Model year record

1995 Mitsubishi Galant recalls & problems

The 1995 Mitsubishi Galant has 6 safety recalls and 209 owner complaints on file with NHTSA. The most-reported problem area is suspension (72 complaints).

Recalls6safety recalls

Complaints209filed by owners

Crashes · fires32 · 5reported in complaints

Injuries · deaths25 · 0reported in complaints

Safety recalls

Fuel system, gasolineJul 26, 2007

Delivery › Fuel pump

Recall 07E055000222 vehicles

Problem: CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.
Risk: IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.
Fix: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.

SuspensionDec 18, 2000

Front › Control arm › Lower ball joint

Recall 00V421001567,432 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
Risk: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.
Fix: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.

Fuel system, gasolineAug 25, 2000

Storage › Tank assembly

Recall 00V23700010,000 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. CRACKS CAN OCCUR IN THE TOP OF THE FUEL TANK DUE TO AN IMPROPER SPOT WELD ON THE BAFFLE PLATE TO THE TOP PORTION OF THE FUEL TANK.
Risk: A CRACK IN THE FUEL TANK COULD ALLOW FUEL OR FUMES TO ESCAPE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Fix: DEALERS WILL INSPECT THE UPPER SURFACE OF THE FUEL TANK FOR ANY SIGNS OF CRACKING. IF NO CRACKING OR LEAKING IS FOUND, DEALERS WILL INSTALL A SEALING PROTECTOR PLATE. IF ANY CRACKING OR LEAKAGE IS FOUND, DEALERS WILL REPLACE THE FUEL TANK ASSEMBLY.

SuspensionApr 5, 1999

Front › Control arm › Lower ball joint

Recall 99V066001307,000 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.
Risk: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.

SuspensionApr 5, 1999

Front › Control arm › Lower ball joint

Recall 99V0660021,731 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT IN JAPAN. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.
Risk: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.

Exterior lightingSep 8, 1998

Tail lights › Switch

Recall 98V21200017,079 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. WHEN THE STOP LAMP SWITCH WAS ASSEMBLED, GREASE WAS INADVERTENTLY APPLIED TO THE CONTACT POINT. THIS CAN CAUSE THE CONTACT POINT TO HEAT UP CAUSING INTERNAL OPERATION ELEMENTS TO MELT ALLOWING THE SWTICH TO BECOME STUCK IN ON OR OFF POSITION.
Risk: THIS CONDITION CAN CAUSE THE ANTI-LOCK BRAKING SYSTEM (ABS) WARNING LIGHT TO COME ON.
Fix: DEALERS WILL INSTALL A RELAY AND REPLACE THE BRAKE LAMP SWITCH.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

1995 Mitsubishi Galant 4-DR.

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Galant

23mpg combined

City / highway	21 / 28 mpg
Fuel	Regular Gasoline

2.4 L · 4 cyl · Manual 5-spd · Front-Wheel Drive · about $2,900/year to fuel

Galant

22mpg combined

City / highway	19 / 26 mpg
Fuel	Regular Gasoline

2.4 L · 4 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,050/year to fuel

Galant

20mpg combined

City / highway	18 / 24 mpg
Fuel	Regular Gasoline

2.5 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,350/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
SuspensionFront › Control arm › Lower ball joint; Front › Control arm	72	1	0	0	117,000 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Disc › Rotor	40	3	1	3	—
Air bagsFrontal; Frontal › Sensor/control module	38	35	1	22	—
Power trainAutomatic transmission; Driveline › Driveshaft	31	1	0	3	65,000 mi
Electrical systemIgnition; 12v/24v/48v battery	18	0	3	2	—
Engine and engine coolingEngine; Engine › Gasoline	15	0	1	0	—
VisibilityWindshield; Defroster/defogger/hvac system	13	0	0	1	—
SteeringHydraulic power assist system; Hydraulic power assist › Pump	12	1	0	0	—
Vehicle speed controlAccelerator pedal; Linkages	10	1	0	0	—
Unknown or other	7	1	0	0	—
Seat beltsFront › Anchorage; Front › Retractor	6	4	0	4	—
EquipmentAppliance › Air conditioner; Electrical › Radio/tape deck/cd etc.	6	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Engine
TL* THE CONTACT OWNS A 1995 MITSUBISHI GALANT. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE THE CHECK ENGINE SENSOR LIGHT AND BRAKE SENSOR LIGHT ILLUMINATED AND CONTINUED TO FLASH OFF AND ON. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 201,000.
Jun 20, 2014 · 201,000 miles
Unknown or other
I SPRAYED MY 95 MITSUBISHI GALANT MOTOR OFF AND RINSED IT OFF, IT RAN FOR ABOUT TWENTY MINUTES AND THEN SHUT OFF. NOW ITS JUST TURNING AD WILL NOT START. *TR
Jun 4, 2010
Electrical systemFire
IT STARTED WITH MY LIGHTS AND RADIO STAYING ON EVEN WHEN THE CAR WAS OFF, IT WAS LIKE THAT FOR A FEW DAYS THEN I WAS DRIVING UP THE ROAD TO MEET SOME FRIENDS WHEN I SPELLED SOMETHING BURNING THEN SMOKE STARTED ROLLING OUT OF MY STEERING COLUMN. *TR
Sep 6, 2008 · 150,000 miles
Exterior lighting
TL*THE CONTACT OWNS A 1995 MITSUBISHI GALANT. THE CONTACT STATED THAT THE ABS LIGHT IN THE VEHICLE WOULD ILLUMINATE. HE WOULD ALSO HAVE TO PULL THE FUSE ON THE DRIVER'S SIDE TURN SIGNAL BECAUSE IT APPEARED TO BE STUCK. THE FAILURE OCCURRED EVERYTIME THE VEHICLE WAS DRIVEN. THE MANUFACTURER STATED THAT THEY WOULD NOT HONOR NHTSA CAMPAIGN ID NUMBER 98V212000 (EXTERIOR LIGHTING:TAIL LIGHTS:SWITCH) BECAUSE HIS VIN WAS NOT INCLUDED. THE CONTACT WILL PAY TO HAVE THE VEHICLE REPAIRED. THE CURRENT MILEAGE WAS 155,852 AND FAILURE MILEAGE WAS APPROXIMATELY 150,000.
Dec 25, 2007 · 150,000 miles
Suspension › Front › Control arm › Lower ball joint
TL*THE CONTACT OWNS A 1995 MITSUBISHI GALANT. WHILE MAKING A LEFT TURN AT APPROXIMATELY 5 MPH, THE FRONT DRIVER'S SIDE WHEEL DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 00V421001 (SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT). THE DEALER HAS NOT INSPECTED THE VEHICLE. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 117,000.
Dec 15, 2007 · 117,000 miles
Service brakes, hydraulic › Antilock/traction control/electronic limited slip
ANTILOCK BRAKE MALFUNCTIONED ON SEVERAL OCCASIONS WHEN THERE WAS NEED TO BRAKE SUDDENLY RESULTING IN SEVERAL NEAR CRASHES. WHEN BRAKE WAS APPLIED GRINDING NOISE HEARD AND THEN ANTI LOCK BRAKE LIGHT CAME ON AND REMAINED ON. THIS HAS OCCURRED TOO OFTEN AND MITSUBISHI NEEDS TO RECALL THIS MODEL AND FIX IT. THE LATEST INCIDENT OCCURRED ON AUGUST 5, 2007, BUT THERE HAVE BEEN SEVERAL INSTANCES OF THIS HAPPENING BEFORE. *TR
Aug 5, 2007 · 109,000 miles
Engine and engine coolingFire
1995 MITSUBISHI GALANT CAUGHT FIRE IN THE ENGINE COMPARTMENT. *KB PRIOR TO THE FIRE, THE HEAD GASKET COVER WAS REPLACED.(OHIO TRAFFIC CRASH REPORT) *JB
May 18, 2007
Service brakes, hydraulic › Antilock/traction control/electronic limited slip
TL*- THE CONTACT STATED THAT THE 1995 MITSUBISHI GALANT ABS LIGHT TURNED ON 03/11/07. HE STATED THAT WHILE DRIVING THE VEHICLE IN THE EVENING HOURS AT THE SPEED OF 50-55 MPH THE ABS LIGHT TURNED ON. HE NOTICED A CHANGE IN THE BRAKE SYSTEM. HE STATED THAT THE BRAKE PEDAL BECAME DIFFICULT TO PRESS. HE CALLED THE DEALERSHIP ON 3/12/07, AND THEY INFORMED HIM TO CHECK AND SEE IF THE VEHICLE WAS ON RECALL ,AND IF IT WAS, TO CALL THEM BACK. THE CONTACT FOUND NO RECALL FOR THE ABS, BUT DID FIND A NUMBER OF COMPLAINTS WITH THE SAME PROBLEM. THE CONTACT STATED THAT THE ABS LIGHT CONTINUED TO STAY ON. HE STATED THAT HE HASN'T DRIVEN THE VEHICLE RECENTLY, BUT DID START IT UP, AND THE LIGHT ABS LIGHT…
Mar 11, 2007

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

LOWER CONTRTOL ARM BALL JOINTClosedLed to recall 00V421001
There is no summary currently available
RQ00015 · opened Aug 2, 2000 · closed Apr 20, 2001