Model year record

2008 Ford F-550 Sd recalls & problems

The 2008 Ford F-550 Sd has 4 safety recalls and 26 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (9 complaints).

Recalls4safety recalls

Complaints26filed by owners

Crashes · fires2 · 0reported in complaints

Injuries · deaths1 · 0reported in complaints

Safety recalls

EquipmentNov 19, 2009

Appliance › Air conditioner

Recall 09V456000269 vehicles

Problem: CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.
Risk: THIS DEFECT COULD RESULT IN A FIRE.
Fix: CUES IS WORKING WITH CARRIER TO REMEDY THE AFFECTED VEHICLES. REPAIRS WILL BE MADE BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL BEGAN ON JANUARY 5, 2010. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR CUES AT 1-407-849-0190.

SeatsFeb 28, 2008

Seats

Recall 08V09600087,515 vehicles

Problem: FORD IS RECALLING 87,515 MY 2008 F250, F-350, F-450, AND F-550 VEHICLES FOR FAILING TO COMPLY WITH ALL THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." SOME 40% SPLIT AND CAPTAIN'S CHAIR DRIVER'S SEATS, EQUIPPED WITH LUMBAR SUPPORTS, MAY HAVE IMPROPER WELDS AT THE JOINT OF THE SEAT BACK PIVOT BRACKET AND THE SEAT BACK FRAME.
Risk: IN THE EVENT OF A CRASH, THE SEAT SIDE PIVOT BRACKET MAY CRACK OR BREAK, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Fix: DEALERS WILL ADD A REINFORCEMENT TO THE DRIVER'S SEAT BACK FRAME ON THE 40% SPLIT OR CAPTAIN'S CHAIR SEAT EQUIPPED WITH LUMBAR SUPPORT OR, IF NECESSARY, THE SEAT BACK FRAME WILL BE REPLACED. THE RECALL BEGAN ON MARCH 28, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Power trainMar 26, 2007

Automatic transmission › Control module (tcm/pcm/tecm)

Recall 07V13900033,169 vehicles

Problem: ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, EXCESSIVE TEMPERATURES IN THE DIESEL PARTICULATE FILTER IN THE EXHAUST SYSTEM MAY RESULT FROM EXCESS HYDROCARBONS IN THE EXHAUST.
Risk: LACK OF POWER OR ROUGH OPERATION, UNUSUAL NOISES FROM THE ENGINE OR EXHAUST, WHITE SMOKE FROM THE EXHAUST, AND POTENTIALLY A VISIBLE FLAME OUT THE TAILPIPE CAN OCCUR.
Fix: DEALERS WILL REPROGRAM THE POWER TRAIN CONTROL MODULE. THE RECALL BEGAN ON APRIL 3, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Electrical systemMar 26, 2007

