The 1995 BMW 525i has 3 safety recalls and 24 owner complaints on file with NHTSA. The most-reported problem area is latches/locks/linkages (6 complaints).
Recalls3safety recalls
Complaints24filed by owners
Crashes · fires1 · 1reported in complaints
Injuries · deaths0 · 0reported in complaints
Safety recalls
Engine and engine cooling › Cooling system
NHTSA recall 98V178000 · Aug 4, 1998 · 340,000 vehicles
Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Risk: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Fix: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
Vehicle speed control
NHTSA recall 97V131000 · Aug 19, 1997 · 410,000 vehicles
Problem: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Risk: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
Latches/locks/linkages › Doors › Latch
NHTSA recall 94V219000 · Nov 8, 1994 · 2,180 vehicles
Problem: THE DOUBLE-LOCK FEATURE CAN ENGAGE WITH OCCUPANTS AND THE DOOR/IGNITION KEY INSIDE THE VEHICLE.
Risk: THE OCCUPANTS OF THE VEHICLE WOULD BE UNABLE TO EXIT EITHER FROM THE DOORS OR FROM THE WINDOWS OF THE VEHICLE. DRIVE-AWAY PROTECTION WOULD PREVENT THE ENGINE FROM STARTING.
Fix: DEALERS WILL REPLACE THE GENERAL CONTROL MODULE WITH ONE CONTAINING THE REVISED SOFTWARE TO PERMIT WINDOW OPENING WITH THE DOUBLE-LOCK ENGAGED AND KEY IN THE IGNITION.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Fuel economy
525i
20mpg combined
City / highway
17 / 26 mpg
Fuel
Premium Gasoline
2.5 L · 6 cyl · Manual 5-spd · Rear-Wheel Drive · about $4,100/year to fuel
525i
19mpg combined
City / highway
16 / 23 mpg
Fuel
Premium Gasoline
2.5 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,350/year to fuel
525i Touring
19mpg combined
City / highway
16 / 23 mpg
Fuel
Premium Gasoline
2.5 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,350/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Latches/locks/linkages Doors › Latch
6
0
0
0
150,675 mi
Electrical system Wiring › Fuses and circuit breakers
5
0
0
0
—
Seat belts Front › Retractor; Front › Buckle assembly
4
0
0
0
—
Engine and engine cooling Cooling system; Engine
4
0
1
0
—
Visibility Power window devices and controls; Rearview mirrors/devices
3
0
0
0
—
Power train Automatic transmission
3
0
0
0
—
Structure Body › Door; Body
2
0
0
0
—
Service brakes, hydraulic Foundation components; Antilock/traction control/electronic limited slip
2
0
0
0
—
Unknown or other
2
0
0
0
—
Vehicle speed control
2
1
0
0
—
Equipment Appliance › Air conditioner
2
0
0
0
—
Suspension
1
0
0
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Dec 18, 2022Electrical system RECAL 94V219000: Double-lock Feature GCM Revised. "The double-lock feature can engage with occupants and the door/ignition key inside of the vehicle. The occupants of the vehicle would be unable to exit either from the doors or from the windows of the vehicle." NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, CONTACT BMW AND THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE My car locked me in it and I was unable to exit exactly as described in this Recall. Called BMW and they are saying the recall was remedied.…
Apr 1, 2012 · 100,000 milesLatches/locks/linkages TL* THE CONTACT OWNS A 1995 BMW 525I. WHILE PARKED WITH THE KEY OUT OF THE IGNITION, THE OCCUPANT IN THE VEHICLE WAS UNABLE TO OPEN ANY OF THE DOORS OR WINDOWS MANUALLY. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 94V219000 (LATCHES/LOCKS/LINKAGES:DOORS:LATCH) THAT COULD HAVE BEEN RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Jun 29, 2010Latches/locks/linkages › Doors › Latch TL* THE CONTACT OWNS A 1995 BMW 525I. AFTER SITTING IDLE IN THE VEHICLE, THE CONTACT ATTEMPTED TO EXIT BUT WAS LOCKED IN THE VEHICLE FOR OVER TEN MINUTES. THE CONTACT REFERENCED NHTSA RECALL CAMPAIGN ID NUMBER: 94V219000 (LATCHES/LOCKS/LINKAGES: DOORS: LATCH) HOWEVER THE DEALER ADVISED HER VIN WAS NOT INCLUDED IN THE RECALL. ANY REPAIRS WOULD BE AT THE EXPENSE OF THE CONTACT. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE NOT AVAILABLE.
