The 2000 Ford E-250 has 5 safety recalls and 18 owner complaints on file with NHTSA. The most-reported problem area is service brakes, hydraulic (5 complaints).
Recalls5safety recalls
Complaints18filed by owners
Crashes · fires3 · 2reported in complaints
Injuries · deaths2 · 0reported in complaints
Safety recalls
Vehicle speed control
NHTSA recall 09V399000 · Oct 13, 2009 · 4,500,000 vehicles · opened after NHTSA action (ODI)
Problem: FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Fix: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Vehicle speed control › Cruise control
NHTSA recall 08V051000 · Feb 4, 2008 · 225,000 vehicles
Problem: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Risk: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Fix: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Vehicle speed control
NHTSA recall 07V336000 · Aug 3, 2007 · 3,600,000 vehicles · opened after NHTSA action (ODI)
Problem: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Fix: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Equipment adaptive/mobility
NHTSA recall 04V562000 · Nov 26, 2004 · 1,660 vehicles · opened after NHTSA action (ODI)
Problem: ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.
Risk: IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.
Fix: DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK WILL HANDLE THE REPAIRS FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR MOBILITYWORKS AT 1-800-769-8267.
Problem: VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
Risk: THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
Fix: OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Fuel economy
E250 Econoline 2WD
14mpg combined
City / highway
12 / 16 mpg
Fuel
Regular Gasoline
4.2 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,800/year to fuel
E250 Econoline 2WD
13mpg combined
City / highway
12 / 17 mpg
Fuel
Regular Gasoline
5.4 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $5,150/year to fuel
E250 Econoline 2WD CNG CNG
12mpg combined
City / highway
11 / 14 mpg
Fuel
Natural Gas
5.4 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,850/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Service brakes, hydraulic Antilock/traction control/electronic limited slip
5
1
0
1
—
Suspension Front › Springs › Air suspension system; Rear
4
0
0
0
—
Steering Gear box (other than rack and pinion); Hydraulic power assist › Pump
2
0
0
0
—
Tires Tread/belt; Temporary/emergency spare tire
2
1
0
1
—
Engine and engine cooling Engine; Engine › Gasoline
2
0
0
0
—
Electrical system Wiring
2
0
2
0
—
Air bags Frontal
1
1
0
1
—
Power train Automatic transmission
1
1
0
0
—
Structure Body
1
0
0
0
—
Vehicle speed control
1
0
0
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Dec 25, 2012 · 40,000 milesStructure › Body TL* THE CONTACT OWNS A 2000 FORD E-250. THE CONTACT STATED THAT THE SPEED CONTROL SWITCH BECAME DETACHED FROM THE VEHICLE. THE CONTACT WAS UNABLE TO ACTIVATE THE CRUISE CONTROL AND STATED THAT THERE WAS CORROSION ON THE AREA THAT WAS EXPOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
Jul 21, 2007 · 79,000 milesEngine and engine cooling › Engine › Gasoline 2000 FORD E250 VAN, PURCHASED NEW AUG 2000. PURCHASED EXTENDED WARRANTY, 5 YEARS. NOVEMBER 2005; HARMONIC BALANCER FELL OFF ENGINE. ~79K MILES (APPROX 3 MONTHS OUT OF WARRANTY) TOWED TO DEALER AND REPAIRED. JULY 2007; HARMONIC BALANCER FELL OFF ENGINE. ~101K MILES. TOWED TO DEALER AND REPAIRED. REPAIR PARTS ARE WARRANTED FOR 12 MONTHS. THIS IS 8 MONTHS OUT OF WARRANTY. PLEASE NOTE: HARMONIC BALANCERS DO NOT USUALLY FALL OFF OF ENGINES. THIS REPAIR HAS A 12 MONTH WARRANTY. *JB
Aug 7, 2006 · 208,380 miles · fireElectrical system › Wiring UNDER HOOD FIRE. *JB
Nov 13, 2005 · 119,000 miles · fireElectrical system DT*: THE CONTACT STATED WHILE SITTING IN THE DRIVEWAY FOR TWO DAYS, THE VEHICLE CAUGHT ON FIRE AND CAUSED DAMAGE TO THE CONTACT'S HOUSE, THE NEIGHBOR'S HOUSE AND ANOTHER VEHICLE OWNED BY THE CONTACT. BOTH VEHICLES WERE TOTALED. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRES. THE FIRE DEPARTMENT DETERMINED THE FIRE ORIGINATED IN THE WIRING OF THE VEHICLE IN BACK OF THE BATTERY. THERE WERE NO PROBLEMS WITH THE VEHICLE PRIOR TO THE INCIDENT. THE DEALERSHIP WAS NOTIFIED.
Sep 26, 2005 · 11,400 milesEngine and engine cooling › Engine BROKEN VALVE SPRING, 2 BENT PISTON RODS, 1 BROKEN PISTON ROD, TWO DAMAGED PISTONS, 2 HEADS REPLACED, GASKETS REPLACED WATER HAS BEEN THE CAUSE BUT THE INTAKE MANIFOLD HAS ALWAYS TESTED OK AS WELL AS THE HEADS. *JB
Mar 16, 2005Tires › Temporary/emergency spare tire SPARE TIRE ON 2000 FORD ECONOLINE 250 WAS DEFECTIVE AND COULD NOT BE USED. OUNG FORD IN CHARLOTTE, NC DENIES RESPONSIBILITY AND FIRESTONE TIRES CLAIMS THAT THE TIRE WAS MANUFACTURED IN 1998 AND IS THEREFORE OUT OF WARRANTY.*AK FIRESTONE LT225/75R16 TUBELESS RADIAL TIRE, 32480UR BM18047. *BF *NM
May 15, 2004 · 44,038 milesSteering › Hydraulic power assist › Pump POWER STEERING LEAKS AND PUMP FAILURE ON 2000 FORD ECONLINE E250. VEHICLES HAD PUMPS RELACED. *AK
Jul 14, 2002 · 43,000 miles · crash · 1 injuryTires › Tread/belt 215/75R/16 FIRESTONE STEELEX WITH OVER 50% OF LIFE LEFT SEPARATED FROM ITS TREAD. THE 3/4 TON VAN SKIDDED ALL OVER THE HIGHWAY, AND FINALLY ROLLED OVER. THE VAN WAS TOTALED. THE TIRE FAILED WHEN LESS THEN MID LIFE WAS LEFT. *NLM
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
EA10003 · opened Apr 13, 2010 · closed Mar 5, 2012HVAC Switch Failures This investigation was opened based on one complaint and reports from four transportation fleets alleging 182 blower motor control switch failures.ODI was concerned that these melting and burning switches could lead to an open flame that could spread throughout the vehicle.After a comprehensive review of all data related to overheating blower motor control switches in the subject vehicles, ODI did not identify the existence of a safety defect trend.ODI reviewed 1,036 complaints, claims, and field reports of failed blower motor control switches and determined that only two fires were likely to have been caused by a failing subject blower motor control switch.This represents a failure rate of 0.2 R/100K on a population of 1,076,975 vehicles that have been in service for up to 14 years.ODI has found that when the subject switches do fail and begin to melt, they are constructed in a manner…
DP05005 · opened Sep 22, 2005 · closed Jan 4, 2006SPARK PLUG EJECTION FROM CYLINDER HEAD ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY…