Model year record

1996 Mitsubishi Galant recalls & problems

The 1996 Mitsubishi Galant has 4 safety recalls and 136 owner complaints on file with NHTSA. The most-reported problem area is power train (39 complaints).

Recalls4safety recalls

Complaints136filed by owners

Crashes · fires27 · 4reported in complaints

Injuries · deaths23 · 0reported in complaints

Safety recalls

Fuel system, gasolineJul 26, 2007

Delivery › Fuel pump

Recall 07E055000222 vehicles

Problem: CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.
Risk: IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.
Fix: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.

SuspensionDec 18, 2000

Front › Control arm › Lower ball joint

Recall 00V421001567,432 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
Risk: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.
Fix: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.

Fuel system, gasolineAug 25, 2000

Storage › Tank assembly

Recall 00V23700010,000 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. CRACKS CAN OCCUR IN THE TOP OF THE FUEL TANK DUE TO AN IMPROPER SPOT WELD ON THE BAFFLE PLATE TO THE TOP PORTION OF THE FUEL TANK.
Risk: A CRACK IN THE FUEL TANK COULD ALLOW FUEL OR FUMES TO ESCAPE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Fix: DEALERS WILL INSPECT THE UPPER SURFACE OF THE FUEL TANK FOR ANY SIGNS OF CRACKING. IF NO CRACKING OR LEAKING IS FOUND, DEALERS WILL INSTALL A SEALING PROTECTOR PLATE. IF ANY CRACKING OR LEAKAGE IS FOUND, DEALERS WILL REPLACE THE FUEL TANK ASSEMBLY.

SuspensionApr 5, 1999

Front › Control arm › Lower ball joint

Recall 99V066001307,000 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.
Risk: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