Feb 10, 2010 · 153,537 milesLatches/locks/linkages OWNER OF 1995 BMW 525 WAS UNABLE TO EXIT CAR .WINDOWS WOULD NOT OPEN WITH KEY ON NOR DID SUNROOF OPEN. THE CAR WOULD NOT START. SOUTH BAY DEALERSHIP REFUSED TO HONOR RECALL NUMBER 94V219000 AS SO DID BMW HEADQUARTERS. *TR
Sep 9, 2008Latches/locks/linkages ON A HOT AFTERNOON IN SACRAMENTO, WE STOPPED IN A PARKING LOT AND SHUT OFF THE CAR PREPARING TO EXIT. THE WINDOWS OF THE BMW WERE UP AND WE WERE NOT ABLE TO OPEN THE DOORS. THE ENGINE WOULD NOT START AND WE WERE TRAPPED IN THE HOT CAR. FORTUNATELY WE HAD A CAR PHONE AND CALLED 911 FOR HELP. AFTER A FRIGHTENING HALF HOUR TRAPPED IN THE HOT LOCKED CAR WE WERE EXTRICATED. THE CAR WAS TOWED TO A GARAGE. *TR
Aug 4, 2007 · 147,813 milesLatches/locks/linkages › Doors › Latch TL*THE CONTACT OWNS A 1995 BMW 525I. THE CONTACT STATED THAT THE DRIVER SIDE FRONT DOOR FAILED TO UNLOCK AND THE DRIVER SIDE WINDOW FELL DOWN INTO THE VEHICLE. THE PASSENGER SIDE AND REAR DOORS WILL OPEN, BUT SHE MUST OPEN THEM QUICKLY. THE CONTACT HAS BEEN LOCKED IN THE VEHICLE ONCE. THE DEALER WAS NOTIFIED. NHTSA RECALL NUMBER 94V219000 (LATCHES/LOCKS/LINKAGES:DOORS:LATCH) WAS REFERENCED. THE CURRENT AND FAILURE MILEAGES WERE 147,813.
Jul 17, 2006 · fireEngine and engine cooling › Engine 1995 BMW 525I CAUGHT ON FIRE WHILE DRIVING. *TS THE FIRE STARTED UNDER THE HOOD. THE ENTIRE FRONT END OF THE VEHICLE WAS DAMAGED. THE CAUSE OF THE FIRE WAS NOT DETERMINED. THERE WERE NO INJURIES *NM
Apr 5, 2005 · 112,000 milesPower train › Automatic transmission TRANSMISSION SLIPPING. I HAVE A 1995 525 BMW WITH 112000 MILES. THE TRANSMISSION INSTANTLY ONE DAY SLIPPED AND THE INDICATOR LIGHT WENT ON TO SEE MY DEALER. I DID AND WAS TOLD THE TRANSMISSIONS ON BMW'S MUST BE REPLACED, THEY CANNOT BE FIXED OR REPAIRED. I CALLED BMW AND SPOKE TO A TIM IN CUSTOMER SERVICE. I ASKED FOR SOME TYPE OF WARRANTY, AND WAS GIVEN A POLITE ANSWER OF 'NO' WE DON'T GIVE WARRANTIES TO ANYONE WHOSE CAR IS OVER THE WARRANTY. I TOLD HIM I WORKED FOR FORD FOR 20 YEARS, AND THEY HAD A REP COME OUT AND LOOK INTO EACH PROBLEM, EVEN IF OUT OF WARRANTY. TIM TOLD ME, BMW DOES NOT SEND REPS OUT TO DO THAT. I ASKED HIM WHO HIS BOSS WAS, I"LL TALK TO THEM. HE SAID HE DIDN' T HAVE A…
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.