Model year record

2005 Ford F-550 Sd recalls & problems

The 2005 Ford F-550 Sd has 5 safety recalls and 32 owner complaints on file with NHTSA. The most-reported problem area is fuel system, diesel (17 complaints).

Recalls5safety recalls

Complaints32filed by owners

Crashes · fires0 · 0reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

Exterior lightingJul 13, 2011

Brake lights

Recall 11V35200026,715 vehicles

Problem: FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Risk: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Fix: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Components: Exterior lighting › Brake lights; Exterior lighting › Tail lights

EquipmentAug 28, 2007

Electrical

Recall 07E066000175 vehicles

Problem: CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Risk: IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Fix: ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

Electrical systemJun 10, 2005

Wiring

Recall 05V270000180,104 vehiclesopened after NHTSA action (ODI)

Problem: CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Risk: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Fix: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Fuel system, gasolineJun 9, 2005

Delivery › Hoses, lines/piping, and fittings

Recall 05V26600078,675 vehicles

Problem: ON CERTAIN PICKUP TRUCKS AND CHASSIS CAB VEHICLES EQUIPPED WITH 5.4L OR 6.8L GASOLINE ENGINES, THE FUEL JUMPER LINE MAY HAVE AN INCORRECT END FORM.
Risk: THE FUEL LINE MAY SEPARATE AT THE CONNECTION TO THE MAIN FUEL BUNDLE. IF THE FUEL LINE SEPARATES, AN OPERATOR MAY NOTICE A GASOLINE ODOR AND/OR FUEL ON THE GROUND, LOSS OF POWER, AND THE ENGINE WILL EVENTUALLY STALL. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Fix: DEALERS WILL INSTALL AN EXTERNAL RETENTION CLIP AT THE FUEL JUMPER LINE TO THE MAIN FUEL BUNDLE CONNECTION. THE RECALL BEGAN ON JUNE 20, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