12v/24v/48v battery

Recall 07V1400001,022 vehicles

Problem: ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, INSUFFICIENT CLEARANCE OF THE BATTERY POSITIVE (B+) WIRE TO THE RIGHT HAND SPLASH SHIELD BOLT MAY RESULT IN THE BATTERY B+ WIRE CONTACTING THE SPLASH SHIELD BOLT.
Risk: LONG TERM CONTACT COULD CAUSE WIRE CHAFE, RESULTING IN COPPER WIRE BEING EXPOSED. IF THIS CONDITION OCCURS, THE BATTERY B+ WIRE COULD SHORT TO GROUND INCREASING THE RISK OF A FIRE.
Fix: DEALERS WILL INSPECT THE BATTERY B+ WIRE LOCATION AND, IF NECESSARY, REPOSITION THE WIRE. THE RECALL BEGAN ON APRIL 3, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Injuries	Typical mileage*
Engine and engine coolingExhaust system; Engine	9	0	0	20,000 mi
Engine	6	0	0	33,000 mi
Power train	5	0	0	36,000 mi
Fuel/propulsion system	3	0	0	—
StructureFrame and members › Underbody shields	2	0	0	—
Fuel system, diesel	1	0	0	—
Vehicle speed control	1	0	0	—
Service brakes, hydraulic	1	1	1	—
Wheels	1	1	0	—
Unknown or other	1	0	0	—
Electrical system	1	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Fuel/propulsion system
Brought the truck in to ford and they told me that paint lining from the tank may of gone into the fuel lines and system so they suggested that we replace the tank and they also replaced 2 injectors and the wiring harness for the injectors and reset the check engine light drove fine till the check engine light come on then its in limp mode and only drives at 40 miles per hour it is unsafe to drive on the highway and I do like this truck
Jan 4, 2020
Power train
TRANSMISSION DOWN SHIFTS TO LOW GEAR WHILE DRIVING AT HIGH SPEEDS ON THE INTERSTATE.
Sep 8, 2020 · 150,000 miles
Electrical system
TL* THE CONTACT STATED THEIR COMPANY OWNS A 2008 FORD F-550 SD. THE CONTACT STATED THE VEHICLE'S HEATER CHORD HAD FAILED A TOTAL 5 TIMES IN THE PAST 2 YEARS. THE VEHICLE HAD BEEN TAKEN TO THE DEALER (ROESH FORD LOCATED AT 303 W GRAND AVE BENTONVILLE IL 60106 PHONE NUMBER: 630-279-6000) WHO REPLACED THE HEATER CHORD A TOTAL OF THREE TIMES, HOWEVER, THE FAILURE PERSIST. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Jan 1, 2018 · 150,000 miles
Engine
TL* THE CONTACT OWNS A 2008 FORD F-550 SD. WHILE DRIVING 65 MPH, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE ENGINE COMPARTMENT AND THE VEHICLE STALLED. THE CHECK ENGINE AND ENGINE OVERHEATING INDICATORS ILLUMINATED DURING THE FAILURE. THE VEHICLE WAS TOWED TO CHAPMAN FORD OF HORSHAM (1100 EASTON RD, HORSHAM, PA 19044) WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS OUT OF WARRANTY. THE FAILURE MILEAGE WAS 33,000. THE VIN WAS NOT AVAILABLE.
Mar 1, 2018 · 33,000 miles
Engine
TL* THE CONTACT OWNS A 2008 FORD F-550 SD. WHILE DRIVING APPROXIMATELY 55 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND A "STOP SAFETY NOW" MESSAGE DISPLAYED. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE EXHAUST FUEL TEMPERATURE SENSOR WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ISSUED A RECALL FOR THE 2011-2012 MODEL YEAR VEHICLES ASSOCIATED WITH NHTSA CAMPAIGN NUMBER: 13V535000 (ENGINE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
Feb 12, 2016 · 110,000 miles
Engine
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
Jul 16, 2014 · 150,000 miles
Engine
WE BOUGHT THIS TRUCK AND PAID OVER 30K AND PUT DOWN 10K. THEY NEVER GAVE US THE FULL REPORT HISTORY OF THE TRUCK... WITH TWO TO THREE MONTHS THE ENGINE WENT OUT. WE TOOK IT TO THE MECHANIC AND HE TOLD US ITS NOT WORTH IT. THE ENGINE IF REPLACED WILL GO OUT AGAIN. FORD HAD A DIFFERENTCOMPANY BUILD THE ENGINES AND ALL OF THERE ENGINES WERE BAD. I BELIEVE FROM 2006 TO 2008 UNTIL FORD TOOK OVER. SO, WE BOUGHT THIS TRUCK FROM 1900 HAMNER AVE, NORCO, CA 92860 (951) 737-6151. WE CONTACTED THEM AND THEY DID NOTHING ABOUT IT. SO, NOW I AM STILL MAKING MONTHLY PAYMENTS OF 543 A MONTH AND THE TRUCK BROKE DOWN AROUND JUNE JULY OF2014. I'VE BEEN PAYING FOR STORAGE PLUS MONTHLY TRUCK PAYMENT. THIS…
Jul 8, 2014
Engine
THE TRUCK HAS NOT RUN PROPERLY SINCE IT WAS PURCHASED, AND THE MOTOR WAS REPLACED BACK IN 2013 WITH MILEAGE OF 31,00 DUE TO OIL BEING SPLATTERED ALL OVER AND NO POWER. WE HAD SPEND OVER 10,000.00 TO FIX THE DEFECTIVE ISSUES. NOW ALMOST 2 YEARS TO THE DAY THE ENGINE HAS AGAIN FAILED. FORD OFFERS NO HELP OR EXPLANATIONS AS TO WHY THIS CONTINUES TO HAPPEN.. *TR
Jan 8, 2013 · 31,871 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.