Model year record
The 1996 Mercury Cougar has 2 safety recalls and 62 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (23 complaints).
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
| Frontal crash | Not Rated |
|---|---|
| Side crash | Not Rated |
| Rollover | Not Rated |
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
| City / highway | 17 / 24 mpg |
|---|---|
| Fuel | Regular Gasoline |
3.8 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,550/year to fuel
| City / highway | 15 / 23 mpg |
|---|---|
| Fuel | Regular Gasoline |
4.6 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,700/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Engine and engine coolingEngine; Exhaust system › Manifold/header/muffler/tail pipe | 23 | 80,000 mi |
| Service brakes, hydraulicFoundation components › Disc › Rotor; Foundation components | 6 | — |
| VisibilityWindshield; Windshield wiper/washer › Motor | 6 | — |
| Vehicle speed controlCables | 5 | — |
| StructureBody › Door; Body › Trunk lid | 5 | — |
| TiresTread/belt | 5 | — |
| Power trainAutomatic transmission; Automatic transmission › Gear position indication (prndl) | 4 | — |
| Seat beltsFront › Anchorage | 3 | — |
| SuspensionFront; Front › Control arm | 3 | — |
| Unknown or other | 3 | — |
| Fuel system, gasolineCarburetor system; Delivery | 3 | — |
| Electrical systemIgnition › Module; Ignition | 3 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
TL* THE CONTACT OWNS A 1996 MERCURY COUGAR. THE CONTACT STATED THAT THE CLIMATE CONTROL ADJUSTER FAILED. AS A RESULT, THE BLOWER WOULD ONLY FUNCTION ON HIGH AND THE CONTACT WAS UNABLE TO ADJUST THE DEFROST SYSTEM. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TO HAVE THE FAILURE DIAGNOSED, BUT THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 61,000 AND THE CURRENT MILEAGE WAS 62,000. THE VIN WAS UNAVAILABLE. UPDATED 05/24/12*LJ
TL * THE CONTACT OWNS A 1996 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING ANTI FREEZE ABNORMALLY. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS ADVISED THAT THE PLASTIC INTAKE MANIFOLD WAS FRACTURED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED TO REPORT THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 140,000.
TL*THE CONTACT OWNS A 1996 MERCURY COUGAR. THE CONTACT STATED THAT THE DRIVERS SIDE FRONT DOOR AND THE PASSENGERS SIDE FRONT DOOR WOULD OPEN WHILE DRIVING AT ANY SPEED. WHEN SHE CLOSED THE DOORS THEY COULD BE PUSHED OPEN WITH LITTLE EFFORT. FORD WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS. NHTSA CAMPAIGN ID NUMBER: 96V070000, LATCHES, LOCKS, LINKAGES, AND DOOR LATCH WAS, ISSUED FOR HER YEAR, MAKE AND MODEL VEHICLE. THE CONTACT WAS ADVISED OF THE 10 YEAR EXPIRATION PERIOD. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 114,000.
WHILE DRIVING MY 1996 COUGAR THIS PAST SEPTEMBER, WHICH HAS ONLY 40,360 MILES ON IT AND IS STORED MOST OF THE YEAR FOR THE PURPOSES OF COLLECTING AND PRESERVING THE VEHICLE INDEFINITELY, AT LOW SPEEDS I NOTICED THE OBVIOUS SIGN OF COOLANT AND THE SMELL OF COOLANT COMING FROM UP UNDER THE HOOD. I THEN SHUT THE VEHICLE DOWN RIGHT AWAY AND DISCOVERED COOLANT RUNNING ONTO THE GROUND BELOW. NOW, BEING OF AN EXPERIENCED NATURE WITH AUTOMOBILES AND USING CLOSE OBSERVATION OF THE PROBLEM IT APPEARED TO BE EMANATING FROM THE FRONT OF THE INTAKE MANIFOLD. I THEN DISCOVERED AFTER THE FACT THAT THESE 4.6 LITER ENGINES ARE NOTORIOUS FOR THIS INTAKE CRACKING PROBLEM, SO NOW I WILL BE PURCHASING AN…
MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE AGAINST THE FLOOR PAN. THIS WEAR CAN CAUSE A PIN HOLE IN THE FUEL LINE RESULTING IN FUEL LEAKAGE. RECALL # 97V159000 1992-93 MERCURY COUGARS...FORD RECALL LETTER TO YOU DATED 9-17-1997..MY COUGAR BUILT 4-'96...1996 WAS THE LAST YEAR FOR THIS CAR. ALL COUGARS 1992 TO 1996 SHOULD HAVE BEEN RECALLED, FOR THE CONVOLUTE COVERING PREVENTION TO BE INSTALLED AROUND THE FUEL LINES PER FORD RECALL LETTER 573.5 (C) (8) CAMPAIGN # 97S84. PURSUANT TO PART 573 OF TITLE 49 OF THE CODE OF FEDERAL REGULATIONS. *NM
1996 MERCURY COUGAR V6 3.8 LITER ENGINE. HEAD GASKET FAILURE. THIS ENGINE HAS NEVER OVERHEATED. ROUGHLY 80,000 MILES. $1200-1500 ESTIMATE FOR REPAIR. *NM
I WAS DRIVING AND SAW MY LOW COOLANT LIGHT WAS ON. PULLED INTO CAR PARTS COMPANY PARKING LOT. OPENED HOOD SAW COOLANT ON TOP OF MOTOR AND UNDERSIDE OF HOOD. COOLANT WAS LEAKING FROM FRONT OF THE INTAKE MANIFOLD. UPON INSPECTION REALIZED THE MANIFOLD IS MADE OF PLASTIC. I ATTEMPTED TO STOP THE LEAK WITH PLASTIC REPAIR AND A COOLANT SYSTEM REPAIR, NO USE. HAD TO LIMP THE CAR TO ZENDER FORD IN SPRUCE GROVE, ALBERTA. THEY ARE FIXING THE CAR AT AN ESTIMATED COST OF $900.00 NO WARRANTY OR RECALL. LEFT ME STRANDED 400 KM'S FROM MY HOME. *NM
CAMPAIGN 96V007000----ON MY 96 COUGARXR7 PURCHASED IN 2001--HAD TO REPACE MOTOR DUE TO OVERHEATING--NEW MOTOR STARTED TO OVERHEAT/BLOWER CAUSED THIS OVER-HEATING--BECAUSE BLOWER CAME ON ERATICALLY MECHANIC DID NOT FIND IMMEDIATELY//CURRENTLY OUT OF POCKETEXPENSES AROUND 6000.00--DEALER SHOULD OF HAD THIS FIXED BEFORE SELLING TO ME OR AT LEAST NOTIFIED ME OF THIS RECALL
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
There is no summary currently available