1997 Honda Passport recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Unknown or other

  IN 2015 I BOUGHT A 1997 HONDA PASSPORT FROM SOMEBODY AND NOTICED THE FRAME HAS EXTREME ROT AND ITS SO BAD IT ROTTED A FUEL LINE CAUSING A LEAK NOW, I OWNED A 1995.5 ISUZU RODEO WITH EXCESIVE FRAME ROT AS WELL TO WHERE THE FRAME BROKE IN HALF WHILE DRIVING. THESE FRAMES USED IN ALL OF THE ISUZU RODEOS AND HONDA PASSPORTS AREN'T TREATED PROPERLY BEFORE THEY WERE RELEASED TO THE PUBLIC, THERE ARE HOLES IN THE FRAME AS LONG AS A FOOT, THESE NEED TO BE ADDRESSED ASAP BEFORE SOMEONE GETS KILLED OR INJURED BECAUSED OF IT, I HAVENT BEEN ABLE TO DRIVE THE VEHICLE YET DUE TO THIS FACT OR THE BREIF MOMENTS I DO DRIVE IT I FEEL AS IF ITS GOING TO BREAK IN HALF. IT WONT LET ME PUT THE MILEAGE IT HAS…

  Jul 6, 2015
• Suspension

  FRAME HAS RUSTED THROUGH IN LEFT REAR AREA NEAR LEAF SPRING HANGER. SHOULD THE FRAME FAIL IN THIS AREA, THE AXLE WILL NO LONGER BE SECURED TO THE VEHICLE. THIS APPEARS TO BE A COMMON PROBLEM WITH THIS VEHICLE. A RECALL HAS BEEN MADE FOR YEARS STARTING 1998 OF THE SAME VEHICLE WITH THE SAME PROBLEM. *TR

  Apr 1, 2015 · 160,000 miles
• Structure › Frame and members › Underbody shields

  1997 HONDA PASSPORT WITH 122,000 MILES. THE INTERIOR AND EXTERIOR LOOKS LIKE NEW. BUT THE FRAME IS SO RUSTED THROUGH I AM AFRAID TO DRIVE IT. FROM ALL OF THE STORIES I HAVE SEEN WHY WAS THEIR NOT A RECALL ON THE HONDA PASSPORT AND ISUZU RODEO? ARE THEY WAITING FOR PEOPLE TO DIE? *TR

  Oct 14, 2014 · 122,000 miles
• Structure › Frame and members › Underbody shields

  THE FRAME HAS RUSTED THROUGH IN THE REAR OF THE VEHICLE CAUSING THE LEAF SPRING IN THE BACK TO FALL DOWN. MY REAR END IS NO LONGER HELD IN PLACE AND CAN FALL OUT FROM THE REAR OF THE VEHICLE. MY CAR IS NO LONGER DRIVABLE. IT'S A 97 HONDA PASSPORT. OTHER WISE MY VEHICLE IS IN EXCELLENT CONDITION INSIDE AND OUT WHICH MAKES ME SICK TO KNOW THAT THE FRAME IS GONE. *TR

  Jan 4, 2012
• Service brakes, hydraulic

  WHEN CHANGING THE BRAKES I NOTICED A LOT OF SURFACE RUST WHEN I INSPECTED FURTHER I FOUND TWO HOLES IN FRAME ONE ON THE FRONT PASSENGER SIDE BEHIND THE WHEEL AND THE SECOND IN THE REAR ON THE DRIVERS SIDE INFRONT OF THE BACKSIDE OF THE LEAF SPRING SHACKLE THE HOLE IN THE BACK IS AS TALL OF THE FRAME RAIL AND ABOUT 10 INCHES LONG ONLY ON THE OUTSIDE OF THE FRAME THE HOLE IN THE FRONT IS ONLY A FEW INCHES TALL AND 6 INCHES LONG ON THE OUTSIDE OF FRAME AND STARTING ON THE BOTTOM OF FRAME RAIL THE VEHICLE IS UNSAFE BUT MY ONLY MEANS OF TRANSPORTATION I INSPECT IT DAILY TO CHECK FOR ANY DISFORMING OF THE FRAME. *TR

  Oct 3, 2011 · 125,000 miles
• Structure › Body

  TL* THE CONTACT OWNS A 1997 HONDA PASSPORT. THE CONTACT STATED THAT THE VEHICLE WAS BEING EXAMINED BY AN INDEPENDENT MECHANIC WHEN HE WAS INFORMED THAT THERE WAS SEVERE RUST AND CORROSION ON THE FRAME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 10V436000 (SUSPENSION:REAR). THE FAILURE AND CURRENT MILEAGES WERE 180,000.

  Dec 2, 2011 · 180,000 miles
• Fuel system, gasoline

  LEFT HOUSE AND PROCEEDED DOWNHILL ON GRAVEL DRIVEWAY AND THEN TURNED LEFT ONTO MAIN ROAD WHICH IS A HILL RISING APPROXIMATELY 200 FEET OVER .5 MILES. AT TOP OF HILL LET OFF ACCELERATOR BUT THE SPEED WAS STILL INCREASING. TAPPED ACCELERATOR, PULLED FLOOR MAT AWAY FROM GAS/BREAK PEDDLE AREA, TAPPED ACCELERATOR, WHOLE TIME DEPRESSING BREAK WITH BOTH FEET. FINALLY CUT OFF IGNITION AT APPROXIMATELY 55 MILES PER HOUR. I COASTED THE CAR BACKWARDS WITH ENGINE OFF AND TURNED IT AROUND. WHEN I RESTARTED CAR THE ENGINE WAS AT IDLE AND I DROVE IT HOME WITHOUT DEPRESSING ACCELERATOR. WHEN I CHECKED CAR AT HOME I OBSERVED THAT THE RUBBER THIMBLE COVERING THROTTLE CABLE AT THROTTLE WAS DETERIORATED. I…

  Sep 11, 2011 · 166,340 miles
• Structure › Frame and members

  EXCESSIVE RUSTING ON STEEL CHASSIS OF 1997 HONDA PASSPORT TO THE POINT WHERE IT IS UNSAFE TO DRIVE VEHICLE. HONDA HAS RECALL ON '98 AND ABOVE FOR FRAME RUST ISSUES BUT NOT ON 95-97 MODELS. IF THIS VEHICLE IS IN AN ACCIDENT WHERE IT IS HIT BROADSIDE FROM PASSENGER SIDE, THE FRAME IS SO RUSTED (CAN PUT WHOLE FIST INTO IT) THAT IT WILL MOST LIKELY SPLIT THE CAR IN HALF. HONDA WANTS TO CHARGE ME A DIAGNOSTIC FEE TO DETERMINE IF THEY ARE WILLING TO DO ANYTHING WITH THE VEHICLE. OBVIOUSLY, OTHERS HAVE EXPERIENCED THE SAME ISSUE (NHTSA'S INTERNAL REFERENCE NUMBER : 10262212 ). WHERE THIS GENTLEMAN SEEMED TO BE ORIGINAL OWNER REFERENCING NO OFFROADING HISTORY, I CANNOT VOUGE SINCE I JUST BOUGHT THE…

  Jun 15, 2011 · 176,843 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.