SteeringApr 6, 2005

Gear box › Shaft pitman

Recall 05V135000481 vehicles

Problem: ON CERTAIN CHASSIS CAB TRUCKS, THE STEERING GEAR MAY HAVE SOME GEARS WITH A GEAR PISTON THAT WAS ASSEMBLED WITH AN INCORRECT RE-CIRCULATING BALL TUBE RETAINER. AN INCORRECT RETAINER MAY RESULT IN AN IMPROPERLY RETAINED RE-CIRCULATING BALL TUBE, WHICH MAY NOT KEEP THE RE-CIRCULATING BALLS IN PLACE DURING STEERING GEAR ACTUATION.
Risk: IF THE RE-CIRCULATING BALLS BECOME DISLODGED A VEHICLE OPERATOR MAY NOTICE NOISE AND INCREASED STEERING EFFORTS THAT MAY EVENTUALLY PROGRESS TO IMPAIRED STEERING OR POTENTIAL LOSS OF STEERING WHICH COULD RESULT IN A CRASH.
Fix: DEALERS WILL INSPECT THE STEERING GEAR FOR A SPECIFIC DATE CODE AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 4, 2005. OWNERS MAY CONTACT AT 1-800-392-3673.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Typical mileage*
Fuel system, dieselStorage › Tank assembly	17	47,500 mi
Engine and engine coolingEngine › Diesel; Cooling system	6	50,000 mi
Electrical systemWiring; 12v/24v/48v battery	5	55,050 mi
TiresSidewall	2	—
Power trainManual transmission; Driveline	2	—
Fuel system, gasoline	2	—
Engine	2	—
Fuel/propulsion system	2	—
WheelsLugs/nuts/bolts/studs	1	—
Service brakes, hydraulic	1	—
Vehicle speed control	1	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Fuel/propulsion system
I WAS DRIVING MY TRUCK AND IT STARTED TO LOSE POWER LIKE IT WAS RUNNING OUT OF FUEL. THEN ALL OF A SUDDEN THE TRUCK JUST SHUT OFF. I COULDN'T GET THE TRUCK TO RESTART AT ALL. THE TRUCK WAS TOWED TO A GARAGE. WHEN I LOOKED IN TO THE FUEL TANK I FOUND THE INSIDE OF IT WAS PEELING APART. I CHECKED THE FILTER AND THEY BOTH WERE CLOGGED WITH THE LINING OF THE FUEL TANK. *TR
Oct 31, 2013 · 140,000 miles
Engine
TL* THE CONTACT OWNS A 2005 FORD F-550. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE MISFIRED, HESITATED, AND STALLED WITH THE ILLUMINATION OF THE MAINTENANCE LIGHT. THE FAILURE RECURRED OVER THE COURSE OF 7 YEARS. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS ON SEVERAL OCCASIONS WHERE IT WAS STATED THAT THE INJECTORS, OIL PUMP, INTAKE GASKET, CRANK SHIFT, AND ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
Sep 21, 2005 · 30,000 miles
Fuel/propulsion system
TL* THE CONTACT OWNS A 2005 FORD F-550 SD. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT THE FAILURE WAS CAUSED BY A CLOGGED FUEL FILTER. THE FUEL TANK COATING PEELED OFF AND OBSTRUCTED THE FUEL FILTER. THE VEHICLE WAS REPAIRED BY REPLACING THE FUEL TANK AND THE FUEL FILTER. THE FAILURE WAS REPORTED TO THE MANUFACTURER. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 40,000.
May 6, 2013 · 40,000 miles
Engine
TL* THE CONTACT OWNS A 2005 FORD F550 SD. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER NOR WAS THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 53,000. *TR
May 17, 2013 · 53,000 miles
Vehicle speed control
TL* THE CONTACT OWNS A 2005 FORD F-550. THE CONTACT STATED THAT WHILE PARKING, THE VEHICLE ACCELERATED ON ITS OWN. THE CONTACT HAD TO APPLY THE BRAKES TO STOP THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED AND STATED THAT THEY WERE GOING TO LOOK INTO THE FAILURE. THE FAILURE MILEAGE WAS 115.000 AND THE CURRENT MILEAGE WAS 120,000.
Apr 17, 2012 · 115,000 miles
Engine and engine cooling › Engine › Diesel
TRUCK WAS PURCHASED BRAND NEW BY MY COMPANY IN 2005. THIS PROBLEM BEGAN IN 2008. I HAVE RECORDS OF PREVENTATIVE MAINTENANCE BEING DONE PER MANUFACTURER INSTRUCTIONS. I ALSO HAD THE PM DONE AT THE DEALERSHIP. THE CHIEF PROBLEM IS THE ENGINE HAS CONTINUAL POWER ISSUES WHICH INCLUDE STALLING, SHAKING, EXCESS SMOKING. THE ENGINE JUST STOPS RUNNING WHICH IS A HUGE SAFETY RISK WHILE DRIVING IT. SINCE 2008 THIS TRUCK HAS BEEN TO THE DEALERSHIP VIA TOW TRUCK FOR THE SAME CHIEF COMPLAINT AT LEAST 12 TIMES. EACH TIME THE DEALERSHIP WILL WORK ON THE EGR VALVE, THE EGR COOLER, THE OIL COOLER, THE ICP VALVE, INJECTORS, HEAD AND INTAKE GASKETS, THE COMPUTERS SHOOT CODES SUCH PO261, PO264, PO267, PO269,…
Sep 10, 2008 · 59,578 miles
Fuel system, gasoline
TRUCK STALLED I CHECK IT FUEL PUMP HAD STOP WORKING TOOK TO DEALER, NEXT TIME THE FICM WENT BAD I REPLACED IT DROVE GOOD FOR 1500 OR SO MILES THEN PROBLEMS AGAIN FORD SAID FUEL TANK RUSTING CAUSING FICM TO GO BAD AND CLOG INJECTORS FORD FIXED I ASKED ABOUT USE OF COOLENT THEY COULD NOT FIND ANY PROBLEM BUT I HAVE TO ADD ONE GALION EVERY WEEK AND TRUCK IS STARTING TO SMOKE! *TR
Sep 9, 2010 · 55,050 miles
Fuel system, diesel
TL*THE CONTACT OWNS A 2005 FORD F550. THE CONTACT STATED THE VEHICLE STARTED LOOSING POWER AND STALLING WHILE DRIVING. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THAT THE INJECTION CONTROL PRESSURE SENSOR FAILED. THE CONTACT REVIEWED NHTSA RECALL CAMPAIGN NUMBER 05V270000 (ELECTRICAL SYSTEM: WIRING), BUT WAS TOLD BY THE MANUFACTURER THAT THEIR VEHICLE WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 148,000 AND THE CURRENT MILEAGE WAS 153,000. FUEL INJECTION CONTROL MODULE WAS REPLACED. UPDATED 08/31/2011 *LN
Feb 15, 2011 · 148,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.