Model year record
The 1997 Ford F-350 has 3 safety recalls and 155 owner complaints on file with NHTSA. The most-reported problem area is service brakes, hydraulic (36 complaints).
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components | 36 | 97,000 mi |
| TiresTread/belt; Sidewall | 32 | 79,000 mi |
| Engine and engine coolingEngine › Gasoline; Engine › Diesel | 27 | 103,526 mi |
| Power trainAutomatic transmission; Automatic transmission › Park/neutral start interlock switch | 22 | — |
| SteeringHydraulic power assist system; Steering wheel/handle bar | 12 | — |
| SuspensionFront; Front › Wheel bearing | 11 | — |
| Vehicle speed controlCruise control | 8 | 105,000 mi |
| Fuel system, gasolineStorage › Auxillary tank › Selector devices; Fuel injection system › Fuel rail | 7 | — |
| Electrical systemWiring › Fuses and circuit breakers; Ignition | 7 | 164,000 mi |
| Exterior lightingTurn signal › Flasher unit; Turn signal | 4 | — |
| Parking brakeConventional; Conventional › Mechanical › Linkage and cable | 3 | — |
| VisibilityPower window devices and controls; Windshield | 3 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
ON THE PASSENGER SIDE OF THE ENGINE PAN THE DIPSTICK ADAPTER WAS MANUFACTURED POORLY. THE OIL FROM THE CRANKCASE HAS CAUSED THE ORING TO SWELL AND LEAK OIL. THE OIL LEAK IS GETTING ON THE STARTER AND CLUTCH. THE OIL CAN CAUSE A SHORT IN THE ELECTRICAL SYSTEM. THIS CAN CAUSE AN ACCIDENT OR DEATH WHILE DRIVING. THE OIL ON THE CLUTCH CAN CAUSE LOSS OF CONTROL AND CAUSE AN ACCIDENT OR DEATH. THE ORING CAN SWELL AND FALL OFF THE ADAPTOR AND BECOME LODGED IN THE OIL PICKUP. THIS WILL STARVE THE MOTOR OF OIL AND CAUSE A CATASTROPHIC FAILURE OF THE MOTOR WHILE DRIVING. THIS CAN CAUSE AN ACCIDENT OR DEATH. DUE TO THE INHERENT POOR DESIGN THE ORING THAT IS SUBMERGED IN OIL SHOULD BE COMPATIBLE WITH…
TL* THE CONTACT OWNS A 1997 FORD F-350. WHILE DRIVING 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT RESTARTED THE VEHICLE AND IT STALLED A SECOND TIME. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND DRIVE HOME. GLADIAN REPAIR SHOP OF PITTSBURG, VIRGINIA WAS MADE AWARE OF THE FAILURE AND SUGGESTED A LIST OF UNKNOWN REPAIRS. CAMEL BROTHERS REPAIR SHOP OF PRINCE GEORGE, VIRGINIA REPLACED THE ACCELERATOR PEDAL POSITION SWITCH SENSOR, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.
TL* THE CONTACT OWNS A 1997 FORD F-350. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY STALL. AFTER RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY. THE CONTACT INDICATED THAT THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CAM SHAFT POSITION SENSOR WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V553000 (ENGINE). THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 92,000.
WE WERE TRAVELLING 65 MPH ON THE 91 FREEWAY TOLL ROAD WHEN MY LEFT REAR TIRE TREAD COMPLETELY SEPARATED FROM THE CASING CAUSING MY VEHICLE TO SWERVE AND JUMP AND CAUSING SIGNIFICANT DAMAGE TO MY VEHICLE, INCLUDING DAMAGING THE FUEL FILL LINE. FORTUNATELY THERE WAS NO FUEL LEAKAGE. THE TIRE DID NOT DEFLATE SO THERE WAS NO PUNCTURE OR OTHER EXTERNALLY CAUSED DAMAGE TO THE TIRE OR VEHICLE. I TOOK THE TIRE TO A BF GOODRICH DEALER ON 10/19/14 FOR INSPECTION, THE TIRE WAS STILL FULLY INFLATED. THE DEALER DEFLATED THE TIRE OUT OF SAFETY CONCERNS. HAD THIS BEEN A FRONT TIRE THE POTENTIAL FOR DAMAGE AND INJURY WOULD HAVE SIGNIFICANTLY INCREASED. THE TIRE WAS PURCHASED IN JULY 2012 AND WAS JUST OVER…
WHILE DRIVING MY 1997 FORD F350 DIESEL PICKUP, PULLING A 36FT GOOSENECK HORSE TRAILER WITH MY TWO TEENAGE DAUGHTERS AND THEIR FOUR HORSES, THE ENGINE IN MY PICKUP SPONTANEOUSLY IGNITED. THERE WAS NO "CHECK ENGINE" WARNING LIGHT, AND THE ENGINE TEMPERATURE GAUGE SHOWED NORMAL. THE ONLY WARNING I HAD WAS SMOKE COMING UP FROM THE LEFT WHEEL WELL UPON SPEED DECREASE TO TURN A CORNER. I WAS TRAVELING A SHORT DISTANCE FROM HOME AND AT A LOW RATE OF SPEED (LESS THAN 40MPH) DURING THE TRAVEL FROM MY HOME TO THE LOCAL FAIRGROUNDS FOR RODEO PRACTICE. AS I TURNED THE CORNER, THE SMOKE BILLOWED. I IMMEDIATELY PULLED OVER AND SMOKE FILLED THE CAB OF THE PICKUP. MY TWO DAUGHTERS AND I QUICKLY EVACUATED…
TL* THE CONTACT OWNS 1997 FORD F-350. THE CONTACT STATED THAT SHE NOTICED THAT THE FRAME WAS FRACTURED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000. *TR
REAR DRIVER SIDE TREAD SEPARATED FROM TIRE AT 75MPH IN THE STATE OF NEBRASKA.22HRS. LATER IN THE STATE OF OHIO THE PASSENGER REAR SEPARATED. CONTACTED FIRESTONE AND THEY WILL NOT TAKE ANY RESPONSIBILITY FOR INCIDENT. *TR
TL* THE CONTACT OWNS A 1997 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE FUEL GAUGE METER SUDDENLY INDICATED THAT THE FUEL TANK WAS EMPTY. THE CONTACT ALSO DISCOVERED THAT THE PANEL FOR THE FUEL TANK WAS DETACHED, CAUSING THE FUEL TANK TO BE SEPARATED FROM THE CHASSIS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 115,000 AND THE CURRENT MILEAGE WAS 146,823.
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY…
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED…