Model year record

1999 Lincoln Town Car recalls & problems

The 1999 Lincoln Town Car has 6 safety recalls and 148 owner complaints on file with NHTSA. The most-reported problem area is air bags (29 complaints).

Recalls6safety recalls

Complaints148filed by owners

Crashes · fires18 · 7reported in complaints

Injuries · deaths14 · 0reported in complaints

1999 Lincoln Town Car in an NHTSA crash test — NHTSA crash test

Safety recalls

SteeringOct 6, 2015

Steering

Recall 15E0820001,767 vehicles

Problem: Dorman Products, Inc. (Dorman) is recalling certain model Dorman Steering Shafts, part number 425-359, Solutions Steering Shafts, part number 7-0359, and OE Solutions Steering Shafts, part number 425-359, manufactured April 17, 2014, to September 28, 2015. These aftermarket replacement steering shafts are sold for use in 1995-2002 Ford Crown Victoria, Mercury Grand Marquis, and Lincoln Town Car vehicles. These steering shafts may separate during operation if the integral fastener is loose or missing and if the interfacing vehicle shaft is compressed in length.
Risk: If the shafts separate during vehicle operation, a loss of steering control would result, increasing the risk of a vehicle crash.
Fix: Dorman will notify owners, and dealers will replace the steering shaft, free of charge. The recall began on October 28, 2015. Owners may contact Dorman customer service at 1-800-523-2492, option 5.

TiresDec 12, 2000

Tires

Recall 00V35600010,000 vehicles

Problem: VEHICLE DESCRIPTION: CERTAIN LIMOUSINES STRETCHED OVER 60 INCHES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 109, "NEW PNEUMATIC TIRES," AND NO. 110, "TIRE SELECTION AND RIMS."
Risk: THE VEHICLE WEIGHT COULD EXCEED THE MAXIMUM LOAD RATING FOR THE TIRE, INCREASING THE RISK OF PREMATURE TIRE WEAR OR BLOWOUT.
Fix: DEALERS WILL REPLACE ALL 5 TIRES (INCLUDING THE SPARE TIRE) WITH MICHELIN TIRES (225/70R16 107T REINFORCED WHITE SIDEWALL) WITH A SUFFICIENTLY HIGHER LOAD RATING. OWNER NOTIFICATION BEGAN JANUARY 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-248-0186.

EquipmentJul 18, 2000

Mechanical › Integrated jack/leveler/stabilizer

Recall 00V200000875,000 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES HAVE JACKING INSTRUCTIONS WHICH, IF FOLLOWED, COULD CAUSE THE VEHICLE OPERATOR TO PLACE THE JACK ON A FRAME WELD WHEN ATTEMPTING TO RAISE A REAR WHEEL. IF THE VEHICLE IS JACKED UP WITH THE JACK PLACED ON THE FRAME WELD AND IF THE VEHICLE IS FREE TO ROLL (WHEELS NOT BLOCKED OR CHOCKED), THE JACK COULD YIELD AND THE VEHICLE MAY DROP SUDDENLY.
Risk: IF THIS OCCURS AND ANY PORTION OF THE OPERATOR'S BODY IS UNDER THE VEHICLE, THE POTENTIAL FOR PERSONAL INJURY EXISTS.
Fix: OWNERS WILL BE PROVIDED WITH A REVISED JACK INSTRUCTION AND STOWAGE CARD AND JACK WARNING LABEL, AS WELL AS A SUPPLEMENT TO THE OWNER GUIDE.

Seat beltsJun 12, 2000

Front › Anchorage

Recall 00V1570011,167 vehiclesopened after NHTSA action (OVSC)

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET DRIVER'S SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.
Risk: IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.
Fix: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.

Seat beltsJun 12, 2000

Front › Anchorage

Recall 00V1570021,129 vehiclesopened after NHTSA action (OVSC)

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET FRONT PASSENGER SIDE SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.
Risk: IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.
Fix: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.

