Model year record

1994 Ford F-350 recalls & problems

The 1994 Ford F-350 has 6 safety recalls and 95 owner complaints on file with NHTSA. The most-reported problem area is service brakes, hydraulic (43 complaints).

Recalls6safety recalls

Complaints95filed by owners

Crashes · fires4 · 6reported in complaints

Injuries · deaths4 · 0reported in complaints

Safety recalls

Vehicle speed controlAug 1, 2006

Vehicle speed control

Recall 06V2860001,200,000 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Risk: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.
Fix: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)

Exterior lightingMay 24, 2006

Exterior lighting

Recall 06E04900027,176 vehiclesopened after NHTSA action (OVSC)

Problem: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Fix: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

SeatsApr 16, 1996

Seats

Recall 96V06400031,000 vehicles

Problem: THE WIRE HARNESS FOR THE POWER LUMBAR FEATURE ON THE SEAT IS UNDERNEATH THE FRONT SEAT CUSHION SUPPORT WIRES. THE SUPPORT WIRES ON THE DRIVER SEAT CAN CONTACT AND DAMAGE THE INSULATION HARNESS RESULTING IN A HIGH RESISTANCE ELECTRICAL SHORT THROUGH THE SUPPORT WIRES.
Risk: CONSEQUENCE OF DEFECT: OVER HEATING OF THE SUPPORT WIRES COULD RESULT, AND MELTING, SMOKE, OR POSSIBLE IGNTION OF THE SURROUNDING MATERIALS COULD OCCUR.
Fix: DEALERS WILL INSPECT THE SEATS ON THE AFFECTED VEHICLES. IF NO DAMAGE IS FOUND, THE DRIVER SEAT WIRE HARNESS WILL BE COVERED WITH A PROTECTIVE CONVOLUTE TUBING, WRAPPED WITH ELECTRICAL TAPE AND THE HARNESS WILL BE REROUTED. IF DAMAGE IS FOUND, THE WIRE HARNESS WILL BE REPLACED.

Parking brakeSep 7, 1994

Conventional

Recall 94V169001835,791 vehiclesopened after NHTSA action (ODI)

Problem: THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Risk: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Fix: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.

Electrical systemMay 25, 1994

Ignition › Module

Recall 94V101000900 vehicles

Problem: IN A HEAVILY LOADED VEHICLE, WHILE IN THE CRUISE CONTROL MODE, THE THROTTLE MAY NOT REDUCE IMMEDIATELY WHEN THE LOAD ON THE ENGINE IS DECREASED (SUCH AS WHEN THE VEHICLE CRESTS A HILL.) THIS CAN RESULT IN INCREASED VEHICLE SPEED WITHOUT PRIOR WARNING.
Risk: THIS CAN RESULT IN LOSS OF SPEED CONTROL OF THE VEHICLE, AND A POSSIBLE ACCIDENT.
Fix: DEALERS WILL REPLACE THE ELECTRONIC ENGINE CONTROL MODULE.

