Model year record
2004 Lincoln Town Car recalls & problems
The 2004 Lincoln Town Car has no safety recalls on file with NHTSA, and 83 owner complaints. The most-reported problem area is vehicle speed control (19 complaints).
Safety recalls
No safety recalls have been filed for the 2004 Lincoln Town Car.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Crash test ratings
2004 Lincoln Town Car 4-DR. w/SAB
| Frontal crash | Not Rated |
|---|---|
| Side crash | Not Rated |
| Rollover | Not Rated |
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
Fuel economy
Town Car
| City / highway | 15 / 23 mpg |
|---|---|
| Fuel | Regular Gasoline |
4.6 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,700/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Vehicle speed controlCruise control; Accelerator pedal | 19 | 3,366 mi |
| Steering | 14 | 79,150 mi |
| StructureBody; Body › Door | 11 | 93,451 mi |
| Service brakes, hydraulicAntilock/traction control/electronic limited slip; Pedals and linkages | 9 | 1,525 mi |
| Electrical system12v/24v/48v battery | 8 | 105,000 mi |
| WheelsRim | 7 | 80,000 mi |
| Engine and engine coolingEngine | 4 | 19,875 mi |
| Exterior lighting | 4 | 204,000 mi |
| TiresSidewall | 3 | — |
| Fuel system, gasolineDelivery › Fuel pump; Fuel injection system › Injectors | 3 | 6,138 mi |
| Latches/locks/linkagesDoors › Latch | 3 | — |
| Unknown or other | 3 | 88,000 mi |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Exterior lighting
My car has the same lcm control module issues as cars from the same years ad models, but when I enter my VIN it is not showing. +4 PO#3 1998-2000 Lincoln Town Car Lighting Control Module YW1T ... Yes, a recall exists for a 2003-2005 model year Ford/Lincoln Town Car lighting control module (LCM) failure that can cause a loss of headlights. The recall, #15S39, involves dealers installing a bypass module kit to fix the problem for free. The issue stems from a cracked solder joint inside the LCM that can lead to intermittent or complete headlight failure, increasing crash risk at night. The lcm is under the dash near the pedals. It causes loud vibrating noise for a long time and causes a…
- Steering
Bought a 2004 Linc Tow as a gift to my grandson. Drove it a couple of times and had no issues. After it had sat for about 2-3 weeks, I drove it to town to let it run after sitting. On my way home I was turning on to the road for home and the steering suddenly caught, I was in the middle of a turn and pulled steering wheel to straighten the car when it released. I almost hit the car next to me. I have an appointment on October 14th to have it checked out. I understand that this is a problem that has occurred often in other years and was fixed, so why not the 2004. This car only has 92,500 miles on it. I can't risk my grandson getting into an accident.
- Steering
The steering is binding really bad. Noticed it yesterday while taking hubby to docs. Much worse today. Unable to pull into parking spaces, did not dare to try to pull up to pumps. Cornering was a challenge in either direction. We do not have any Ford garages in this area. Think this is a major issue that may go with Lincolns. had 2 other ones with similar issues. It is not too bad if rolling along, but almost impossible when going slow.
- Structure › Body
VEHICLE WAS PARKED OUTSIDE DURING RAIN SHOWERS AND WATER ACCUMULATED INSIDE THE REAR PASSENGER FOOT AREA 1ST AND OVERFLOWED INTO THE FRONT PASSENGER'S FOOT AREA.
- Steering
MY STEERING IS HARD TO TURN. VERY STIFF. BOUGHT IT USED AND I SEE THEY REPAIRED THE UPPER AND LOWER POWER STEERING SHAFT., ALL OTHER MODELS WERE BEING RECALLED FOR THIS PROBLEM. WHY NOT THIS YEAR? IT ONLY HAS 65,500 MILES
- Steering
I HAVE ONLY 20,118 ORIGINAL MILES ON MY 2004 LINCOLN TOWN CAR ULTIMATE. THE STEERING COLUMN UNDER THE HOOD IS TERRIBLY RUSTED. THE CORROSION LOOKS SCARY. I WANTED TO TAKE IT TO THE DEALER TO HAVE THEM TELL ME IF I NEEDED TO REPLACE IT! NOW, I WASN'T LOOKING FOR FORD TO PAY FOR ANYTHING BUT GET THIS - THEY WANT ME TO PAY THEM A $100 DIAGNOSTIC FEE JUST TO TELL ME IF I NEED TO REPLACE THE STEERING COLUMN! THE 2005 TOWN CAR IS BEING RECALLED FOR THE SAME THING YET FORD IS PAYING FOR THIS. WHAT RECOURSE DO I HAVE. I SEE NOW WHY THEY WANT TO CHARGE FOR THIS INSPECTION BECAUSE THEY KNOW THESE CARS WELL AND ARE AWARE OF THE CORROSION ISSUE WITH THEIR STEERING COMPONENTS. NOW THE I LOOK AT THE…
- Electrical system
TL* THE CONTACT OWNS A 2004 LINCOLN TOWN CAR. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE BATTERY DRAINED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE LIGHT CONTROL MODULE FAILED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 64,000.
- Vehicle speed control
OPERATOR EXPERIENCED STUCK SPEED CONTROL BUTTON AND ACCELERATED COULDN�T STOP THE SPEED ACCELERATION WITH STEERING WHEEL SO OPERATOR HIT BREAKS. LOUD BANG SOUND FOLLOWED BY DRASTIC REDUCED SPEEDS. COULD CAUSE LOSS OF CONTROL. RESULTED IN SPEEDING TICKET DURING FAILURE SPEEDS ALMOST UP TO 100MPH DURING EMERGENCY EVENT MODE.
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
- SPARK PLUG EJECTION FROM CYLINDER HEADClosed
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY…