Model year record

1998 Volkswagen Beetle recalls & problems

The 1998 Volkswagen Beetle has 8 safety recalls and 171 owner complaints on file with NHTSA. The most-reported problem area is electrical system (63 complaints).

Recalls8safety recalls

Complaints171filed by owners

Crashes · fires14 · 16reported in complaints

Injuries · deaths9 · 0reported in complaints

Safety recalls

Engine and engine coolingMar 7, 2014

Engine

Recall 14E00700050 vehicles

Problem: The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
Risk: A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Fix: Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.

Exterior lightingApr 7, 2009

Exterior lighting

Recall 09E01200016,270 vehiclesopened after NHTSA action (OVSC)

Problem: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Fix: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Exterior lightingAug 11, 2008

Headlights

Recall 08E0500001,921 vehiclesopened after NHTSA action (OVSC)

Problem: K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

Exterior lightingJun 29, 2006

Exterior lighting

Recall 06E06000087,745 vehiclesopened after NHTSA action (OVSC)

Problem: CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Fix: AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.

Exterior lightingMay 24, 2006

Brake lights › Switch

Recall 06V183000646,246 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Risk: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Fix: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Exterior lightingMay 24, 2006

Exterior lighting

Recall 06E04900027,176 vehiclesopened after NHTSA action (OVSC)

Problem: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Fix: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Exterior lightingMar 23, 2006

Exterior lighting

Recall 06E02600061,944 vehiclesopened after NHTSA action (OVSC)

Problem: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Fix: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Electrical systemMay 13, 1998

