Model year record
2002 Ford Ford Truck recalls & problems
The 2002 Ford Ford Truck has no safety recalls on file with NHTSA, and 37 owner complaints. The most-reported problem area is power train (17 complaints).
Safety recalls
No safety recalls have been filed for the 2002 Ford Ford Truck.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Power trainAutomatic transmission; Driveline › Differential unit | 17 | 59,000 mi |
| SuspensionFront; Front › Control arm › Lower ball joint | 8 | 65,700 mi |
| StructureBody › Hatchback/liftgate; Body › Door | 7 | 61,272 mi |
| Seat beltsFront › Buckle assembly; Front › Webbing | 3 | — |
| TiresTread/belt | 3 | — |
| Vehicle speed controlCruise control | 3 | — |
| Air bagsFrontal › Sensor/control module | 3 | — |
| Engine | 2 | — |
| Equipment | 1 | — |
| Latches/locks/linkagesHatchback/liftgate › Lock | 1 | — |
| Engine and engine coolingEngine | 1 | — |
| Wheels | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Seat belts › Front › Buckle assembly
The contact owns a 2002 Ford Think Neighbor. The contact stated that after entering the vehicle and attempting to secure the front driverâs seat belt latch into the buckle, the seat belt latch failed to lock into place. The seat belt loosened and unlatched from the buckle while the contact was driving. The contact stated that the failure was intermittent. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 20,000.
- Engine
FORD F 250 TRITON V10 NO. 2 SPARK PLUG AND COIL BLEW OUT OF THE ENGINE HEAD. APPARENTLY THIS IS A COMMON PROBLEM WITH THIS MODEL AND OTHERS. FORD WILL CHARGE 650.00 TO FIX. *TR
- Engine
FORD F 250 TRITON V10 NO. 2 SPARK PLUG AND COIL BLEW OUT OF THE ENGINE HEAD. APPARENTLY THIS IS A COMMON PROBLEM WITH THIS MODEL AND OTHERS. FORD WILL CHARGE 650.00 TO FIX. *TR
- Suspension › FrontCrash
WHILE GOING AROUND A HAIRPIN TURN THE DRIVER SIDE FRONT TIRE FELL OFF ROTOR AND ALL, THIS INCIDENT CAUSED THE 2002 FORD LIGHTNING TRUCK TO SLIDE INTO THE CURB CAUSING THE TRUCK TO ROLL COMPLETELY OVER LANDING BACK ON IT'S 3 TIRES THAT WERE LEFT. FROM THE LOOK OF IT THE AXLE BOLT FELL OFF CAUSING THE TIRE TO FALL OFF. DRIVER WAS GOING UNDER THE SPEED LIMIT & NO OTHER VEHICLES WERE INVOLVED. ACCORDING TO A FRIEND THIS SAME INCIDENT HAPPENED TO HIS LIGHTNING TRUCK. SOUNDS LIKE A DEFECT ON FORDS PART. *TR
- Power train › Automatic transmission
AUTOMATIC TRANSMISSION SLIPPING AND HARD BANG WHEN IT GO INTO GEAR. FORD SERVICE DEPT.DIAOGNOSE TRANS OP, NO CODES,LINE PRESSURE TEST.R110-N-75 OD95 L-95. R&R TRANSMISSION PAN FOR INSPECTION, PIECES OF BRASS BUSHINGS IN PAN. R&R TRANS TO OVERHAUL. REPLACED OD PLANETARY ASSY .BUSHINGS BETWEEN GEARS COME APART) FLUSHED COLLING LINES,REPLACED CONVERTER(METAL CONTAMINATION.) REPLACED VALVE BODY(VALVES STICKING). CLEARED PCM MEMORY & REFLASHED PCM. ROAD TEST. ALL THE ABOVE WORK WAS DONE ACCORDING TO THE INVOICE. WHEN I DROVE THE TRUCK I COULD HEAR A NOISE THAT WASN'T THERE BEFORE, I TOOK THE TRUCK BACK TO THE DEALER AND CHECKED THINGS OUT AND TOLD ME EVERY THING WAS FINE, BUT IT WASN'T. *TR
- Structure › Body › Hatchback/liftgate
2002 FORD EXPLORER VERY COLD NIGHT NOTICED A HUGE CRACK IN THE REAR PANEL BELOW REAR WINDOW RIGHT OUT OF NOWHERE THE CAR WAS FINE HOURS BEFORE AND AS I WALKED PAST IT AGAIN SAW A HUGE CRACK BY THE EMBLEM AND UNDER.*CN
- Power train › Automatic transmission › Gear position indication (prndl)
DRIVING MY VEHICLE WITH MY 2 CHILDREN 2 AND 10 YEAR. DROPPING THE 2 YEAR OLD OFF TO SCHOOL. STOP THE VEHICLE GO TO PUT THE SHIFT GEAR INTO PARK, BREAKS RIGHT OFF IN HAND, IF THE RUBBER WASN'T AROUND IT, I COULD HAVE WALKED OUT OF THE CAR WITH IT. I WAS STUCK THERE KEEPING MY FOOT ON THE BRAKES BECAUSE THE GEAR WAS ALSO STUCK BETWEEN REVERSE AND PARK. *TR
- Power train › Automatic transmission
TRANSMISSION TAKES 3-5 SECONDS TO GO INTO REVERSE THIS IN ITS SELF DANGEROUS WHEN NEEDING A QUICK REVERSE. THE MAIN REASON FOR A COMPLAINT IN TRANSMISSION NEEDING TO BE REBUILT AFTER ONLY 45,000 I DON'T TOW ANYTHING AND AM A GOOD DRIVER I KNOW OTHERS WITH SAME VEHICLE SAME PROBLEM TAKE NOTE UHAUL WILL NOT RENT TO EXPLORER OWNERS BECAUSE OF THE PROBLEMS WITH THIS TRANSMISSION (CALL UHAUL AND FIND THIS OUT). *TR
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.