydraulic	9	0	1	0	30,000 mi
Vehicle speed controlCruise control; Accelerator pedal	8	2	0	1	12,000 mi
Fuel system, diesel	8	0	0	0	34,599 mi
Wheels	6	1	0	0	59,500 mi
Electrical system	5	0	0	0	26,000 mi
StructureBody	3	1	0	0	91,000 mi

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Tires
TL* THE CONTACT OWNS A 2019 FORD F-350 SD, EQUIPPED WITH MICHELIN TIRES, TIRE LINE: LTX MS/2, TIRE SIZE: 245/75/R17, DOT NUMBER: B74345 (PARTIAL). THE CONTACT STATED WHILE DRIVING 75 MPH, THE FRONT DRIVER'S SIDE TIRE WENT FLAT AND THE STEERING CEASED. THE CONTACT DEPRESSED THE BRAKE PEDAL AND PULLED OVER TO THE SIDE OF THE ROADWAY. THE TIRE WAS REPLACED WITH THE SPARE TIRE. THE CONTACT STATED THAT IT WAS THE SECOND TIME THE FAILURE OCCURRED. THE FIRST TIME, THE FRONT PASSENGER SIDE TIRE WENT FLAT WHILE THE CONTACT WAS DRIVING AT AN UNDISCLOSED SPEED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THAT THERE WAS NO RECALL AND THAT THE TIRE WAS OVER THE WARRANTY COVERAGE PERIOD.…
Mar 26, 2021 · 54,000 miles
Steering
TL* THE CONTACT OWNS A 2008 FORD F-350 SD. WHILE DRIVING APPROXIMATELY 12 MPH, THE STEERING FAILED WITHOUT WARNING. THE CONTACT STATED THAT THE STEERING WHEEL BECAME DETACHED FROM THE STEERING BOX. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STEERING BOX NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. BOB BELL FORD WAS CONTACTED BY PHONE AT 410-766-3600 (LOCATED AT 7125 RITCHIE HWY, GLEN BURNIE, MD 21061). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.
Jan 11, 2018 · 125,000 miles
Steering
THE 2008, AS WELL AS OTHER YEARS OF THE FORD F-350 ARE KNOWN TO HAVE A PROBLEM WITH A FRONT-END SHIMMY OR "DEATH WOBBLE". I HAVE HAD SEVERAL THOUSAND DOLLARS OF WORK DONE TO MY F-350 IN ORDER TO RESOLVE THE DEATH WOBBLE PROBLEM. THE REPAIRS WORK FOR A TIME AND THEN, WITHOUT WARNING, THE DEATH WOBBLE RETURNS. THE FACT THAT THIS CAN OCCUR WITHOUT WARNING, AT HIGH SPEEDS, BY DRIVING OVER A VERY SMALL BUMP IN THE ROAD, MAKES THIS AN EXTRAORDINARILY DANGEROUS PROBLEM. I DON'T THINK I CAN ADEQUATELY DESCRIBE THE EXTREME NATURE OF THE DEATH WOBBLE. THE FRONT-END OF THE TRUCK IS BOUNCING LEFT AND RIGHT, THE ENTIRE VEHICLE IS TWISTING AND ROLLING, THE STEERING WHEEL IS BARELY CONTROLLABLE, ANYTHING…
Jul 24, 2018 · 128,000 miles
Power train
TL* THE CONTACT OWNS A 2008 FORD F-350 SD. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT HEARD AN ABNORMAL NOISE FROM THE FRONT OF THE VEHICLE. IN ADDITION, THE VEHICLE WENT INTO LIMP MODE. A LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT TO CALL NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 212,425. THE VIN WAS NOT AVAILABLE.
Jan 4, 2018 · 212,425 miles
Engine
ENGINE DID NOT KICK OUT OF REGIN CAUSEING OVER HEAT
Nov 1, 2017 · 119,000 miles
Steering
STEERING GEARBOX FAILED. STEERING FELT VERY LOOSE, PULLED INTO PARKING LOT. STEERING WOULD TURN RIGHT BUT WOULD NOT TURN TO THE LEFT.COULD HEAR A CRUNCHING OR POPPING NOISE WHEN ATTEMPTING TOP TURN LEFT. HAD VEHICLE TOWED TO LOCAL REPAIR SHOP THAT FOUND THE STEERING GEARBOX FAILED INTERNALLY.
May 13, 2017 · 52,500 miles
WheelsCrash
NITTO DURA GRAPPLER 245/75R/17 FRONT LEFT TIRE BLEW CAUSING VEHICLE TO CRASH INTO GUARD RAILING ON INTERSTATE. THE VEHICLE WAS DRIVING ON I-75 SB NEAR MM 181 APPROXIMATELY 72 MPH. I WAS NOT MADE AWARE OF THE RECALL. ON MARCH 6,2015 I HAD ANOTHER TIRE BLOW AND I FILED A NITTO CLAIM NUMBER 804190 (THROUGH THE TIRE DEALERSHIP). I RECEIVED FROM NITTO THE SAME TIRE IN EXCHANGE. EVEN THOUGHT THIS TYPE OF TIRE WAS RECALLED ON SAFERCAR.GOV ON NOVEMBER 4, 2015. WHY WAS IT REPLACED BY NITTO WITH ANOTHER DEFECTIVE TIRE??? NOW MY VEHICLE IS TOTALED!
Mar 7, 2017 · 75,000 miles
Steering
TL* THE CONTACT OWNS A 2008 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A RANDOM DEATH WOBBLE ASSOCIATED WITH THE STEERING AND SUSPENSION. A DEALER PERFORMED EXTENSIVE REPAIRS, BUT THE CONDITION CONTINUED. THE DEALER AND THE MANUFACTURER FAILED TO PROVIDE A REMEDY. THE VEHICLE WAS UNABLE TO BE SAFELY DRIVEN DUE TO A STRONG VIBRATION FROM THE STEERING, WHICH ALSO CAUSED THE SUSPENSION TO BE UNSTABLE. THE VEHICLE WAS PARKED AT THE CONTACT'S RESIDENCE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Dec 19, 2016

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Alleged Loss of SteeringClosed
The Office of DefectsInvestigation (ODI) opened PE13-014 after identifying five complaints alleging steering gear failure in model year (MY) 2008 Ford F-250 and F-350 Super Duty pick-up trucks and to evaluate the relationship between the design history of the steering gear assembly and the alleged defect.As background, ODI investigated steering gear sector shaft fractures in approximately 1.3 million MY 1999 - 2001 Ford Super Duty pick-up trucks and MY 2000 - 2001 Ford Excursion sport utility vehicles in Engineering Analysis EA01-009.The investigation determined that the sector shaft failures were the result of extraordinary, possibly multiple, impacts and not the result of fatigue.No defect in design, manufacturing or materials was identified in the sector shaft.EA01-009 was closed August 19, 2003 with 169 complaints, resulting in a rate of 12.9 incidents per 100,000 vehicles after…
PE13014 · opened May 7, 2013 · closed Jan 31, 2014