*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Structure
The contact owns a 1999 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, the rear subframe fractured near the axle. The vehicle was taken to an independent mechanic who diagnosed that the subframe was corroded and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 145,000.
Mar 22, 2022 · 145,000 milesStructure › Body
I STARTED HEARING A BANGING/CLANGING NOISE UNDER THE REAR OF THIS VEHICLE UPON STARTING/STOPPING OR REVERSING. THE NOISE IS BEST DESCRIBED AS A SHARP METALLIC CLANG. UNDERCAR INSPECTION REVEALED THE FRAME HAS CORRODED TO THE POINT THE UPPER CONTROL ARM MOUNTS HAVE PULLED AWAY FROM THE FRAME AND THE TRACK BAR THAT LOCATES THE AXLE SIDE-TO-SIDE HAS SEPARATED FROM THE REAR AXLE HOUSING ALONG WITH THE UPPER CONTROL ARM MOUNT SEPARATING FROM THE AXLE HOUSING. REPAIR OF THIS VEHICLE REQUIRES REPLACEMENT OF THE FRAME ALONG WITH REPLACEMENT OF THE COMPLETE REAR SUSPENSION AND AXLE HOUSING. THIS SAME VEHICLE WAS REPORTED TO YOU 03 NOVEMBER 2016 FOR THE SAME ISSUE INVOLVING THE CENTER SECTION OF THE…
Oct 15, 2019 · 197,000 milesStructure › Body
FRAME ROTTED FROM RUST WHERE THE REAR SUSPENSION ATTACHES TO THE FRAME. TOO MUCH RUST TO REPAIR. REMAINING VEHICLE IS IN GOOD SHAPE CONSIDERING ONLY 107K MILES. SUSPENSION BROKE FREE FROM THE FRAME DURING NORMAL ROAD OPERATION. I AM TOLD THAT THE PROBLEM IS EPIDEMIC WITH JEEP TJ FRAMES. APPARENTLY SO BECAUSE THERE IS NOTING AVAILABLE ON THE USED PARTS MARKET. LOTS OF TJ BODIES AND PARTS AVAILABLE BUT NO FRAMES TO GO ALONG WITH THEM.
Jul 8, 2019 · 107,000 milesStructure › Body
JEEP IS A 5 SPEED TRANSMISSION. COULDN'T SHIFT CORRECTLY, HEARD A RATTLE. ENGINE HAD FALLEN DUE TO RUSTING FRAME. FRAME SO RUSTED, ENGINE FELL. ONLY 90,000 MILES ON VEHICLE. NOT DRIVEN DAILY. WAS IN MOTION.
Mar 19, 2019 · 90,000 milesStructure › Body
TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. WHILE CHANGING THE REAR DRIVER SIDE TIRE, IT WAS DISCOVERED THAT THE SPARE TIRE HUB WAS EXTREMELY CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN ANY OPEN RECALLS. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 25,001.
Oct 20, 2017 · 25,001 milesElectrical system
FUEL- JEEP HARD TO FILL WITH FUEL OR MUST FILL FUEL AT VERY SLOW RATE. NOZZLE DOES NOT LOCK OR FILL PROPERLY. (STATIONARY) ELECTRICAL- HAZARD LIGHTS(IN REAR) RANDOMLY TURN ON BY THEMSELVES WHILE DRIVING. (ANY MPH, CITY STREETS AND HIGHWAYS)
Jul 17, 2017 · 126,000 milesVisibility › Defroster/defogger/hvac system › Fan/motor
TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. WHILE DRIVING APPROXIMATELY 50 MPH OVER A BUMP IN THE ROAD, THE BLOWER MOTOR FAILED TO FUNCTION. THE INSTRUMENT PANEL WARNING INDICATORS ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Jun 9, 2015 · 150,000 milesStructure › Body
JEEP WRANGLER (TJ BODY) 1999 FRAME RUST I WAS DRIVING THE VEHICLE AT INTERSTATE (68-72MPH) SPEEDS WHEN A SEVERE VIBRATION STARTED SUDDENLY AND THE MANUAL TRANSMISSION SHIFT LEVER DROPPED TO A LOWER THAN NORMAL POSITION. I PULLED OFF IN A SAFE AREA AND INSPECTED FIRST FOR A FLAT TIRE AND THEN LOOKED UNDER THE VEHICLE. I NOTED THE RIGHT FRAME RAIL HAD RUSTED THROUGH FROM THE INSIDE AND THE TRANSMISSION-TRANSFER CASE MOUNT/SKID PLATE ASS'Y HAD SEPARATED FROM THE RIGHT (PASSENGER SIDE FRAME RAIL AND DROPPED APPROX. 2-3 INCHES. THIS CAUSED SEVERE DRIVELINE VIBRATION AND ERRATIC VEHICLE CONTROL. *TR
Oct 22, 2016 · 176,000 miles
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