SuspensionDec 16, 1998

Front › Control arm › Lower ball joint

Recall 98V322000175,000 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.
Risk: IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
Fix: DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

1999 Lincoln Town Car 4-DR. w/SAB

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Town Car

18mpg combined

City / highway	15 / 22 mpg
Fuel	Regular Gasoline

4.6 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,700/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Air bagsSide/window; Frontal	29	12	0	13	100,762 mi
SuspensionFront › Control arm › Lower ball joint; Front	24	1	0	0	100,000 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Disc › Rotor	21	2	1	1	48,500 mi
VisibilityWindshield; Rearview mirrors/devices › Exterior	18	2	1	2	94,412 mi
StructureBody › Door; Body	16	1	0	0	50,000 mi
SteeringLinkages › Tie rod assembly; Steering wheel/handle bar	15	2	1	0	85,000 mi
Electrical systemWiring; Wiring › Front underhood	14	1	4	0	72,988 mi
Engine and engine coolingExhaust system › Manifold/header/muffler/tail pipe; Cooling system	13	0	0	0	105,750 mi
Power trainAutomatic transmission; Axle assembly	7	0	0	0	—
Unknown or other	6	0	1	0	157,812 mi
Vehicle speed controlLinkages; Cruise control	5	2	0	1	—
EquipmentAppliance › Air conditioner; Electrical	5	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Suspension
See attached document for complaint.
Nov 18, 2018
Seat belts
Front driver seatbelt does not lock. Unknown when or why this occurred. All other seatbelts in car still functioning. Not repaired yet. Would this be covered under any type of federal warranty?
Apr 26, 2023
Steering
The contact owns a 1999 Lincoln Town Car. The contact stated while driving approximately 55 MPH, the steering wheel started pulling to the left with extreme force. The contact attempted to correct the over steering and the vehicle started pulling to the right and the left. The contact stated that an unknown warning was illuminated. The contact drove the vehicle back to his residence. The contact stated that he drove the vehicle several more times and the steering failure recurred while driving at various speeds. The contact drove the vehicle to an independent mechanic to be diagnosed. The contact was informed that the ball joints, upper and lower control arms, and the steering gear needed…
Dec 13, 2020 · 132,000 miles
Structure › BodyCrash
TL* THE CONTACT OWNS A 1999 LINCOLN TOWN CAR. THE CONTACT STATED THAT WHILE DRIVING THE CONTACT FELT THE BRAKES WERE NOT WORKING PROPERLY. THE CONTACT MADE A RIGHT HAND TURN AND CRASHED INTO A PARKED TRUCK. THE CONTACT DID NOT HAVE AN INJURY THAT REQUIRED TRANSPORT TO A HOSPITAL AND NO POLICE REPORT WAS FILED. THE CRASH HAPPENED RIGHT AT THE INDEPENDENT MECHANIC'S SHOP. THE INDEPENDENT MECHANIC FIXED THE BRAKES WITH A FLUID LEAK FROM THE BRAKE LINE AS THE CAUSE OF THE MALFUNCTION. THE CONTACT FELT THERE ALSO WAS AN ISSUE OF THE FRONT END OF THE VEHICLE BEING OUT OF ALIGNMENT THAT CAUSED THE VEHICLE TO DRIFT TO ONE SIDE. THE ISSUE RECURRED WITH THE FRONT END STILL BEING OUT OF ALIGNMENT WITH…
Dec 1, 2020 · 200,000 miles
Suspension
TL* THE CONTACT OWNS A 1999 LINCOLN TOWN CAR. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN, THE CONTACT HEARD AN ABNORMAL SOUND COMING FROM THE FRONT DRIVER'S SIDE WHEEL. THE CONTACT STATED THAT THE WHEEL DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE DRIVER'S AND PASSENGER'S SIDE FRONT UPPER CONTROL ARMS AND BALL JOINTS WERE REPLACED. THE CONTACT CALLED LAMARQUE FORD LOCATED AT 3101 WILLIAMS BLVD SUITE F, KENNER, LA 70065, (504) 443-2500, AND MADE THE DEALER AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 54,000.*DT *AS
Jun 16, 2020 · 54,000 miles
Engine
TL* THE CONTACT OWNS A 1999 LINCOLN TOWN CAR. THE CONTACT STATED WHILE DRIVING AT AN UNDISCLOSED SPEED, THE CONTACT BECAME AWARE OF NOTICED LIQUID DRIPPING FROM THE AIR VENTS. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC FOR DIAGNOSIS AND REPAIR. THE DIAGNOSIS WAS A FAILURE WITH THE INTAKE MANIFOLD. THE DEALER WAS NOT CONTACTED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Jan 8, 2020 · 150,000 miles
Structure › Body
TAKATA RECALL: STEERING WHEEL HAS SMOKED BEFORE LIGHTLY, INTERIOR LIGHTS HAVE STAYED ON,STEERING WHEEL HAS DONE A 360 TURN,CORROSION ON THE SIDE PANEL AND PANEL(CHROME) HAS FALLEN OFF. I'M NOT SURE HOW LATE A RECALL TIME FRAME IS BUT MY CAR HAPPENS TO BE VERY OLD NOW SO I'M WONDERING IF THIS IS THE CASE I HAVE PICTURES FROM WHAT THE CAR LOOKED LIKE AND UP TO NOW ALSO MY CAR IS NOW AT 366.'- MILES SO THIS MAY NOT EVEN BE SOMETHING TO BE TURNED IN, THIS STATE HAS ALSO DONE SO MUCH DAMAGE FROM THE POTHOLES..
Jan 4, 2016 · 200 miles
Fuel/propulsion systemFire
I WAS DRIVING DOWN A PUBLIC STREET NOT EVEN GOING THE SPEED LIMIT AND I CAME TO THE STOP LIGHT MY CAR ACTED LIKE IT DIDN'T WANNA GO I GOT IT TO A PARKING SPOT AND IT BURST TO A BALL OF FLAMES I HAD NO PREVIOUS SYMPTOMS AND THE CAR WAS DRIVING FINE IT HAD JUST GOTTEN TO HALFWAY MARK ON MY HEAT GAUGE. I THINK IT MAY HAVE BEEN THE PLASTIC INTAKE MANIFOLD MELTED MAYBE? ANY WAYS THOUGHT I WOULD REPORT THAT THIS IS ACTUALLY A VERY DANGEROUS THING IT ALMOST BURNT ME ALIVE GOING DOWN THE ROAD AND THEN ALMOST BURNT A BUSINESS DOWN AND I'M HOPING TO GET SOME SORT OF COMPENSATION BECAUSE NO ONE TOLD ME TILL JUST NOW. IF I COULD GET SOME INFO ON WHO TO CALL AT FORD THAT'D BE GREAT
Apr 13, 2019 · 161,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

SPARK PLUG EJECTION FROM CYLINDER HEADClosed
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY…
DP05005 · opened Sep 22, 2005 · closed Jan 4, 2006
INADVERTENT SIDE AIR BAG DEPLOYMENTClosed
ODI HAS IDENTIFIED 173 COMPLAINTS ALLEGING INADVERTENT OR NON-CRASH DEPLOYMENT OF SIDE AIR BAGS ON MODEL YEAR (MY) 1999-2003 LINCOLN TOWN CARS.MOST OF THE COMPLAINTS ALLEGE THAT ONE OF THE SIDE AIR BAGS DEPLOYED WHILE DRIVING WITHOUT ANY IMPACT.ANALYSIS SHOWED THAT MY 2001 THROUGH EARLY MY 2003 TOWN CARS HAVE MUCH HIGHER COMPLAINT AND WARRANTY CLAIM RATES (138 COMPLAINTS AND 120 WARRANTY CLAIMS) THAN THE REMAINING VEHICLES (35 COMPLAINTS AND 32 WARRANTY CLAIMS).FORD CHANGED ITS SUPPLIER OF THE SIDE CRASH SENSORS FOR THE MY 2001 TOWN CARS.FORD STATES THAT THE ALGORITHM IN THE MY 2001 TOWN CARS IS DIFFERENT FROM THE PREVIOUS MODEL YEAR'S DESIGN, AND THAT IT IS DESIGNED TO PROVIDE IMPROVED OCCUPANT PROTECTION IN MODERATE SPEED SIDE POLE IMPACTS.IN DECEMBER 2002 (I.E., EARLY MY 2003 VEHICLE PRODUCTION), THE CRASH SENSORS WERE MOVED FROM THE FLOOR OF VEHICLE TO NEAR THE BASE OF B-PILLARS IN…
PE03011 · opened Mar 14, 2003 · closed Aug 22, 2003
FUEL-FED FIRESClosed
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
DP02007 · opened Aug 22, 2002 · closed Dec 4, 2002
POST REAR END COLLISION FIRESClosedLed to recall 02I003000
There is no summary currently available
SQ01014 · opened Nov 27, 2001 · closed Oct 3, 2002