Model year record

2001 Ford E-250 recalls & problems

The 2001 Ford E-250 has 3 safety recalls and 18 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (10 complaints).

Recalls3safety recalls

Complaints18filed by owners

Crashes · fires1 · 3reported in complaints

Injuries · deaths1 · 0reported in complaints

Safety recalls

Vehicle speed controlOct 13, 2009

Vehicle speed control

Recall 09V3990004,500,000 vehiclesopened after NHTSA action (ODI)

Problem: FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Fix: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Vehicle speed controlFeb 4, 2008

Cruise control

Recall 08V051000225,000 vehicles

Problem: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Risk: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Fix: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Vehicle speed controlAug 3, 2007

Vehicle speed control

Recall 07V3360003,600,000 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Fix: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

E250 Econoline 2WD

14mpg combined

City / highway	13 / 18 mpg
Fuel	Regular Gasoline

4.2 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,800/year to fuel

E250 Econoline 2WD

14mpg combined

City / highway	12 / 17 mpg
Fuel	Regular Gasoline

5.4 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,800/year to fuel

E250 CNG CNG

12mpg combined

City / highway	11 / 14 mpg
Fuel	Natural Gas

5.4 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,850/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Engine and engine coolingEngine; Exhaust system › Emission control › Gas recirculation valve (egr valve)	10	0	2	0	103,338 mi
Tires	2	0	0	0	—
SuspensionRear	2	0	0	0	—
Electrical systemWiring	1	0	1	0	—
Power trainAutomatic transmission	1	0	0	0	—
Air bagsFrontal	1	1	0	1	—
Engine	1	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Engine
SPARK PLUG ON CYLINDER #7 BLEW OUT OF THE CYLINDER HEAD. 2ND TIME THIS HAS OCCURRED ON THIS VEHICLE. REPAIR SHOP STATES IT IS NOT REPAIRABLE THIS TIME APPROX. $3000 FOR NEW HEAD INSTALLED. THIS IS A KNOWN PROBLEM ON THIS 5.4 TRITION ENGINE. FORD SHOULD RECALL TO FIX THIS PROBLEM 130,000 MILES ON THIS TRUCK.
Jan 25, 2017 · 130,000 miles
Engine and engine cooling › EngineFire
I OWN A 2001 F250 FORD WITH AN 5.4L GAS ENGINE . THE REAR PASSENGER SIDE SPARK PLUG BLEW OUT BREAKING IGNITION COIL CAUSING SMALL FIRE . THE THREADS WERE GONE AND HEADS MUST BE REPLACED ON VEHICLE. *TR
Sep 10, 2010 · 128,000 miles
Suspension
WHILE DRIVING AT APPROX 30MPH ON A RURAL ROAD, THE REAR SPARE TIRE FELL OFF OF MY 2001 FORD E250 VAN. TIRE WAS SUSPENDED BELOW REAR VEHICLE. THE LOCAL FORD DEALER IN GRANTS PASS OR SAID THE CABLE WAS CORRODED CAUSING THE TIRE TO FALL OFF. HERE IN SOUTHERN OREGON WE DO NOT USE SALT ON OUR ROADS DURING THE WINTER AND WE HAVE LESS RAINFALL THAN NORTHERN OREGON SO CORROSION FAULT IS QUESTIONABLE. THE COST TO REPLACE CABLE WAS NOT REALISTIC AND IF THEY USED A QUALITY CABLE, THIS SHOULD NEVER HAVE HAPPENED. I WAS LUCKY I WAS NOT DRIVING ON A FREEWAY WHEN THIS HAPPENED. *TR
Jan 10, 2010 · 190,000 miles
Engine and engine cooling › Engine
