*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Service brakes
While driving down a 50 mph roadway there was a line of cars slowing for a vehicle to make a turn. When gently pushing the brakes to slow down, brake went clear to the floor and could not slow down. Truck was driven into the ditch to avoid rear-ending vehicles. This happened immediately without warning, all braking prior to this incident was normal. When taken to our mechanic, they advised the brake lines underneath were notorious for rusting out and failing, new stainless steel lines were then installed to correct the problem.
Apr 14, 2026Tires
The contact owns a 2003 Chevrolet Silverado 2500 equipped with Prinx Tires, Tire Line: High Country, Tire Size: 245/75/R16, DOT Number: 04N18HTPC1323. The contact had the tires rotated by an independent mechanic. Upon inspection of the tires, the contact discovered cracks along the base of the tire treads on all four tires. The contact notified the mechanic about the defect and was given a credit for the remaining mileage on the tires warranty. The contact notified the manufacturer about the failure through voicemail and email; however, the contact never received a response. The contact stated that the four tires were replaced. The tire failure mileage was 21,942. The vehicle failure…
Aug 3, 2024 · 342,422 milesPower train
The component that failed according to the Chevrolet dealer is the "transfer case pump clips", which came loose inside the transfer case and wore a hole through the case causing the oil to come out. If I would not have noticed the oil on the back of my truck, I could have continued to drive the truck, which could have caused the transfer case gears to lock up the front and rear axles while driving and could have caused me to wreck, causing injury to myself, my family or someone else. I marked the area of the leak with a sharpie as depicted in the photos.
Jun 28, 2023Air bags
When starting vehicle , after initial dash lights times out, I now get an AIRBAG 9malfunction light). Tried resetting, did not work. Now, every time I start the engine, the comes on and stays on.
Jun 15, 2023Service brakes
Hydroboost valve pump shows a recall.,and it's not working properly
Jun 3, 2021Power train
I had to replace the replace the housing on my transfer case as it wore a hole in and was leaking. At a cost of 1200 dollars due to myself catching it early as later with a fully disabled case would have been 2600 dollars. My mechanic who deals in transmission repairs told me this a very common problem for Chevy trucks from 1999 to 2006. He claimed he had done 7 transfer cases in one week and was actually replacing a fully wrecked one for 2600 dollars as I brought mine in to be worked on . It had worn a hole through the transfer case and was leaking. As this seems to be a serious defect . I feel it should have been under a recall and reimbursement should be in order for those who paid out…
Oct 7, 2022Engine and engine cooling
In the middle of the taxiway, while I was traveling my truck turned off while it was running and did not turn on again, putting my safety at risk by being in the middle of the taxiway, after several minutes the truck was able to be removed from the road, then I was able to investigate that I am not the only one that the same thing has happened to him, there is no Safety Recall in this regard, the GM fabric is aware of these cases but only wrote a TSB, it was diagnosed with the scanner and it gave code U1800, before the event there were no lights warning but after the event there is a check engine light on.
Apr 1, 2022Steering
The contact owns a 2003 Chevrolet Silverado 2500. The contact stated that while driving at various speeds, the power steering failed causing the steering wheel to become hard to maneuver. The contact heard an abnormal sound coming from the hydro boost area when the brake pedal or accelerator pedal were depressed. The vehicle was taken to the dealer and diagnosed that the intermediate shaft was faulty. The intermediate shaft was replaced however, the failure recurred. The contact requested the dealer to replace the power steering pump but the dealer informed the contact that the failure was caused by the power steering pump. The manufacturer was made aware of the failure and a case was…
Jul 12, 2016 · 115,000 miles
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.