1997 Mercury Cougar recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Power train

  MY VEHICLES BECAME TOTALLY DISABLED ON A VERY BUSY HIGHWAY WITH HEAVY AFTER HOURS RUSH HOUR TRAFFIC. THE MANIFOLD WHICH IS MADE OF PLASTIC BROKE WERE THE COOLANT TEMPERATURE SENSOR WAS BUILT IN, I ALSO NOTICED THAT A FEW SPARKPLUGS WERE FLOODED WITH COOLANT. I FOUND OUT THAT THERE WAS A LAWSUIT ON THESE VEHICLES BUT NO ONE KNEW ABOUT IT AND ONLY FLEET VEHICLES WERE COVERED AND NOT CIVILIAN VEHICLES. I WONDER IF THERE IS ANY CHANCE FOR ME TO SEEK A DEALERSHIP AND GET REIMBURSED FOR THESE DAMAGES. *TR

  Jun 19, 2013 · 156,000 miles
• Engine

  ON 5/19/2004 I HAD TO HAVE TOWED AND REPLACE DEFECTIVE CRACKED PLASTIC INTAKE MANIFOLD ON A 1997 MERCURY XR7 COUGAR AND HADN'T BEEN PREVIOUSLY INFORMED OF ANY RECALLS THEN RECENTLY I HAD TO REPLACE YET ANOTHER DEFECTIVE MANIFOLD (2ND CAR ) THIS SHOP INFORMED ME OF A CLASS ACTION THAT I SHOULD HAVE BEEN INFORMED OF PREVIOUSLY THAT SHOULD HAVE TAKEN CARE OF THE AUTO ABOVE HOWEVER AS THE NOTIFICATION PROGRAM NEVER NOTIFIED ME ON EITHER CAR. *TR

  May 19, 2004 · 88,075 miles
• Fuel system, gasoline

  FUEL WAS NOTED LEAKING FROM FUEL LINES JUST AFT OF THE PASSENGER SIDE DOOR. UPON FURTHER INVESTIGATION, FUEL WAS SEEM RUNNING DOWN THE FUEL LINES AND SIDE OF FUEL TANK. LEAK WAS CAUSED BY FUEL LINES CHAFFING THROUGH ON TOP OF TANK. CAR HAD 51,000 MILES ON IT. *TT

  Jul 6, 2011 · 51,000 miles
• Engine and engine cooling › Exhaust system

  I UNDERSTAND THERE WAS A CLASS ACTION SUIT DUE TO A FAULTY INTAKE MANIFOLD ON MANY FORD CARS WITH A 4.6 LITER ENGINE. I OR MY KIDS HAVE OWNED A 1997 MERCURY COUGAR SINCE NEW. RECENTLY THIS CAR WHICH HAD BEEN IN STORAGE FOR SEVERAL YEARS WAS GIVEN TO MY SON WHO IS LAID OFF AND ATTEMPTING TO COMPLETE HIS BACHELORS DEGREE. I SPENT MONEY TO REPAIR SENSOR, FREEZEPLUG AND HE PUT NEW TIRES ON THIS CAR. I AM WRITING BECAUSE I CONTACTED FORD ABOUT THIS DEFECTIVE INTAKE MANIFOLD PROBLEM AND WAS TOLD I WAS TOO LATE BECAUSE THE CLASS ACTION INVOLVING THE FAULTY PLASTIC INTAKE MANIFOLD HAD EXPIRED IN 2007 OR AT 75,000 MILES. THE CAR IN QUESTION HAS SLIGHTLY MORE THAN 75,000 MILES. HOW COULD I HAVE TAKEN…

  Dec 15, 2009 · 70,000 miles
• Engine and engine cooling

  INTAKE MANIFOLD CRACK AND ANTI-FREEZE SPILLING OUT AND A LOT OF STEAM SMOKE WHILE I WAS DRIVING,CAR IN SHOP NOW A IT WILL COST ME $600.00 TO FIX. *TR

  Jan 10, 2008
• Electrical system › Ignition

  IGNITION FAILED TO TURN WITH KEY. PUT LUBRICANT (WD-40) IN HOLE AND TAPPED WITH HAMMER UNTIL KEY TURNED.

  Mar 4, 2007 · 61,700 miles
• Exterior lighting › Headlights

  FORD HEADLIGHTS: CLOUDY LENSES: FORD MADE AUTOS HAVE PLASTIC LENSES/HEADLIGHTS THAT CLOUD UP OVER TIME, WITHIN 5 YEARS TO 10 YEARS, THAT LIMIT EFFECTIVENESS OF THE HEADLIGHTS AT NIGHT. I PERSONALLY HAVE HIT CURBS AND NARROWLY MISSED PEDESTRIANS ETC DUE TO INABILITY TO SEE THEM AT NIGHT DUE TO LOW HEADLIGHT BRIGHTNESS. THE FORD/MERCURY DEALER INFORMS ME THAT TO REPLACE THE FOGGED LENSES, I WILL HAVE TO PAY HIM $350.00 PER HEADLIGHT FOR A WHOLE NEW ASSEMBLY. LENSES ARE NOT SOLD SEPARATELY, HE SAYS. CANNOT BE CLEANED, HE SAYS. WHY, WHY, WHY DO YOU LET FORD GET BY WITH SELLING CARS THAT HAVE THESE DEFECTIVE, PRONE TO FAILURE HEADLIGHT LENSES? PEOPLE CAN'T SEE WHERE THEY ARE GOING AT NIGHT!…

  Feb 22, 2007
• Engine and engine cooling › Cooling system

  I HAVE A 1997 COUGAR XR7 WITH A 4.6 LITER V8. AROUND JULY 1, 2001, THE INTAKE MANIFOLD ON THE CAR CRACKED CAUSING IT TO OVERHEAT. I HAD THE CAR FIXED, NOT KNOWING THERE WAS A RECALL ON THESE INTAKE MANIFOLDS. IN MARCH OF 2004, I FOUND THE RECALL LETTER SENT TO ME BY LINCOLN MERCURY. I CONTACTED THE SERVICE MANAGER, TIM COATS, AT WHAT WAS THEN RUSTON FORD (I KNEW HIM AS HE DID MOST OF MY VEHICLE'S WARRANTY WORK WHEN HE WAS AT THE LINCOLN MERCURY DEALERSHIP IN MONROE, LA.). I TOLD HIM ABOUT THE LETTER AND I STILL HAD ALL MY RECEIPTS. HE SENT EVERYTHING IN TO LINCOLN MERCURY AND I WAS REIMBURSED. THE RECALL WAS GOOD FOR 7 YEARS, UNLIMITED MILEAGE BEGINNING IN FEBRUARY 1998. LAST FEBRUARY, I…

  Jun 25, 2001 · 77,400 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• BLOWER SWITCH/RESISTOR OR WIRING HARNESSClosedLed to recall 01I009000

  There is no summary currently available

  EA01001 · opened Jan 5, 2001 · closed Jul 31, 2001