Wiring › Front underhood

Recall 98V1000008,500 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ELECTRICAL WIRING LOCATED IN THE ENGINE COMPARTMENT WAS ROUTED TOO CLOSE TO THE ENDGE OF THE VEHICLE'S BATTERY TRAY. THE WIRING CAN BECOME DAMAGED OVER TIME BY CHAFING AND THE AIR-CONDITIONER COMPRESSOR AND/OR THE FUEL PUMP CAN MALFUNCTION.
Risk: A MALFUNCTION OF THE FUEL PUMP CAN CAUSE THE VEHICLE TO STALL, AND IN SOME INSTANCES, COULD ALSO RESULT IN A WIRING FIRE IN THE ENGINE COMPARTMENT.
Fix: DEALERS WILL INSTALL A MODIFIED BATTERY TRAY AND INSPECT, PROPERLY ROUTE, AND SECURING THE WIRING IN ACCORDANCE WITH THE RECALL REPAIR INSTRUCTIONS.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Electrical systemWiring › Front underhood; Wiring › Fuses and circuit breakers	63	2	10	2	59,325 mi
VisibilityPower window devices and controls; Windshield	39	1	1	0	58,997 mi
Engine and engine coolingEngine › Gasoline; Engine	35	2	8	0	53,500 mi
Exterior lightingHeadlights; Brake lights › Switch	28	4	1	0	60,000 mi
StructureBody; Body › Trunk lid	17	0	1	0	50,000 mi
Air bagsFrontal; Side/window	15	9	0	6	56,331 mi
EquipmentElectrical › Radio/tape deck/cd etc.; Appliance › Air conditioner	14	1	1	0	50,000 mi
Power trainAutomatic transmission; Driveline › Driveshaft	12	1	0	1	50,000 mi
SeatsFront assembly › Recliner	12	1	0	1	64,000 mi
Latches/locks/linkagesDoors › Latch; Hatchback/liftgate › Lock	11	0	0	0	51,000 mi
Service brakes, hydraulicFoundation components; Foundation components › Disc › Pads	8	1	1	0	89,957 mi
Unknown or other	8	1	2	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Tires › Tread/belt
Separation between belts near the sidewall Cooper cs5 grand touring 205/65 r16. I have had 4 tires that this has happened to. Replaced both front tires twice. This seems to be a recurring problem with these tires.
Mar 3, 2021
Air bagsCrash
The driver was driving the speed limit (55 mph) and tried to slow down as they approached a red light. The brakes failed to work, and the driver rear-ended the vehicle waiting at the stoplight. The airbags did not deploy.
Oct 4, 2021
Service brakes
DON'T WORK
May 25, 2019
EngineFire
DAUGHTER WAS DRIVING TO SCHOOL, CAR STALLED, RESTARTED CAR THEN SAW SMOKE AND FIRE UNDER PASSENGER SIDE DASH. CAR BURNT COMPLETELY, TOTALED. HAVE BEFORE AND AFTER PICTURES. ..UPDATED 11/12/14 *BF
Oct 31, 2014 · 130,000 miles
Engine
TL* THE CONTACT OWNS A 1998 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE STALLED AND FAILED TO SHIFT INTO ANY GEAR WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 85,000.
Jun 2, 2014 · 85,000 miles
Electrical systemFire
OWNER WAS DRIVING VEHICLE AND ATTEMPTED TO TURN ON A/C. WHEN A/C WOULD NOT WORK PROPERLY, SHE PULLED OFF ROADWAY AND STOPPED. SMOKE AND BURNING ODOR CAME OUT OF VENTS, WITH FIRE EVENTUALLY SHOWING FROM CLIMATE CONTROL PANEL. INTERIOR OF VEHICLE WAS FULLY INVOLVED IN FIRE WHEN FD ARRIVED. ENGINE COMPARTMENT NOT INVOLVED. RADIO OPERATING PROPERLY PRIOR TO INCIDENT. NO PRIOR ISSUES WITH VEHICLE. *TR
Aug 2, 2013
Seats
TWO SMALL BOLTS THAT HOLD DOWN THE FRONT OF THE DRIVERS SEAT BECAME LOOSE AND OVER TIME THEY EVENTUALLY BROKE COMPLETELY FREE ALLOWING THE SEAT TO ROLL AND TIP BACKWARD AND SIDEWAYS. THIS WAS A COMPLETE SHOCK WHEN IT OCCURED, I HAD NOTICED THE SEAT BECOMING LOOSE BUT THEN TO HAVE IT BREAK FREE WAS A SCARE. THANKFULLY THERE WAS NOT A CRASH AND INJURY AS A RESULT. IT APPEARS THAT I AM NOT THE ONLY ONE THIS HAS HAPPENED TO SO IT IS SURPRISING THAT THAT CARS ARE NOT RECALLED TO HAVE THREAD LOCKER OR DIFFERENT BOLTS INSTALLED. *TR
Mar 18, 2013 · 147,000 miles
Electrical system1 injury
WINDOWS STARTED GOING UP AND DOWN RANDOMLY AND DOORS LOCKING/UNLOCKING RANDOMLY. AS I WAS REACHING THROUGH MY WINDOW TO GRAM MY KEYS FROM THE IGNITION MY ARM GOT PINCHED, AND LODGED IN THE WINDOW THAT WAS GOING UP, (I WAS TRYING TO GET MY KEYS BEFORE GETTING LOCKED OUT OF THE CAR (AGAIN) DUE TO THE RANDOM LOCKING AND UNLOCKING). AUTO REVERSAL OF THE WINDOWS WHEN AN APPENDAGE GETS LODGED IN THE WINDOW DID NOT OCCUR. THIS PINCHED AND LODGED MY LEFT ARM IN THE WINDOW TO A POINT OF BRUISING AN AREA OF 4 INCHES BY 2 INCHES. AFTER EXHAUSTIVELY RESEARCHING THIS ISSUE (WHICH IS A COMMON ISSUE WITH THE DOOR LOCK MODULES ON THE 98-02 VW BEETLES WITH THE OLD STYLE "LOUD" POWER LOCKS) I CONCLUDED THAT…
Aug 26, 2012 · 76,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

BRAKE LIGHT SWITCH FAILUREClosedLed to recall 06V183000
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
RQ06004 · opened Feb 28, 2006 · closed Aug 7, 2006
BRAKE LIGHT SWITCHClosedLed to recall 03V265000
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
EA03002 · opened Apr 8, 2003 · closed Aug 20, 2003
BRAKE LIGHT SWITCH OPERATIONClosed
THE BRAKE LIGHT SWITCH USED IN NEW BEETLE IS ALSO SPECIFIED IN GOLF AND JETTA MODELS.ONE TYPE OF SWITCH IS USED ON CRUISE EQUIPPED MODELS, A SECOND TYPE IS USED ON NON-CRUISE MODELS.VW REPORTS 86 CONSUMER COMPLAINTS AND 2575 WARRANTY CLAIMS OF INOPERATIVE BRAKE LIGHTS, THE MAJORITY OF WHICH ARE RELATED TO THE BRAKE SWITCH.TWO OF THE VW COMPLAINTS INVOLVE FAILURES THAT WERE ALSO REPORTED TO ODI.ADDITIONALLY, OVER 100,000 BRAKE SWITCH SERVICE COMPONENTS HAVE BEEN SOLD UNDER 4 DIFFERENT PART NUMBERS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
PE02084 · opened Nov 18, 2002 · closed Apr 8, 2003