WHILE DRIVING UNDER NORMAL CONDITIONS, THE #2 SPARK PLUG BLEW OUT OF THE HEAD AND STRIPPED OUT THE THREADS MAKING IT IMPOSSIBLE TO REINSTALL THE SPARK PLUG WITHOUT HAVING MAJOR ENGINE WORK DONE. THIS IS THE SECOND OCCURRENCE IN THIS ENGINE. I HAVE SINCE BEEN INFORMED THAT THIS IS A COMMON OCCURRENCE AND SHOULD HAVE BEEN FIXED BEFORE THE HEADS WERE PUT INTO PRODUCTION. THE FORD DEALERSHIP WANTS APPROXIMATELY $3000.00 TO REPLACE THE HEADS. I HAVE USED AN AFTERMARKET REPAIR KIT APPROVED BY, BUT NOT USED BY FORD. REMOVED PART IS AVAILABLE FOR INSPECTION. I AM LOSING COUNTLESS HOURS OF WORK TIME, I AM SELF-EMPLOYED, AND OVER $100.00 IN TOWING EXPENSES. *TR
Apr 16, 2010 · 150,854 miles
Engine and engine cooling
WAS DRIVING MY 2001 FORD E250 VORTEC V8 AT APPROX. 30 MPH WHEN A SPARK PLUG BLEW OUT OF THE ENGINE. AN HOUR AND A HALF AWAY FROM HOME , IN A NOT SO GOOD AREA OF TOWN. I WAS LEFT STRANDED. 120,000 MILES ON ODOMETER. *TR
Apr 27, 2010 · 120,000 miles
Engine and engine coolingFire
I OWN A 2001 FORD E250 VAN. THIS VAN HAS BEEN A RELIABLE VEHICLE AND MAINTENANCE HAS BEEN EASY AND PREDICTABLE. HOWEVER TODAY THE THIRD SPARK PLUG ON THE PASSENGER SIDE BLEW OUT OF THE CYLINDER HEAD. THOUGH IT WAS A EXHAUST LEAK AT FIRST BECAUSE OF THE SOUND. I PULLED OF THE FREEWAY AND OPENED THE ENGINE COVER. AT THIS POINT I RESTARTED THE ENGINE TO FIND THE EXHAUST LEAK. A LARGE FLAME IMMEDIATELY BEGAN BURSTING OUT OF THE OPEN SPARK PLUG HOLE. ALTHOUGH I WAS ABLE TO TURN THE ENGINE OFF QUICKLY THIS SCARED ME CONSIDERABLY AS I KNOW THEIR ARE FUEL LINES THAT RUN RIGHT BY THE SPARK PLUG. I HAD IT TOWED FROM THEIR TO A SHOP. I HAVE RESEARCHED THIS AND FOUND THAT IT IS A COMMON PROBLEM WITH…
Jun 2, 2001 · 137,000 miles
Suspension › Rear
REAR SPRING SHACKLE RUST OUT. *TR
May 20, 2009 · 126,000 miles
Engine and engine cooling › Exhaust system › Manifold/header/muffler/tail pipe
I STARTED TO HEAR EXHAUST NOISE ON MY 2001 FORD F250 SUPER DUTY WITH A V10 ENGINE WITH ONLY 53,000 MILES. IN CHECKING, I FOUND THAT THE BOLTS THAT WERE HOLD THE EXHAUST MANIFOLD TO THE ENGINE WERE BREAKING OFF AT THE CYLINDER HEAD. 6 OUT OFF 10 CYLINDERS HAD BROKEN BOLTS AND THE OTHER 4 WERE NEAR BREAKING. THERE IS A DANGER OF FIRE IN THE ENGINE DUE TO THE HOT EXHAUST GASES. THE REPAIR IS VERY EXPENSIVE DUE TO HAVING TO REMOVE THE BOLT STUDS STILL IN THE ENGINE HEAD WITHOUT DOING ANY DAMAGE . *TR
Oct 22, 2007 · 53,240 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

HVAC Switch FailuresClosed
This investigation was opened based on one complaint and reports from four transportation fleets alleging 182 blower motor control switch failures.ODI was concerned that these melting and burning switches could lead to an open flame that could spread throughout the vehicle.After a comprehensive review of all data related to overheating blower motor control switches in the subject vehicles, ODI did not identify the existence of a safety defect trend.ODI reviewed 1,036 complaints, claims, and field reports of failed blower motor control switches and determined that only two fires were likely to have been caused by a failing subject blower motor control switch.This represents a failure rate of 0.2 R/100K on a population of 1,076,975 vehicles that have been in service for up to 14 years.ODI has found that when the subject switches do fail and begin to melt, they are constructed in a manner…
EA10003 · opened Apr 13, 2010 · closed Mar 5, 2012
SPARK PLUG EJECTION FROM CYLINDER HEADClosed
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY…
DP05005 · opened Sep 22, 2005 · closed Jan 4, 2006