Model year record

2000 Lincoln Navigator recalls & problems

The 2000 Lincoln Navigator has 7 safety recalls and 109 owner complaints on file with NHTSA. The most-reported problem area is tires (44 complaints).

Recalls7safety recalls

Complaints109filed by owners

Crashes · fires9 · 17reported in complaints

Injuries · deaths6 · 0reported in complaints

Safety recalls

Exterior lightingApr 7, 2009

Exterior lighting

Recall 09E01200016,270 vehiclesopened after NHTSA action (OVSC)

Problem: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Fix: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Exterior lightingJul 17, 2006

Exterior lighting

Recall 06E0640004,029 vehiclesopened after NHTSA action (OVSC)

Problem: CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Fix: TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

Fuel system, gasolineJun 13, 2006

Fuel system, gasoline

Recall 06E05600058,640 vehicles

Problem: CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Risk: FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Fix: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

Vehicle speed controlSep 7, 2005

Vehicle speed control

Recall 05V3880004,500,000 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
Risk: A FIRE AT THE SWITCH COULD OCCUR.
Fix: BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)

Vehicle speed controlJan 27, 2005

Cruise control

Recall 05V017000738,490 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
Risk: THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
Fix: AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)

VisibilityAug 8, 2001

Windshield wiper/washer › Motor

Recall 01V2580001,083,000 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Risk: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Fix: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

Trailer hitchesMar 7, 2000

Trailer hitches

Recall 00V073000565,800 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES. THE TRAILER HITCH ASSEMBLY TO THE FRAME ATTACHING BOLTS COULD LOSE THE CLAMP LOAD.
Risk: THE TRAILER HITCH COULD THEN SEPARATE FROM THE VEHICLE.
Fix: DEALERS WILL REPLACE THE TRAILER HITCH MOUNTING BOLTS AND NUT PLATES.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2000 Lincoln Navigator 4 DR. 4X4

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Navigator 2WD

13mpg combined

City / highway	11 / 16 mpg
Fuel	Premium Gasoline

5.4 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $6,300/year to fuel

Navigator 4WD

13mpg combined

City / highway	11 / 15 mpg
Fuel	Premium Gasoline

5.4 L · 8 cyl · Automatic 4-spd · 4-Wheel or All-Wheel Drive · about $6,300/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
TiresTread/belt; Sidewall	44	1	0	2	46,750 mi
Electrical systemWiring › Front underhood; Ignition › Module	13	0	7	0	85,250 mi
Power trainAutomatic transmission; Automatic transmission › Park/neutral start interlock switch	11	2	0	0	—
Air bagsFrontal; Frontal › Sensor/control module	9	2	0	3	85,000 mi
SuspensionFront; Rear › Springs › Air suspension system	9	1	0	2	54,000 mi
Vehicle speed controlCruise control	9	3	5	1	73,750 mi
SteeringLinkages › Tie rod assembly; Steering wheel/handle bar	8	4	0	6	44,500 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Disc	7	2	1	0	—
Engine and engine coolingEngine › Gasoline	7	0	2	0	120,000 mi
StructureFrame and members; Body › Bumpers	6	2	1	3	90,000 mi
VisibilityPower window devices and controls; Windshield wiper/washer › Motor	4	0	1	0	—
Parking brakeConventional › Mechanical › Linkage and cable	2	1	0	2	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Structure › BodyCrash1 injury
ON OCTOBER 4, 2017 AT APPROXIMATELY 3:45 PM, I DEPARTED FROM THE SACRAMENTO CHILDREN'S HOME THROUGH AN ADJACENT ALLEY TRAVELING THROUGH THE SOUTH BOUND ENTRANCE. AS I MADE THE LEFT TURN INTO THE ALLEY AS I GRADUALLY GOT UP TO SPEED MY VEHICLE SUDDENLY BEGAN TO ACCELERATE. I WAS STARTLED BY THE SUDDEN INCREASE OF SPEED AND IMMEDIATE MADE AN ATTEMPT TO PUT THE VEHICLE IN NEUTRAL AND SHUT THE VEHICLE DOWN AND APPLY THE BRAKES. BEFORE I COULD MAKE THE CORRECTIONS THE VEHICLE HAD VEERED OFF TO THE LEFT HAND SIDE OF THE ALLEY AND STRUCK AN OAK TREE. TO MY GUESS THE VEHICLE WAS TRAVELING AT A RATE OF SPEED OF ABOUT 25-30 MPH. ON IMPACT I SLAMMED INTO MY MOTOROLA SPEAKER THAT WAS ATTACHED TO MY SUN…
Oct 4, 2017 · 290,000 miles
Electrical system
TL* THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. WHILE DRIVING 65 MPH SPEED AND TAKE YOUR FOOT OF THE GAS PEDAL AND CAR CONTINUES TO GO 65 MPH ALL OF SUDDEN NO POWER STEERING OR POWER BRAKES. IN ADDITION, THE CONTACT STATED THAT THE ELECTRICAL SYSTEM FAILED TO OPERATE INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000. THE CONSUMER STATED THE VEHICLE CONTINUED TO GO 65 MPH, EVEN WHEN HE REMOVED HIS FOOT FROM THE ACCELERATOR. THE RPM METER AND THE MOTOR SPEED DROPPED DOWN TO 500 RPM AND THE ENGINE SHUT OFF. THERE WAS NO POWER STEERING AND NO POWER BRAKES, BUT THE VEHICLE CONTINUED GOING 65 MPH. ALSO, THE…
Jan 1, 2017 · 115,000 miles
Visibility/wiper
VEHICLES WIPERS WILL NOT CUT OFF. WIPER MOTOR SMOKES BAD FROM UNDER HOOD.
Aug 4, 2016
Air bags
TL* THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE VEHICLE STARTED SHAKING. THE VEHICLE WAS TAKEN TO THE DEALER, WHO APPLIED PINS ON THE SUSPENSION AND REPLACED THE TIRES BUT THE FAILURE RECURRED. THE CONTACT ALSO STATED THAT THERE WAS A CRACK ON THE WHEELS THAT CAUSED THE BOLT JOINTS TO FAIL. THE CONTACT ALSO STATED THAT THE AIRBAG WARNING LIGHT WAS ILLUMINATED AND THE AC AND HEAT WAS INOPERABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.
Jul 6, 2004 · 124,000 miles
Unknown or otherFire
VEHICLE WAS PARKED AND TURNED OFF WHEN IT SUDDENLY EXPLODED. *TT
Mar 20, 2014 · 175,000 miles
EngineFire
DROVE CAR TODAY AND IT HAD BEEN SITTING PARKED FOR 5 HOURS . NEIGHBORS CALLED MY CELL TO TELL ME THE TRUCK WAS ON FIRE AND THE FIRE DEPARTMENT HAD BEEN CALLED TO TRY TO PUT IT OUT . THE FIRE DEPARTMENT HAD TO CHAINSAW THE HOOD AND THEY WERE FINALLY ABLE TO PUT IT OUT WITHOUT THE FIRE DESTROYING THE PASSENGER COMPARTMENT. THE TRUCK HOWEVER HAD BURNED FOR ABOUT 15 MINUTES IN THE ENGINE COMPARTMENT . THIS TRUCK HAD SELF STARTED ITS OWN FIRE BEING LEFT ALONE IN THE DRIVEWAY FOR 5 HOURS . *TR
Aug 17, 2013 · 145,000 miles
Vehicle speed controlFire
TL* THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO BE REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 05V388000 (VEHICLE SPEED CONTROL) BUT THE VEHICLE STILL HAD A PROBLEM WITH THE WIRING. THE CONTACT ALSO STATED THAT THERE WAS A BURNING WIRE ODOR. THE DEALER STATED THERE WAS NO PROBLEM WITH THE VEHICLE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS UNAVAILABLE. THE CURRENT MILEAGE WAS 127,000. *TR
Nov 7, 2005
Engine and engine coolingFire
TL* THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. THE CONTACT STATED THAT THE ENGINE COMPARTMENT IGNITED IN FLAMES WITHOUT WARNING. THE FIRE DEPARTMENT WAS CONTACTED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE CAUSE OF THE FIRE WAS UNKNOWN TO THE CONTACT. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 157,000.
May 1, 2012 · 157,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

SPARK PLUG EJECTION FROM CYLINDER HEADClosed
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY…
DP05005 · opened Sep 22, 2005 · closed Jan 4, 2006
SPEED CONTROL DEACTIVATION SWITCH FIREClosedLed to recall 05V017000
IN ITS LETTER DATED JANUARY 27, 2005 TO ODI, FORD INDICATED THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL # 05V-017) TO REMEDY AN OVERHEATING SPEED CONTROL DEACTIVATION SWITCH IN APPROXIMATELY 738,490 SUBJECT VEHICLES.THE VEHICLES AFFECTED BY THE RECALL ARE CERTAIN 2000 MODEL YEAR (MY) FORD F150, FORD EXPEDITION AND LINCOLN NAVIGATOR EQUIPPED WITH SPEED CONTROL AND CERTAIN 2001 MODEL YEAR F150 SUPERCREW VEHICLES BUILT THROUGH AUGUST 7, 2000.SINCE OPENING PE04-078, ODI HAS IDENTIFIED OTHER REPORTS OF KEY OFF ENGINE COMPARTMENT FIRES IN FORD VEHICLES WITH SIMILAR SPEED CONTROL DEACTIVATION SWITCHES THAT WERE NOT THE SUBJECT OF THIS PRELIMINARY EVALUATION OR FORD'S RECALL 05V-017.FORD'S RESPONSE TO THE ODI INFORMATION REQUEST LETTER DATED DECEMBER 3, 2004, PROVIDED AN ADDITIONAL 107 ALLEGATIONS OF KEY OFF ENGINE COMPARTMENT FIRES THAT WERE ALSO IN VEHICLES NOT SUBJECT TO THIS…
PE04078 · opened Nov 19, 2004 · closed Mar 22, 2005