StructureJan 2, 1994

Body › Bumpers

Recall 94V018000370,000 vehicles

Problem: THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.
Risk: IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.
Fix: INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components	43	2	0	2	—
Power trainAutomatic transmission; Clutch assembly	22	1	0	0	—
Engine and engine coolingEngine › Gasoline › Belts and associated pulleys; Exhaust system › Manifold/header/muffler/tail pipe	13	0	0	1	—
SteeringHydraulic power assist › Pump; Hydraulic power assist system	8	0	0	0	—
Vehicle speed controlCruise control	8	0	3	0	—
Fuel system, gasolineDelivery › Hoses, lines/piping, and fittings; Delivery › Fuel pump	6	0	0	0	—
TiresTread/belt	6	1	0	1	—
StructureBody › Bumpers; Body › Door	5	1	0	1	—
Electrical systemWiring › Front underhood; Horn	5	0	3	0	—
SuspensionFront	2	0	0	0	—
VisibilityWindshield wiper/washer; Rearview mirrors/devices › Exterior	2	0	0	0	—
WheelsLugs/nuts/bolts/studs	2	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Vehicle speed control
The contact owns a 1994 Ford F-350. The contact received notification of NHTSA Campaign Number: 09V399000 (Vehicle Speed Control) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Oct 13, 2009
Tires
IN MARCH OF 2014 I PURCHASED A SET OF TIRES FROM TREADWRIGHT TIRES WITHIN A VERY SHORT TIME I NOTICED THE SIDE WALLS CRACKING , BEFORE I COULD GET ANY RESPONSE I HAD A BLOW OUT ON MY RIGHT FROM TIRE AT 60 MPH, I WENT THROUGH TWO MORE SETS WITH THE SAME RESULTS OF SIDE WALL CRACKING BUT NO BLOW OUTS I AM NOW ON MY FOURTH SET , THEY ARE A DIFFERENT MODEL TIRE BUT I AM NOW HAVING A BAD VIBRATION SOME WHAT LIKE I HAD JUST BEFORE THE BLOW OUT ON THE FIRST TIRE SET. TREADWRIGHT IS BEING UNRESPONSIVE NOW TO MY WARRANTY CLAIM AND NOT REFUNDING ME THE COST AND SHIPPING OF THE TIRES.
May 15, 2014 · 260,000 miles
Vehicle speed controlFire
F350 FORD SUPERCREW 4X4 7.3 TURBO DIESEL HAD BEEN SITTING FOR 4 DAYS. WIFE COMES OUT OF HOUSE FINDS TRUCK ON FIRE IN ENGINE COMPARTMENT ON DRIVER'S SIDE. THE CRUISE DEACTIVATION SWITCH WAS DISCONNECTED. *TR
Nov 26, 2008 · 229,000 miles
Power train › Automatic transmission
TL*THE CONTACT OWNS A 1994 F-350. WHILE DRIVING 20 MPH, ALL OF THE SENSORS FAILED AND DAMAGED THE TRANSMISSION. THE CONTACT STATED THAT THE SENSOR LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL TO WARN HER OF THE FAILURE. THE SENSORS AND THE TRANSMISSION WERE REPLACED BY A LOCAL MECHANIC. THE DEALER INFORMATION WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 145,900.
Sep 5, 2007 · 145,900 miles
Vehicle speed control › Cruise controlFire
1994 FORD F-350 HAD AN UNDER HOOD FIRE. *KB A RECALL WAS RECEIVED IN REFERNCE TO FAULTY SPEED CONTROL DEACTIVATION SWITCH FOR THE CONSUMER'S 1995 F-250 BUT NOT THE 1994 F-350. *NM
Apr 11, 2006
Electrical system › Wiring › Front underhoodFire
OUR 1994 FORD F-350 WAS DESTROYED BY FIRE ORIGINATING AT THE MASTER CYLINDER TODAY. THERE WAS A SMALL BRAKE FLUID LEAK NOTICED IN THIS AREA THE OTHER DAY; BUT I WAS UNAWARE OF THE CRUISE CONTROL SHUTOFF SWITCH DANGER UNTIL AFTER THE FIRE. I HAVE RECEIVED NO NOTICE OF A RECALL FOR THIS VEHICLE.
Jul 7, 2005
Service brakes, hydraulic › Antilock/traction control/electronic limited slip
BRAKE FADE. WHEN AT A COMPLETE STOP, PEDAL WILL SINK SLOWLY BUT NOT ENOUGH TO ACTIVE A WARNING LIGHT. IF PEDAL IS NOT PRESSED HARDER VEHICLE WILL ROLL. DEALERSHIP SAYS THIS IS NOT THE FIRST VEHICLE TO DO THIS AND HAS CONTACTED THE MANUFACTURER. VEHICLE STILL DOES IT TO THIS DAY. MASTER CYLINDER HAS BEEN REPLACED TWICE, STILL NOT FIXED.*AK
Aug 23, 2004 · 299,000 miles
Vehicle speed control › Cruise controlFire
WHEN ATTEMPTING TO START THE VEHICLE SMOKE CAME FROM THE ENGINE COMPARTMENT. CONSUMER IMMEDIATELY GOT OUT AND DISCONNECTED THE CRUISE CONTROL CABLE WIRES. THEN, THE SMOKE STOPPED. *AK
Feb 21, 2005 · 150,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

ENGINE COMPARTMENT FIRESClosedLed to recall 05V388000
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED…
EA05005 · opened Mar 22, 2005 · closed Aug 2, 2006
FAILURE OF SERPENTINE BELTClosedLed to recall 96I003001
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
EA95012 · opened Mar 31, 1995 · closed May 28, 1996
TRNS OIL COOLER LINE FAILSClosed
FORD HAS ACKNOWLEDGED A SERIOUS PROBLEM WITH THE ACCESSORY DRIVE BELT SYSTEM (SERPENTINE BELT) IN THE SUBJECT VEHICLES.SEVERAL SERVICE BULLETINS HAVE BEEN ISSUED TO ADDRESS CONCERNS RELATED TO BELT TRACKING OR WEAR.FORD MAINTAINS THAT THE SUBJECT CONDITION DOES NOT PRESENT AN UNREASONABLE RISK TO HIGHWAY SAFETY, ARGUING THAT THE LOW INCIDENCE OF FAILURES ALLEGING SAFETY CONSEQUENCES (I.E., FIRES, FLUID LEAKS, AND/OR ACCIDENTS) IS STRONG EVIDENCE IN SUPPORT OF THIS CLAIM.FORD HAS INDICATED RECEIPT OF 4,445 FIELD REPORTS AND 46891 WARRANTY CLAIMS CONCERNING THE SUBJECT CONDITION. FORD MAINTAINS THAT THE LOW NUMBER OF REPORTED HOSE RUPTURES AND/OR FIRES, RELATIVE TO TOTAL BELT FAILURES, SHOWS THAT THE PROBLEM IS A DURABILITY CONCERN THAT PRESENTS VERY LITTLE RISK TO MOTOR VEHICLE SAFETY.FORD INTENDS TO ADDRESS THE PROBLEMIN A SERVICE BULLETIN SCHEDULED FOR PUBLICATION THE WEEK OF MARCH 13,…
PE94087 · opened Nov 18, 1994 · closed Mar 31, 1995
HYDRAULIC BRAKE LINE CRACKS/LEAKSClosed
There is no summary currently available
PE94004 · opened Jan 25, 1994 · closed Apr 29, 1994