1996 Mitsubishi Galant 4-DR.

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Galant

23mpg combined

City / highway	21 / 28 mpg
Fuel	Regular Gasoline

2.4 L · 4 cyl · Manual 5-spd · Front-Wheel Drive · about $2,900/year to fuel

Galant

22mpg combined

City / highway	19 / 26 mpg
Fuel	Regular Gasoline

2.4 L · 4 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,050/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Power trainAutomatic transmission; Manual transmission	39	3	0	1	93,474 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components	33	6	0	6	—
SuspensionFront › Control arm › Lower ball joint; Front › Control arm	23	3	0	0	—
Air bagsFrontal; Frontal › Sensor/control module	21	19	0	20	—
Engine and engine coolingEngine › Gasoline; Engine	20	0	0	0	—
StructureBody › Door; Frame and members	13	0	2	0	150,000 mi
VisibilityWindshield; Power window devices and controls	9	0	2	0	—
Electrical systemAlternator/generator/regulator; 12v/24v/48v battery	7	0	0	0	—
Vehicle speed controlAccelerator pedal	7	2	0	2	—
Seat beltsFront › Retractor; Rear/other	5	3	0	3	—
EquipmentAppliance › Air conditioner; Electrical › Radio/tape deck/cd etc.	5	0	1	0	—
SteeringHydraulic power assist system; Column locking › Anti-theft device	4	1	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Structure › Body
TL* THE CONTACT OWNS A 1996 MITSUBISHI GALANT. THE CONTACT STATED THAT ROUTINE MAINTENANCE WAS BEING PERFORMED ON THE VEHICLE WHEN SHE WAS NOTIFIED THAT THE FRAME WAS CORRODED. THE MECHANIC STATED THAT THE VEHICLE NEEDED TO BE DESTROYED AND WAS NO LONGER SAFE TO OPERATE. THE DAMAGE WAS BEYOND REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER COVERED UNDER WARRANTY. THE FAILURE AND THE CURRENT MILEAGE WAS 179,000.
Apr 2, 2012 · 179,000 miles
Suspension › Front
I CURRENTLY BOUGHT THE 1996 MITSUBISHI GALANT FOR MY WIFE AND 11 MONTH OLD DAUGHTER. THE DEALER TOLD ME I NEEDED A FRONT END ALIGNMENT TO GET THE PULL AND SHAKE OUT OF MY FRONT END. I TOOK IT TO AN ALIGNMENT SHOP AND THE ASE MASTER TECH. TOLD ME MY CONTROL ARMS WERE BENT DUE TO CORROSION OF THE BALL JOINT, HE THEN TOLD ME THERE WAS A RECALL ON THESE VEHICLES AND IF I DON'T GET THE PROBLEM FIXED IT COULD RESULT IN A LOSS OF STEERING. I DON'T THINK IT WOULD BE SAFE FOR MY WIFE TO LOSE STEERING WITH OUR INFANT DAUGHTER SO NOW I GOT BIGGER PROBLEMS THEN A TWENTY FIVE DOLLAR FRONT END ALIGNMENT. I'M UPSET AT THE DEALER FOR NOT INFORMING ME WITH THESE RECALLS NOT THE MANUFACTURE FOR MAKING THE…
Jul 24, 2010
Structure › Frame and members
TL*THE CONTACT OWNS A 1996 MITSUBISHI GALANT. WHILE ATTEMPTING TO CHANGE A FLAT TIRE, THE JACK WENT STRAIGHT THROUGH THE FRAME WHILE THE VEHICLE WAS BEING LIFTED. THE CONTACT HAD THE VEHICLE TOWED TO A SHOP AND THEY INFORMED HIM THAT THERE WAS EXCESSIVE RUST IN THE REAR SUBFRAME. THE CONTACT SOLD THE VEHICLE RATHER THAN HAVE IT REPAIRED. THE FAILURE MILEAGE WAS 150,000.
May 1, 2007 · 150,000 miles
Structure › Body
TL*THE CONTACT OWNS A 1996 MITSUBISHI GALANT. THE REAR WHEEL ASSEMBLY IS ATTACHED TO THE SUBFRAME, WHICH IS ATTACHED TO THE BODY. THE ENTIRE PART IS EXTREMELY RUSTED AND PREVENTED THE CONTACT FROM JACKING THE VEHICLE AND CHANGING THE TIRE. THE DEALER NOTIFIED THE CONTACT OF THIS FAILURE. THE FAILURE IS NOTICEABLE WHILE DRIVING 20 MPH. THE FAILURE MILEAGE WAS 130,000 AND CURRENT MILEAGE WAS 162,000. UPDATED 01-11-08. *KB UPDATED 12/31/07 *TR
Jun 1, 2007 · 130,000 miles
Structure › Frame and members
THE REAR UNDERCARRIAGE OF MY 1996 MITSUBISHI GALANT HAS SEVERE RUST DAMAGE TO THE POINT THAT YOU CANNOT EVEN JACK UP THE CAR AS THE JACK PENETRATES THEY SUB FRAME. THE STRUT FROM THE RIGHT REAR ALSO CAME LOOSE FROM THE TOWER. THE REAR WHEELS THAT ARE ATTACHED TO THE SUB FRAME ARE EXTREMELY UNSAFE. *TR
Jan 1, 2007 · 100,000 miles
Structure › Frame and members
TL* - THE CONTACT OWNS A 1996 MITSUBISHI GALANT. DURING ROUTINE MAINTENANCE CHECKS THE MECHANIC DISCOVERED RUST ON THE FRAME UNDER THE VEHICLE IN FRONT OF EACH REAR WHEEL. THE CURRENT MILEAGE WAS 157000 AND THE FAILURE MILEAGE WAS 155000. *AK UPDATED 2/27/2007 - *NM
Aug 1, 2006 · 155,000 miles
Power train › Automatic transmission
TRANSMISSION FLUID DIPSTICK IMPOSSIBLE TO READ, NOTIFIED DEALER, DEALER SAID THAT'S JUST HOW IT IS DESIGNED. I'M WORRIED BECAUSE TRANMISSIONS ARE A COMMON FAILURE ON THIS GENERATION OF MITSUBISHI GALANT. CAN THIS BE CORRECTED BY A DIPSTICK REDESIGN?
May 20, 2005 · 84,388 miles
Power train › Manual transmission
THE MANUAL TRANSMISSION OF MY 1996 MITSUBISHI GALANT SLIPS OUT OF GEAR AT VARIOUS SPEEDS AND REENGAGES. CONTROL OF THE VEHICLE IS LOST WHEN THIS HAPPENS.*AK
Mar 21, 2005 · 129,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

LOWER CONTRTOL ARM BALL JOINTClosedLed to recall 00V421001
There is no summary currently available
RQ00015 · opened Aug 2, 2000 · closed Apr 20, 2001